What 85 owners told NHTSA about the 2013 Volvo S60 Recharge

TL* THE CONTACT OWNS A 2013 VOLVO S60. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE DOOR UNLATCHED INDEPENDENTLY AND OPENED WHILE DRIVING 50 MPH. A PASSENGER WAS OCCUPYING THE SEAT AT THE TIME OF THE FAILURE. THE CONTACT WAS ABLE TO MOVE SAFELY OUT OF TRAFFIC. THE CONTACT STATED THAT THE OTHER THREE DOOR LATCHES ALSO FAILED. THE DOOR AJAR INDICATOR ILLUMINATED FOR ALL THE DOORS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 70,000.

NHTSA ODI 11242059

TL* THE CONTACT OWNS A 2013 VOLVO S60. WHILE DRIVING 30 MPH AND APPROACHING AN INTERSECTION, THE AIR BAG WARNING INDICATOR ILLUMINATED AND THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED. THERE WAS NO INJURY. THE POLICE WAS CONTACTED, BUT THE CONTACT WAS UNAWARE IF A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO MCLARTY VOLVO CARS OF LITTLE ROCK (1500 N SHACKLEFORD RD, LITTLE ROCK, AR 72211, (501) 588-7300). THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. PRIOR TO THE FAILURE, THE SAME DEALER DIAGNOSED THE VEHICLE CONCERNING THE AIR BAG WARNING INDICATOR ILLUMINATING. THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC FOR A WHEEL ALIGNMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 270,000.

NHTSA ODI 11232536

THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO A MOM & POP MECHANIC THAT I USE. THEY DETERMINED THAT THE PROBLEM IS THAT THE CAR IS BURNING OIL. IT NEEDED 3 QUARTS. THEY RESEARCHED ON-LINE AND FOUND A 'TECHNICAL JOURNAL' RELEASED BY VOLVO USA TO IT'S SERVICE DEPARTMENTS ENTITLED 'HIGH OIL CONSUMPTION'. 16 DIFFERENT VOLVOS (MODELS AND YEARS) ARE LISTED IN THIS JOURNAL. MY CAR IS ONE OF THEM. VOLVO KNOWS THERE IS A PROBLEM, THE CAR IS UNSAFE TO DRIVE AND YET THERE HAS BEEN NO RECALL FOR THE CARS. LOCAL AND CORPORATE VOLVO DENIED ME FINANCIAL ASSISTANCE WITH THIS BECAUSE THE CAR IS 'TOO OLD, WITH TOO MANY MILES'. BUT IT IS A KNOWN PROBLEM AND THE PROBLEM IS ALSO WITH NEWER MODELS. SO THE FACT THAT MY CAR IS OLDER SHOULDN'T MATTER. MY CAR HAS THE ENGINE THAT HAS THE DEFECT. SHOULDN'T HAVE TO REBUILD THE ENGINE WITH ONLY 116,000 MILES. OBVIOUSLY, IF THEY KNOW OF 16 CARS THAT HAVE THIS ISSUE, IT HAS HAPPENED BEFORE AND WITHOUT BEING FIXED, IT CAN'T BE DRIVEN. BOTH LOCAL AND USA CONTACTS TREATED MY REQUEST AS AN ISOLATED EVENT, NOT A PART OF A BIGGER PROBLEM - ABOUT WHICH THEY HAVE KNOWLEDGE. AGAIN, THIS IS A KNOWN DEFECT!

NHTSA ODI 11231880

THE FRONT PASSENGER DOOR OPENNED WHILE VEHICLE WAS IN OPERATION DUE TO DEFECTIVE SENSOR IN THE DOOR LOCKING SYSTEM

NHTSA ODI 11194802

DRIVING HOME GOING 40 MPH THIS WEEK THE OIL LIGHT CAME ON AND I WAS ALERTED TO STOP THE CAR IMMEDIATELY. THIS FLASHED ON AND OFF TWICE. I THOUGHT IT WAS A GLITCH AS I HAD ANOTHER 1000 MILES TILL MY NEXT OIL CHANGE. I CHECKED THE OIL AND IT WAS DRY. I ADDED A QUART AND DROVE TO GET MY OIL CHANGED. RESULT WAS WHEN THEY DRAINED IT THERE WERE 2 QUARTS THAT DRAINED OUT. THIS INCLUDES THE QUART I HAD PUT IN. MY PRIOR OIL CHANGES I WOULD HAVE BEEN DOWN A QUART AFTER 5000 MILES. THIS IS SHOCKING! SEEING THIS HAS HAPPENED TO OTHERS I'M CONCERNED. LUCKILY I'M NOT HEARING KNOCKS AND MY CAR SEEMS FINE. I CALLED A VOLVO MECHANIC AND HE SAID TO CHECK THE OIL LEVEL EVERY MONTH. MY CONCERN IS THERE WAS NO EARLY WARNING THAT MY OIL WAS LOW. IF THE TIRE LOOSES AIR THERE ARE NON STOP WARNINGS.

NHTSA ODI 11192657

BURNING EXCESSIVE OIL AND NOT GIVING A WARNING LIGHT. DRIVING DOWN THE HIGHWAY WHEN I HEARD A KNOCK COMING FROM THE CAR SO I STOPPED CHECKED EVERYTHING AND NOTICED THERE WAS NO OIL ON THE DIP STICK AND I JUST CHANGED THE OIL 5 WEEKS AGO. THE ENGINE NOW KNOCKS AND CAN BARELY BE DRIVEN.

NHTSA ODI 11192469

WHILE DRIVING ON THE HIGHWAY TO WORK ON 12/3/18 MY VEHICLE DRIVER INFORMATION CENTER DISPLAYED A MESSAGE OF "NO OIL PRESSURE - PARK SAFELY". AS I ATTEMPTED TO PULL TO THE SHOULDER OF THE HIGHWAY THE ENGINE STARTED KNOCKING VERY LOUDLY AND SHUTDOWN! THE ENGINE NOW HAS CATASTROPHIC FAILURE, WITH A TERRIBLE KNOCKING IF THE ENGINE IS STARTED. IT CANNOT BE DRIVEN!

NHTSA ODI 11157262

THE HEATER/AIR CONDITIONER BLOWER FAN DOES NOT WORK. THIS IS NOT A BLOWN FUSE, YET A POSSIBLE BLOWN RESISTOR AND/OR FAILED BLOWER MOTOR. THIS VEHICLE IS 5 YEARS OLD AND HAS 72K MILES; I CANNOT GET HEAT OR AIR CONDITIONING DUE TO THIS ISSUE; WINDOWS ARE FOGGED OFTEN, WHICH REPRESENTS A HAZARDOUS/SAFETY ISSUE. REPLACEMENT OF THE HEATER BLOWER MOTOR AND/OR RESISTOR REQUIRES THE REMOVAL OF THE DASHBOARD AND INSTRUMENT CLUSTER. THIS SHOULD NOT HAPPEN ON ANY 5 YEAR OLD VEHICLE, MUCH LESS A VOLVO. THE REPAIR IS EITHER VERY COSTLY, AT LEAST $700 TO $1100 OR TIME CONSUMING IF I DO IT MYSELF. THAT IS SEVERAL CAR PAYMENTS WORTH FOR A PART THAT SHOULD NOT HAVE FAILED. I HAVE OWNED TWO OLDER VOLVOS (1972, 1986) AND THIS PART NEVER FAILED--AND IF IT DID, THE ACCESS WAS MUCH EASIER (BEHIND THE GLOVEBOX).

NHTSA ODI 11089213

EXCESSIVE OIL CONSUMPTION - BURNING OR CONSUMING AT LEAST 5 QUARTS OF OIL EVERY 2K-3K MILES, BETWEEN OIL CHANGES. OUR ONLY NOTICE IS WHEN OIL IS BELOW 5-QUART RANGE, WHEN WE RECEIVE A DASH WARNING NOTING TO STOP ENGINE. CAR HOLDS 7.25 QUARTS OF SYNTHETIC OIL. WELL KNOW DOCUMENTED THROUGHOUT THE WEB AND KNOWN TO VOLVO MECHANICS, ALTHOUGH MORE RECOGNIZED WITH 2011-2012 S60. STOP ENGINE NOTICE RECEIVED WHEN STARTING CAR. FORTUNATELY ABLE TO UBER TO AUTO SUPPLY AND ADD 5QUARTS TO DRIVE HOME. OCCURRED ON TWO OCCASIONS, WHEREIN THE SECOND INSTANCE WE RESEARCHED, REACHED OUT TO VOLVO MECHANICS AND IN THE PROCESS OF CONTACTING DEALER AND VOLVO FOR FOLLOW-UP. IT APPEARS THAT SEVERAL INSTANCES HAVE RESULTED IN ENGINE FAILURE AND/OR $5K OR MORE IN PERSONAL COST TO FIX PISTON/VALUE ISSUE OR REPLACE ENGINE.

NHTSA ODI 11061411

WHILE DRIVING DOWN THE FREEWAY, THE SUNROOF OF THE CAR SPONTANEOUSLY EXPLODED RAINING BROKEN GLASS INTO THE CAR. THERE WAS NOTHING ABOVE THE CAR AT THE TIME THE SUNROOF EXPLODED (I.E. AN OVERPASS WHERE SOMETHING COULD HAVE FALLEN) NOR WERE THERE OTHER VEHICLES NEAR BY THAT COULD HAVE KICKED A ROCK OR OTHER OBJECT THAT COULD HAVE BROKEN THE GLASS. FURTHER, AFTER PULLING OFF THE ROAD TO EXAMINE THE DAMAGE, THE GLASS HAD EXPLODED OUTWARD, AWAY FROM THE CAR RATHER THAN INWARD, AS WOULD BE EXPECTED IF SOMETHING LIKE A ROCK HAD HIT THE GLASS AND BROKEN IT.

NHTSA ODI 11057798

BACK DOOR ON DRIVERSIDE WILL NOT LATCH SOMETHING ELECTRICAL IS GOING ON I HAD TO TIE THE DOOR UP JUST TO DRIVE ANYWHERE

NHTSA ODI 11055128

WITH LESS THAN 50,000 MILES ON IT, MY S60 JUST COMPLETELY STOPPED WORKING ON MY WAY TO WORK. WHILE PULLING OUT OF MY DEVELOPMENT, THE ENTIRE ENGINE, POWER STEERING - EVERYTHING SHUT DOWN. I HAD TO COAST INTO A TURNING LANE TO PUT ON MY FLASHERS. I HAD NOT GONE MORE THAN 3 MINUTES FROM MY HOUSE. AFTER VOLVO HAD IT FOR A FEW DAYS THEY TOLD ME THAT THE ALTERNATOR BELT HAD JUMPED OFF, HITTING THE ALTERNATOR, FRAYING THE BELT. THIS THEN RESULTED IN THE BELT WRAPPING AROUND ANOTHER PART OF THE ENGINE IMPACTING THE DRIVE BELT. THIS RESULTED IN DAMAGE TO THE DRIVE BELT, ALTERNATOR, 1/3 OF MY ENGINE AND MY CYLINDER BLOCK. VOLVO IS BLAMING THIS ON A FAULTY BELT TENSIONER, YET THEY ARE MAKING ME PAY FOR PART OF THE REPAIR WHICH IS A TOTAL COST OF $6,000. THIS IS CLEARLY A DEFECTIVE PART - EITHER IT WAS INSTALLED INCORRECTLY OR IT WAS NOT PROPERLY BUILT AS A BELT DOES NOT JUST "JUMP". I WAS LUCKY THAT I HAD NOT YET GOTTEN ONTO THE HIGHWAY OR I WOULD HAVE BEEN INJURED ALONG WITH OTHER PEOPLE IF NOT WORSE. THIS IS A HUGE SAFETY CONCERN AND VOLVO DOES NOT SEEM TO WANT TO ADMIT COMPLETE FAILURE HERE. THIS CAR HAS BEEN SERVICED REGULARLY AND AT THE SAME DEALERSHIP.

NHTSA ODI 11047380

TAKATA RECALL THE AIR BAG IN MY CAR IS DAMAGED. IT HAS NOT BLEW UP ON ME YET BUT IT IS DANGEROUS.

NHTSA ODI 11039873

WHILE DRIVING THE CAR ELECTRONICS, SUCH AS THE DASHBOARD LIGHTS, AND RADIO STARTED TO FLICKER OFF AND ON REPEATEDLY AND THE ENGINE CUT OFF. I WAS UNABLE TO CONTROL THE STEERING AND THE CAR CAME TO A COMPLETE STOP. I WAITED A FEW MIN AND WAS ABLE TO START BACK THE CAR AND DRIVE IT. THIS INCIDENT HAS HAPPENED 2 TIMES IN A 6 MONTH PERIOD. THE CAR WAS RECENTLY SERVICED AT AROUND 38,000 MILES AT THE VOLVO DEALERSHIP. THE ISSUE STARTED TO OCCUR ABOUT A MONTH AFTER THE CAR WAS SERVICED.

NHTSA ODI 11025107

WHEN COMING TO A STOP, ONCE STOP HAS COMPLETED, WHILE FOOT IS ON THE BRAKE AT RANDOM TIMES THE VEHICLE WE JOLT FORWARDED. THE JOLT WOULD BE IN COMPARISON TO THE FEELING OF BEING REAR ENDED AT A COMPLETE STOP. I HAVE TAKEN THE CAR TO THE LOCAL VOLVO DEALERSHIP AND THEY CHECKED IT AND CAME BACK WITH NOTHING BEING WRONG. ON THE FOURTH RETURN TO THE DEALERSHIP I ASKED IF ANYONE DROVE THE VEHICLE. THE ANSWER WAS NO. THE SERVICE DEPARTMENT SPECIALIST ASKED IF HE COULD DRIVE THE VEHICLE HOME FOR THE NIGHT. I SAID YES, BECAUSE THIS PROBLEM HAPPENS RANDOMLY. THE NEXT DAY, THE SERVICE SPECIALIST SAID THAT HE EXPERIENCED THE SAME PROBLEM. AGAIN, NOTHING THEY SAID COULD BE DONE BECAUSE NO ERROR CODE APPEARED. THE TRANS JUMPS TOO MUCH, TO BE NORMAL.

NHTSA ODI 10954158

RIGHT FRONT TIRE 235/40/R18/95H DEFLATED WHEN IT HIT A POT HOLE ON LOW SPEED STREET ROAD. INNER SIDEWALL WAS DAMAGED AND TIRE NEED TO BE REPLACED. THIS IS THE FIRST INCIDENT.

NHTSA ODI 10920373

WHILE DRIVING ON A LOW SPEED STREET ROAD, HIT A POT HOLE AND RIGHT FRONT TIRE GOT FLAT. PER VOLVO TECHN FOUND 3 NAILS AND EXCESSIVE SIDEWALL DAMAGE. THIS IS THE THIRD INCIDENT. *TR

NHTSA ODI 10920383

LEFT FRONT TIRE IS FLAT. PER VOLVO TECHNICIAN FOUND NAIL IN EDGE OF SIDEWALL WHICH IS NON REPAIRABLE AND NEED TO BE REPLACED. THIS IS THE FOURTH INCIDENT.

NHTSA ODI 10920387

LEFT FRONT TIRE ALWAYS LOSING AIR. REPLACED BY A NEW TIRE. THIS IS THE SECOND INCIDENT.

NHTSA ODI 10920380

WHEN I AM SOMETIMES EITHER STOPPED AT A STOP SIGN, INTERSECTION OR ON A HIGHWAY, THE TRANSMISSION WILL ALMOST STOP, BUCK AND THEN RESUME DRIVING.

NHTSA ODI 10882830

ON FEB. 3RD, I WAS PULLING INTO A PARKING SPACE IN FRONT OF A STORE WHEN MY S60 R TYPE VOLVO BEGAN TO ACCELERATE ON ITS OWN AND REACHED VERY HIGH RPM. MY FOOT WAS NOT EVEN ON THE ACCELERATOR AS THE CAR NORMALLY IDLES FAST ENOUGH TO PERFORM PARKING MANEUVERS. I HIT THE BRAKE BUT THE CAR CONTINUED TO MOVE. IT JUMPED THE SIDEWALK; HIT THE BUILDING AND PROCEEDED TO DIG A HOLE IN THE FLOWERBED AT THE STORE'S FRONT. THIS ALL HAPPENED IN THE LENGTH OF A PARKING SPACE. I CAN'T REMEMBER WHETHER I SHUT THE IGNITION OFF OR OF THE ENGINE STOPPED ON ITS OWN SHORTLY AFTER THE COLLISION. NEITHER THE AIRBAGS NOR THE PEDESTRIAN AVOIDANCE BRAKING SYSTEM DEPLOYED. I HIT THE BUILDING SO HARD THAT THE BRICK CRACKED INSIDE AND OUT OF THE STRUCTURE. THE DOOR IS STILL INOPERABLE.

NHTSA ODI 10837637

TL* THE CONTACT OWNED A 2013 VOLVO S60. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT DROVE THROUGH A STOP LIGHT AND CRASHED INTO THE SIDE OF ANOTHER VEHICLE. THE HOOD OF THE CONTACT'S VEHICLE FRACTURED AND BECAME DETACHED FROM THE VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER OF THE OTHER VEHICLE SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOT WHERE IT WAS DEEMED DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 41,000. UPDATED 03/16/16*LJ UPDATED 03/22/16.*JB

NHTSA ODI 10822085

AUTOMATIC BRAKES CAME ON WHEN TURNING OUT OF MY NEIGHBORHOOD ONTO A MAIN ROAD. IT'S WAS 7AM AND THERE WERE NO CARS AROUND ME AT THE TOME OF THE INITIAL INCIDENT. THERE WAS NOTHING NEAR ME BUT EMPTY STREETS. I TURNED BACK INTO MY NEIGHBORHOOD TO FIGURE OUT WHAT HAPPENED AND SAW NOTIFICATION OF AUTOMATIC BRAKING ON MY DASHBOARD. I TURNED MY CAR OFF AND RESTARTED IT TO TRY AND LEAVE MY NEIGHBORHOOD AGAIN BUT THE DANCE THING HAPPENED IN THE EXACT SAME SPOT. STILL NO TRAFFIC OR ANYTHING AROUND TO TRIGGER THAT. VERY DANGEROUS!!!

NHTSA ODI 10749252

A ROCK SLIDE LEFT SEVERAL ROCKS ON THE HIGHWAY. I HIT ONE OF THEM AND CRACKED A RIM. SINCE THE VOLVO S60 DOES NOT COME WITH A SPARE TIRE, I WAS LEFT STRANDED IN A CANYON ROAD IN THE RAIN WITH A DISABLED VEHICLE. MINIMAL CELL PHONE RECEPTION MADE CALLING FOR HELP VERY DIFFICULT. VOLVO ASSUMES THAT CALLING THEIR ROADSIDE ASSISTANCE (IF YOU CAN) AND WAITING FOR A TOW TRUCK IS EQUIVALENT TO CARRYING A SPARE TIRE. IT CLEARLY IS NOT AND CAN LEAVE DRIVER'S HELPLESS WHEN A SIMPLE SPARE TIRE WOULD HAVE SOLVED THE PROBLEM. ALTHOUGH PURCHASING A SPARE TIRE IS AN OPTION, IT WOULD CONSUME TRUCK SPACE THAT IS NECESSARY FOR MY SON'S STROLLER. I CAN ONLY CARRY THE STROLLER OR THE SPARE BUT NOT BOTH.. THE CAR SHOULD BE DESIGNED TO CARRY A SPARE TIRE IF NECESSARY. UPDATED 10/9/15 *LN UPDATED 12/21/2015*JS

NHTSA ODI 10744425

NOTE AHORA SE HAN MUDADO AL 755 NW 20 ST MIAMI FL 33127 UNDER NAME GOLDEN GLADE COLLISION CENTER, INSURANCE KNOWS ABOUT AIR BAG IT DOES NOT WORKING PROPERLY,, THEY KNOW ABOUT FRAUD,, INVESTIGATOR KNOWS ABOUT SAFETY PARTS,, INSURANCE PAY THEM WITH FAKE PAPERS,, INSURANCE KNOWS ABOUT STOLEN MONEY THROUGH THE MY ACCIDENT,, INSURANCE, AGRICULTURE GOVERNMENT KNOWS ABOUT UNSAFETY CAR,, THE AUTO SHOP, AAA OF DADE COUNTY IN MIAMI DID ONLY VERY SUPERFICIAL REPAIR WORK ON MY CAR, ALTHOUGH THEY COLLECTED COMPENSATION FROM THE INSURANCE COMPANY. THEY MENTION HAVING REPAIRED MY SEAT BELT SYSTEM, AIR BAGS, AND OTHER MECHANICAL ITEMS, AS WELL AS OUTER BODY PARTS, BUT IT IS OBVIOUS THAT THESE ITEMS HAVE NOT BEEN REPAIRED. THIS WAS CONFIRMED BY VOLVO, MIAMI & MELBOURNE (SEE ATTACHMENT 2 & 3), AND BY J&J IN PALM COAST (SEE ATTACHMENT 4). MORE IMPORTANTLY, NOT ONLY DID THEY DO IMPROPER AND INCOMPLETE REPAIR WORK, BUT THERE IS INDICATION THAT THEY THEMSELVES CAUSED ADDITIONAL DAMAGES TO MY CAR, E. G. THERE APPEAR SCRATCHES, THE REAR BUMPER IS LOOSE, THE ORIGINAL FRONT TIRES WERE REMOVED AND REPLACED WITH TIRES SO WORN THAT IT PUT MY SONS LIFE AND MINE IN GRAVE DANGER! I HAVE SINCE REPLACED THEM BY NEW ONES. FROM WHAT I HAVE BEEN TOLD AT VOLVO, MY CAR HAS SUFFERED A LOSS IN VALUE OWING TO CREATED DAMAGES EQUAL TO AT LEAST $18,000! ON 9/24/14, AAA OF DADE COUNTY PREPARED AN AUTHORIZATION FORM FOR THE PURPOSE OF COLLECTING MONEY FROM THE INSURANCE COMPANY. THIS REPORT STATES THAT ALL DAMAGES HAVE BEEN SATISFACTORILY REPAIRED ON THAT SAME DATE. PLEASE NOTE, HOWEVER, THAT THE PHOTOS, CLEARLY SHOWING THE DAMAGES TO THE CAR, WERE TAKEN BY THE APPRAISER ON 9/26/2014!). IT THUS APPEARS THAT THIS FORM WAS USED FOR THE SOLE PURPOSE OF COLLECTING MONEY, AND NOT, AS STATED, CONFIRMING REPAIR OF THE DAMAGES. PLEASE FEEL FREE TO CONTACT ME SHOULD YOU NEED ADDITIONAL INFORMATION

NHTSA ODI 10730784