What 179 owners told NHTSA about the 2013 Scion Fr-s

On approximately May 27, 2026 I delivered my 2013 Scion FR-S (approx. 105,000 miles) to an authorized Toyota dealer for Safety Recall J02 (NHTSA 18V-772, engine valve spring replacement). I picked it up on June 3, 2026. Immediately the engine ran sluggish and the air conditioning, which had worked, stopped blowing cold. On June 7, 2026 - four days and only a few miles later - the engine spun a rod bearing and began knocking loudly. The vehicle is now inoperable. This recall requires removing and disassembling the engine and is widely documented to cause oil starvation and spun bearings when excess RTV sealant from reassembly clogs the oil pickup screen. My engine ran normally for years and failed within days of the recall repair. The recall repair caused catastrophic engine failure. No crash or injury has occurred; the vehicle is parked to prevent further damage.

NHTSA ODI 11742856

I am submitting this complaint to report a serious safety defect involving a complete loss of steering control in my vehicle, 2013 Scion FR-S. While driving and making a turn, the steering system failed entirely, leaving me unable to control the direction of the vehicle. I retained only braking and acceleration capabilities. There where no waring lights or mechanical indicators of potential or probable failure. As a result of this failure, I was involved in a collision with a nearby vehicle. Following the incident, I researched the issue and discovered a known failure point in the electric power steering (EPS) system, specifically related to the steering column EPS damper bushing. This appears to be a recognized defect that has not been addressed at the factory level, despite the significant safety risk it poses. I believe this issue warrants investigation to prevent future incidents and potential injuries. Thank you for your attention to this matter.

NHTSA ODI 11706415

The car randomly shut off, i started it back up and it has a knock in the engine. Oil is super clean, and changed every 3k miles. I keep up with maintenance on my vehicle. I contacted Toyota and they had a Valve Spring Recall that leads to this very problem but somehow my vehicle isn't covered. I

NHTSA ODI 11703673

The car randomly shut off, i started it back up and it has a knock in the engine. Oil is super clean, and changed every 3k miles. I contacted Toyota and they had a Valve Spring Recall that leads to this very problem but somehow my vehicle isnt covered.

NHTSA ODI 11653904

The contact owns a 2013 Scion FR-S. The contact received notification of NHTSA Campaign Number: 18V772000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. The dealer and manufacturer informed the contact that the recall could not be performed because the engine in the vehicle was not the OEM part. Parts distribution disconnect.

NHTSA ODI 11644023

The contact owns a 2013 Scion FR-S. The contact stated that while his daughter was driving 60 MPH, the engine warning light was flashing. The driver pulled to the side of the road, and the vehicle stalled. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was determined that there was a fractured engine valve spring. The vehicle was not repaired. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not included in NHTSA Campaign Number: 18V772000 (Engine and Engine Cooling). The failure mileage was approximately 84,000.

NHTSA ODI 11628526

sometimes the car randomly stalls out during driving. usually off cold starts if i let it warm up for even 5 minutes it still will stall out sometimes. its not super common id say it does it once every 2 days maybe. the car is also misfiring and ive noticed a large loss of power from the car. it started back in june and i just havent really gotten it fixed yet. usually when im driving itll kind of just buffer and a check engine light is thrown on but it ends up going off after a couple drives.

NHTSA ODI 11619011

The fuel pump stopped working. I was driving to work on a busy highway and without any warning my car started slowing down. There were no warning lights or any indication of a problem. I pressed the gas pedal and no response from the motor. I pushed in the clutch and put my 4 ways on and luckily coasted to a spot I could pull off the road at. Once safe and stopped I tried to start the car again and it sputtered and shut off. The car has been running funny on n off for a little bit I didn't think it could be the fuel pump but It seems it was the problem. The pump wasn't inspected by anyone but after replacing it the car was back to normal.

NHTSA ODI 11554980

The contact's son owns a 2013 Toyota Scion FR-S. The contact stated that while her son was driving at an undisclosed speed, he heard a loud screeching sound located at the hood of the vehicle. The vehicle was diagnosed by an independent mechanic that the clutch release bearing failed and needed to be replaced. The vehicle was not repaired. The dealer nor the manufacturer were not notified of the failure. The failure mileage was approximately 106,000.

NHTSA ODI 11541494

The engine suffered catastrophic failure 2,988 miles after the J02 Saftey recall was performed by Preston Toyota of New Castle, PA. I was travelling at highway speeds when the engine died and would not turn on. I lost all power brakes and could have wrecked and injured myself, others or worse, caused a fatality. The car was towed to a toyota dealership that confirmed the issue was due to the work performed during the recall on the car. The oil light flashed a few times then shut off and then a few seconds later the engine died.

NHTSA ODI 11524410

Vehicle suffered engine failure in line with previous recalled, and subsequently repaired parts. Both Toyota & Subaru have refused to repair. Vehicle is under 100,000 miles.

NHTSA ODI 11523062

Engine stalled won't crank over or run anymore. Mechanic said it was a valve spring issue and vehicle had a recall that entitled engine to be replaced by Toyota.

NHTSA ODI 11520958

The contact owns a 2013 Scion FR-S. The contact received notification of NHTSA Campaign Number: 18V772000 (Engine and Engine Cooling). The vehicle was taken to a local dealer, where it remained awaiting the parts for the recall repair. The contact stated that once the parts for the repair were available, the mechanic informed her that the manufacturer would not be covering the repairs on the vehicle. The vehicle was not repaired. The manufacturer was made not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11505208

Steering locks and binds up and clunks while driving, makes steering. Creates dangerous situations as you cannot steer when this occurs. Diagnosed as a failed electric steering damper, repair performed by owner as dealer quoted over $900 for the repair to replace the entire electric power steering motor. This should be a recall as it affects the steering of the car. This failure occurs so commonly on these cars that owners are repairing it themselves with no manufacturer help. See: https://www.ft86club.com/forums/showthread.php?t=133606

NHTSA ODI 11502374

Engine failure. My safety is compromised by car leaving me stranded at an unpreditable time. Serviced center fixed vehicle twice unsuccecfully because different engine brand but joint partnership. No warning lamps were present before or after failure of engine.

NHTSA ODI 11502515

The contact owns a 2013 Scion FR-S. The contact stated there was an abnormal clunking sound coming from the engine compartment. The contact stated that while driving at an undisclosed speed, the check oil warning light was illuminated while the vehicle was decelerating. The contact drove into a nearby parking lot. The vehicle was towed to the dealer who diagnosed the vehicle and determined that the valve spring had fractured. The vehicle was repaired under NHTSA Campaign Number 18V772000 (Engine and Engine Cooling). The contact stated that 115 miles after the repair there was a knocking noise coming from the engine compartment and the vehicle began to run rough. While driving at highway speeds the vehicle began to feel as if it was decelerating with the accelerator pedal being depressed. The contact had the vehicle towed to the dealer who diagnosed, and the contact was informed that the failure was coming from the bottom of the engine. The vehicle had not been diagnosed or repaired. The vehicle was towed back to the residence. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 115,000.

NHTSA ODI 11496759

Under normal driving conditions, a well maintained 79k car, the joint that holds up cylinder #2 failed, totalling the engine. Thankfully the rod did not kill me.

NHTSA ODI 11493217

It is my belief that the valve spring on the engine broke, even after the recall work had been done. I was getting out of my car and heard, what sounded like, metal under tension popping really loudly. After that the engine made a rattling noise. In hindsight I should have known something was wrong, but I had an oil change at the dealer in 2 days and thought they would hear it. After the oil change they didn't say anything so I felt it was ok. On my way home from work the following day, less than 40 miles after the oil change, the car suddenly completely shut off while I was driving home on the highway. What saved my life was that I was getting off the highway in the right lane and was able to roll the car slightly off the highway. Had this been in any other lane I might have been in an accident. Trying to restart the car on the side of the road it had a terrible knocking noise and sounded like something was spinning freely. I had it towed to the dealer as they had just changed the oil thinking that was it. They "looked" at it a couple days later and said it was a spun bearing and that it was normal wear and tear. The car only has 103,000 miles on it and was driven normally, with regular maintenance. Upon retrieving the car the tow truck driver stated that's not normal to happen, and I noticed the car was in the same place as where I had it towed originally. The dealer never actually inspected or looked at the car and just made the spun bearing assessment without trying to start it, as the battery was dead from trying to restart on the highway. No one has since touched the car, and some research online shows that I am not the only person this has happened to. The recall stated that the valve springs could break while driving and the car would suddenly shut off with no warning. This is exactly what happened, while driving on the highway home. According to the dealer it is a spun bearing but that is not what it sounds like at all. It definitely sounds like a rod.

NHTSA ODI 11492687

The day before the incident, took the vehicle for an oil change at dealership. Driving in a Interstate 8 under construction and vehicle had engine malfunction turning off and also turned off power steering creating difficulty steering, could have created accident on freeway jeopardize my safety and of others. The engine malfunction started by making a rattling sound and turning off the engine. Since my vehicle is Standard/Manual transmission, I stepped on the clutch and the rattling stop making me coast with the moment it had. I removed the clutch to turn on the vehicle and the rattling continued so I put it in neutral, waited to slow down to push the vehicle onto an emergency lane (since the freeway was under construction and the lanes had Jersey Barriers). The problem hasn't been able to reproduce because the vehicle cannot restart, contact local dealership and rejected to perform recall unless I put down $2,000 (November 2018). Sent out to a local shop but didn't have workers with Boxer engine knowledge. Contact DMV for guidance about rejection on recall (which happened again on March 2022) and made another appointment at local dealership. They rejected me again without inspecting recall component and commented that "It was suspicious that you haven't had the recall done on it". There wasn't any check engine light nor abs or any message prior to the failure.

NHTSA ODI 11468640

Was going down the road. To a fast food place. As soon as I turned. A pop happens and the whole car started to shake. All the maintenance was done every 6k miles. Got the car at 32k miles Went to Toyota. And they called and said it was engine failure “mechanical failure” then they called back and said there was no coolant. In my eyes I feel it’s to cover their end to not do a recall.

NHTSA ODI 11464676

2013 SCION FR-S Valve spring recall notice was received in the mail. Recalled valve spring replacement caused engine to seize twice. The first time the engine seized Tustin Toyota admitted fault, noting issue was from recall fix and repaired the engine at no cost. The second time the engine seized Toyota denied responsibility and wanted to charge $5000

NHTSA ODI 11461198

After completing the valve spring recall I got my car back and not 200 miles later the engine started to have rod knock. The Toyota dealership told me that there was now metal in my oil pan and I would need a new engine. This is not a unique issue, it has been happening to hundreds of other cars going through this exact recall, for years now.

NHTSA ODI 11450284

My issue is that I was never notified and I just so happened to look up out of curiosity and I’m upset that something bad could have possibly happened.

NHTSA ODI 11436999

Toyota of El Cajon performed the J02 recall for engine valve springs on August 13, 2020 at 98, 448 mileage. Toyota of El Cajon performed service oil/filter change, coolant change, and multipoint inspection June 2021 (work order 356309). The engine of my 2013 Scion FR-S malfunctioned with a rod knock on July 13, 2021 at 105k mileage, eleven months after J02 recall performed. There were no warnings lamps, oil lights, or any messages prior to failure. The only symptom was the engine rod knock when the car starts. Toyota of El Cajon technician and shop floorman do not know the cause, yet they attempt to deny that this issue relates to the J02 recall. They said it would cost a "couple thousand" to take apart the engine to investigate the cause. They said it would be $9k out of my pocket to replace the short block and would be "terribly expensive". I towed my unfixed vehicle home through my insurance. Vehicle has not been inspected by manufacturer, police, insurance or others. I am contacting Toyota Corporate to create claim #. Engine failure after J02 recall is a well-known issue. There are several other cases of this happening and a Class Action lawsuit due to workmanship error and sealant. This issue should be fixed by the dealership/manufacturer without cost to consumer. The safety, reliability and reputation of the vehicle depends on it. Do the right thing!

NHTSA ODI 11427377

I was driving down the road and felt the car lose power. Shortly, after the traction control and check engine light came on. I pulled over and a I slowed the engine died on me. It took several tries and it finally started and I made it home going about 45. The next day I went to town and as I pulled into a parking lot the engine completely died again. I went to the parts store right next door and the code read can shaft sensor fault. I then slowly drove to a family members house and where we replaced those sensors. This didn't fix anything. I then took it too my mechanic who proceeded to tell me I needed a new engine. There were multiple codes showing with his code reader. I only remember low oil pressure but the oil was full. Tried to drive it back to family members (less than 2 miles)but it didn't make it and I had to have it towed home.i had the valve spring recall repaired in the summer of 2020. My car has 103,000 miles and has had every oil change and had a tune up when I took it to the dealership for the recall.

NHTSA ODI 11426888