What 604 owners told NHTSA about the 2013 Hyundai Santa Fe Hybrid Hev

I WAS DRIVING DOWN A VERY BUSY HIGHWAY ON 12/21/20 AND MY ENGINE COMPLETELY SEIZED, NO WARNING AND INCREDIBLY TERRIFYING. THE CAR CAME TO A VERY SUDDEN STOP, AND WE WERE VERY LUCKY THAT WE WERE NOT KILLED IN AN ACCIDENT. MY CAR BEGAN SMOKING AND IT SMELLED AS IF IT WERE BURNING, WE CALLED THE FIRE DEPARTMENT IMMEDIATELY. I WAS UNABLE TO START THE CAR AGAIN, AND I WAS ALSO UNABLE TO SWITCH IT TO NEUTRAL SO THAT I COULD GET OUT OF THE BUSY TRAFFIC. HAD TO CALL 911 AND PRAY THAT I WAS NOT HIT WHILE WAITING FOR THEM. I TRIED CONTINUOUSLY TO START MY CAR SO THAT I COULD MOVE OUT OF THE TRAFFIC, BUT ENGINE COMPLETELY SEIZED, GEAR WOULD NOT SHIFT TO NEUTRAL, AND WE WERE STRANDED IN A VERY DANGEROUS SITUATION. ONCE COPS CAME WE HAD TO HAVE THE CAR TOWED 40 MILES AWAY AND IT IS NOW SITTING USELESSLY IN THE DRIVEWAY.

NHTSA ODI 11384602

DRIVING CONDITIONS WERE CLEAR WEATHER AND DRY ROADS WITH HEAVY TRAFFIC. WHILE TRAVELING APPROXIMATELY 65 MPH WESTBOUND ON INTERSTATE 4, THE VEHICLE LOST ALL POWER AND ALL THE WARNING INDICATOR LIGHTS CAME ON. FORTUNATELY, WAS ABLE TO COAST ACROSS TRAFFIC TO THE EMERGENCY LANE. TRIED TO RESTART THE CAR AND ALL THE INDICATOR LIGHTS CAME ON BUT THE CAR DIDN'T START. EXITED THE VEHICLE AND WALKED TOWARDS THE FRONT TO SEE SMOKE, AT FIRST, THEN SAW FLAMES COMING FROM UNDER THE ENGINE COMPARTMENT. TRIED TO DIAL 911, BUT HAD WEAK CELL SIGNAL. APPARENTLY 911 WAS NOTIFIED. HIGHWAY PATROL ARRIVED, THE FLAMES WERE SPREADING AND GETTING LARGER. BY THE TIME THE FIRE DEPARTMENT ARRIVED, THE VEHICLE WAS TOTALLY ENGULFED IN FLAMES, WHICH REACHED ALMOST 10 FEET HIGH. THE FIRE FIGHTERS WERE ABLE TO CONTAIN THE FIRE BEFORE IT REACHED THE FUEL TANK, BUT THE VEHICLE AND ITS CONTENTS WERE TOTALLY BURNED. THE VEHICLE WAS A SHELL OF METAL AND ASH WHEN IT WAS TOWED AWAY.

NHTSA ODI 11377033

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. THE CONTACT STATED THEY WOULD HEAR A KNOCKING COMING FROM THE ENGINE OF THE VEHICLE AND THE CHECK 20V1442TH SMOKE BENG SEEN DUE TO A FUEL INJECTOR FAILURE. THE CONTACT STATED THAT EXCESSIVE SMOKE WOULD COME OUT FROM THE EXHAUST OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE ALTERNATOR AND FUEL INJECTOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURES CONTINUED. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP (HUNTINGTON BEACH HYUNDAI ADDRESS: 16751 BEACH BLVD, HUNTINGTON BEACH, CA 92647 PHONE: (714) 594-5604) WHO DIAGNOSED THE VEHICLE WITH THE DIAGNOSTIC CODE FAILURE: P0299, WHICH, STATES THAT THE VEHICLE'S UNDER BOOST TURBOCHARGER HAD FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE HAD NOT BEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED A CASE REGARDING THE MATTER. THE APPROXIMATE FAILURE MILEAGE WAS 131,000.

NHTSA ODI 11319845

THE CAR WENT OF FIRE ON HIGHWAY

NHTSA ODI 11318025

MY HYUNDAI SANTA FE SPORT 2013 MODEL SUDDENLY CAUGHT FIRE WHILE THE VEHICLE WAS IN MOTION. THERE WAS NO ACCIDENT INVOLVED. INCIDENT HAPPENED ON DEC 5, 2019. I AM ATTACHING THE FIRE DEPARTMENT REPORT. MY WIFE WAS DRIVING THE VEHICLE ON CITY ROAD AT A SPEED OF 45 MPH AND SUDDENLY SMOKE STARTED COMING OUT OF HOOD. SHE STOPPED THE VEHICLE, GOT OUT OF IT AND A NEARBY DRIVER CALLED 911. FIRE DEPARTMENT FOLKS REACHED THE LOCATION IN 5 TO 10 MINS AND CONTROLLED THE FIRE.

NHTSA ODI 11298274

2013 HYUNDAI SANTE FE SPORT 'STEERING BEGAN A "HESITATION", "LAG", "PLAY" WHEN TURNING THE STEERING WHEEL EVEN SLIGHTLY IN EITHER DIRECTION.' THE PROBLEM WILL INCREASED AS 3 DIFERENTE CERTIFIED MECHANICS ALREADY INFORMED ME. IT APPEARS ALL THESE PROBLEMS ARE ATTRIBUTABLE TO HYUNDAI'S ELECTION TO USE A CHEAP RUBBER COUPLER BETWEEN THE STEERING COLUMN AND STEERING LINKAGE.' 'THE REPLACEMENT PART IS $6.88. HYUNDAI DEALERSHIPS CHARGE $400-$500 TO REPLACE IT. NHTSA SHOULD HAVE LONG AGO ORDERED HYUNDAI TO EFFECTUATE A REPLACEMENT OF THIS PART WITH ONE MADE OF A MATERIAL THAT WILL NOT DEGRADE AS THIS PART DOES.' HYUNDAI HAS ISSUED SEVERAL EXTENDED WARRANTIES FOR SOME MODELS, EVEN THOUGH THEY KNOW ITS THE SAME PROBLEMS FOR ALL THE MODELS WITH THIS CHEAP RUBBER COUPLER. MOST OF THIS INFORMATION WAS FROM OTHER OWNER'S COMPLAINS, BUT THE NEW INFORMATION I HAVE WAS FROM THE HYUNDAI SERVICE DEPARTMENT. AFTER REPLACING MY ENGINE IN A RECALL (WHERE MY CAR STOPPED AND FIRE STARTED IN MY ENGINE), I FOUND OUT ABOUT THIS RUBBER COUPLER. EVERYONE FROM HYUNDAI SERVICE DEP KNOWS THIS PROBLEM SHOULD BE IN A RECALL, BUT THEY JUST WILL DO NOTHING TO GET IT TO NHTSA. THEY JUST STATED 'NHTSA IS THE ONLY ONE THAT CAN REQUEST FOR A RECALL.' TODAY I SPOKE AGAIN WITH THE HYUNDAI SERVICE MANAGER (AT RED HOAGLAND HYUNDAI WINTER HAVEN, FL ), BECAUSE AFTER CALLING HYUNDAI RECALL DEP AND BEING TOLD THAT 'IF THE SERVICE DEP DECIDES THAT THIS REPLACEMENT SHOULD BE IN A RECALL THEY COULD REQUEST FOR A EXTENDED WARRANTY FROM THE HYUNDAI RECALL DEP, OR NHTSA NEEDS TO PUT A RECALL FOR THIS PROBLEM'. ITS CLEAR THAT EVERYONE KNOWS THIS PROBLEM SHOULD BE IN A RECALL AND THAT IT IS A LIFE THREATENING SITUATION, BUT NO ONE DOES ANYTHING ABOUT IT. ARE YOU GUYS WAITING FOR SOME ONE TO DIE BECAUSE OF THIS PROBLEM BEFORE PUTTING A RECALL? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *PM

NHTSA ODI 11290001

RECALL 112 FOR HYUNDAI SANTA FE SUV. MY CAR HAS HAD ITS FRONT AXEL POP OUT OF THE TRANSMISSION TWICE IN LESS THAN 2 YEARS AND THERE ARE ALSO METAL SHAVINGS IN THE TRANSMISSION. THE RECALL 112 WOULD ADDRESS THESE ISSUES, HOWEVER HYUNDAI HAS TAKEN THE POSITION THAT MY VIN IS NOT COVERED BY THE RECALL. THE AXEL POPPED OUT BOTH TIMES WHILE DRIVING WITH MY WIFE AND KIDS IN THE CAR LEAVING THEM STRANDED. THIS IS A HUGE SAFETY CONCERN AS WE ARE FORTUNATE THAT THEY HAVE NOT BEEN HURT DO TO THIS ISSUE YET. IF SAFETY IS A CONCERN FOR HYUNDAI THE NHTSA SHOULD LOOKING INTO EXPANDING THE RECALL TO ACCOUNT FOR ALL CARS THAT HAVE THIS DEFECT IN THE AXEL AND TRANSMISSION. I AM LOOKING FOR HELP OR COUNCIL TO KEEP HYUNDAI ACCOUNTABLE FOR MANUFACTURING DEFECTS.

NHTSA ODI 11243396

SHORT VERSION- THIS CAR STALLED IN THE MIDDLE OF HIGHWAY TRAFFIC AND WOULD NOT START AGAIN, CREATING A TRAFFIC HAZARD AND REQUIRED TOWING AND HYUNDAI DEALER SAID THERE WAS NOTHING WRONG WITH IT. LATER IT ALSO CAUGHT ON FIRE WHILE MOVING IN A PARKING LOT. THERE WAS SMOKE INSIDE THE CAR AND SMOKING COMING OUT THE FRONT GRILL. IT HAS SEVERAL KNOWN FACTORY MANUFACTURE KNOWN ISSUES THAT ARE WELL DOCUMENTED NATIONWIDE TO CREATE ENGINE FIRES, STALLING, SEIZED ENGINES, JUST LIKE OURS. . HYUNDAI REFUSES TO REMEDY. HYUNDAI ALSO DID A SOFTWARE UPDATE TO PREVENT ENGINE SEIZURE ON AN ALREADY DEAD MOTOR, THAT IS NOT PERFORMING ITS SAFETY FEATURES AS DESIGNED AND THEY WILL NOT REMEDY. THEY ARE CHARGING US FOR THE MOTOR THAT IS STILL DEFECTIVE, AND A SAFETY ISSUE, AND THEY WILL NOT FIX THEIR FACTORY DEFECT LEMON CAR.

NHTSA ODI 11190333

I WAS DRIVING ON A TWO LINE HIGHWAY IN THE COUNTRY AND AS I WENT TO ACCELERATE THE CAR ENGINE QUIT. I COULD NOT RESTART THE CAR. AS I WAS PULLING OFF TO THE SIDE I SAW SMOKE COMING OUT OF THE ENGINE OR HOOD. I GOT MY DAUGHTER AND MYSELF OUT OF THE CAR SAFELY AND ONCE WE STEPPED AWAY FROM THE CAR I SAW AN ORANGE GLOW IN THE ENGINE AND THEN THAT GLOW BURST INTO FLAMES. I WAS IN MOTION AND I WAS DRIVING STRAIGHT WITHOUT TURNING. I BELIEVE I WAS GOING APPROXIMATELY 45 MILES AN HOUR AND ACCELERATED WHEN THE CAR ENGINE DIED. WE DID SMELL GAS AS I WAS PULLING OFF TO THE SIDE OF THE COUNTRY ROAD. I DID NOT HAVE A COLLISION, AN ACCIDENT OR HIT ANYTHING IN THE ROAD. AGAIN, I STARTED TO ACCELERATE AND THE ENGINE DIED. I HAD CONTROL TO GET THE CAR OVER TO THE SIDE OF THE COUNTRY ROAD. I WAS SURROUNDED PRIMARILY BY FARM FIELDS AND NO SIDEWALKS. I WAS ON ROUTE 47 AND I WAS ON THE STRAIGHT PART OF THE HIGHWAY WITHOUT ANY BENDS. I CALLED NINE-ONE-ONE IMMEDIATELY AND THEY DISPATCHED THE FIRE DEPARTMENT AND THE POLICE DEPARTMENT.. THE FIRE WAS EXTINGUISHED AND THE CAR TOWED TO MY PREFERRED AUTO SHOP. THIS HAPPENED ON FRIDAY, JANUARY 11TH, 2019 AT APPROXIMATELY 5:15 P.M. THE TEMPERATURE OUTSIDE WAS APPROXIMATELY 16 DEGREES. I HAVE CALLED MY INSURANCE COMPANY AND THEY ARE SENDING OUT SOMEONE TO LOOK AT IT.

NHTSA ODI 11170112

WHILE DRIVING DOWN A 4 LANE DIVIDED STATE HIGHWAY I STARTED TO HEAR A CLICKING NOISE COMING FROM FRONT OF CAR; BUT CAR WAS STILL RUNNING. GOT WORSE AND STARTED HESITATING A LITTLE AS I PRESSED THE GAS PEDAL. I GOT STOPPED AT A RED LIGHT. WHEN I STARTED OFF FROM BEING STOPPED IT WOULD BARELY GO, THEN IT DIED. WITHIN A FEW MINUTES I NOTICED SMOKE COMING FROM THE ENGINE, GOT OUT AND SAW FLAMES COMING OUT OF GRILL AREA AND UNDERNEATH THE ENGINE AREA. CALLED 911, CAR WAS ON FIRE! I HAVE MANY VIDEOS OF THE INCIDENT. I HAD NO PREVIOUS PROBLEMS WITH THE CAR BEFORE NOW.

NHTSA ODI 11155446

I OWN A 2013 SANTA FE AND I HAVE HAD SEVERAL ISSUES WITH IT, THE ENGINE BEING REPLACED DUE TO FAILING WHILE DRIVING ON THE HIGHWAY, IT WAS SERVICED WITH A FEW OTHER ITEMS DEALER FOUND TO BE NEEDED FOR SOME RECALLS. BUT NONE I CAN RECALL FOR SURE WAS REGARDING THE ENGINE ITSELF, WILL NEED TO CHECK SERVICE RECORDS. THEN LATER IT WAS THE FUEL PUMP(INJECTOR) NEED TO VERIFY SPECIFICS, BUT GAS FUMES AND SMOKE COMING FROM THE ENGINE AND THIS WAS REPLACED, THEN LATER AGAIN HAD TO TAKE IN AGAIN FOR REPAIR DUE TO SERVICE ERROR OF TUBING BEING BENT ECT WHEN INSTALLED, NOTICED THE HIGH AMOUNT OF GAS FUMES AND SMOKE FROM THE ENGINE AND INTO THE CABIN. THIS WAS A FEW MONTHS AGO, THEN NOV 9 2018 MY CAR CAUGHT FIRE AND WAS DESTROYED BY FLAMES. I HAD JUST SECONDS TO PULL THE CAR OVER AND PUT IN PARK, GRAB MY 6 YEAR OLD SON AND GET OUT BEFORE FLAMES COVERED THE ENTIRE ENGINE THEN THE ENTIRE CAR. I WAS IN MY NEIGHBORHOOD AND PULLED OVER ON THE SIDE OF THE STREET. I WOULD LIKE TO START AN INVESTIGATION REGARDING THIS MATTER, I FEAR I AND MY SON COULD HAVE DIED DUE TO THIS KNOWN AND NEGLECTED ISSUE THESE SANTA FE'S HAVE BEEN HAVING. I HAVE HAD THE CAR SERVICED AT THE DEALERSHIP SO I WILL BE ABLE TO SUPPLY THE SERVICE REPORTS AND THE CASE NUMBER FOR THE WILLIAMSON COUNTY SHERIFF REPORT OF THE FIRE AND OTHER DOCUMENTS NEEDED. MY CELL [XXX] PLEASE LEAVE A MESSAGE IF I MISS YOUR CALL AND EMAIL INSTRUCTIONS AND OR INFORMATION NEEDED TO MOVE FORWARD. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11150942

I WAS DRIVING ON THE INTERSTATE ON FRIDAY, JUNE 29, 2018 IN MY 2013 HYUNDAI SANTA FE LIMITED 3.3L V6 AND ALL OF A SUDDEN I HEAR SOMETHING SIMILAR TO A SHOTGUN GOING OFF & MY CAR BEGAN TO STALL AND I NOTICED SMOKE & FLAMES FROM THE SIDEVIEW MIRRORS AS I COULDN'T SEE OUT OF THE REARVIEW MIRROR. LUCKILY NO ONE BEHIND ME WAS INJURED BEHIND ME SINCE ENGINE PARTS & SMOKE FROM THE OIL POURING OUT ON THE SIDE OF THE BLOCK. ONCE I WAS ABLE TO PULL OVER ON THE EXIT RAMP I NOTICED MY VEHICLE WAS ON FIRE & LUCKILY I WAS ABLE TO EXTINGUISH THE FLAMES. I CALLED A WRECKER SERVICE & UPON FURTHER INSPECTION I NOTICED A BIG GAPING HOLE IN THE ENGINE BLOCK. MY CAR WAS TAKEN TO THE LOCAL DEALERSHIP CRENSHAW HYUNDAI ON JULY 3, WHERE IT HAS REMAINED & NO ONE HAS CONTACTED ME SINCE. I HAVE CONTACTED THEM ON SEVERAL OCCASIONS & HAVE MET WITH THE SERVICE MANAGER WHO ADVISED ME THAT HYUNDAI INSTRUCTED HIS TEAM TO INSPECT THE VEHICLE FOR NEGLIGENCE ON MY BEHALF WHICH THEY DID NOT FIND AND WAS BACKED UP BY ALL SERVICE RECORDS.

NHTSA ODI 11142268

TL* THE CONTACT OWNED A 2013 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE CONTACT NOTICED SMOKE COMING THROUGH THE AIR VENTS. HE THEN OBSERVED FLAMES UNDER THE HOOD. A POLICE REPORT WAS FILED. THE LOCAL FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN AUTO SHOP WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS A TOTAL LOSS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000.

NHTSA ODI 11140657

I WAS DRIVING THE VEHICLE TO WORK AND THE ENGINE STOPS AND ALL THE DASH LIGHTS ARE ON. THE VEHICLE WILL NOT EVEN TURN OVER LET ALONE START. I HAD AAA TOW THE VEHICLE TO MY HOUSE AND AFTER PUTTING A WRENCH ON THE CRANKSHAFT PULLEY BOLT AND PHYSICALLY TRYING TO TURN THE MOTOR OVER I REALIZED THE MOTOR IS SEIZED. I HAD NOTICED AFTER DRAINING MY OIL DURING ALL THE PRIOR OIL CHANGES, THE VEHICLE WAS LOSING OIL. THERE IS NO SIGNS OF THE ENGINE LEAKING OIL EXTERNALLY SO IT HAS TO BE AN INTERNAL MALFUNCTION ON THE ENGINE. KNOWING THIS I WOULD CHECK AND ADD OIL AS NEEDED BETWEEN Y OIL CHANGES. THE ENGINE HAD PLENTY OF OIL BEFORE AND AFTER THE ENGINE FAILED. SOMETHING WAS WRONG WITH MY ENGINE FROM DAY ONE FROM THE FACTORY. I GUARANTEE THIS ENGINE FAILED BECAUSE OF THE FACTORY THAT ASSEMBLED THE ENGINE.

NHTSA ODI 11076135

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. WHILE STATIONARY, THE VEHICLE WOULD NOT START WHEN PROMPTED. UPON EXITING THE VEHICLE, THE CONTACT NOTICED THAT FLUID LEAKED INTO THE DRIVEWAY OF THE CONTACT'S HOME AND SMOKE EMITTED FROM THE VEHICLE. FUTHERMORE, WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. WOODHOUSE HYUNDAI IN OMAHA, NEBRASKA (LOCATED AT 11540 WEST DODGE RD, 68154) WAS MADE AWARE OF THE FAILURE AND HAD PREVIOUSLY REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 17V226000 (ENGINE AND ENGINE COOLING). THE DEALER REQUESTED THAT THE VEHICLE BE BROUGHT BACK IN FOR INSPECTION. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 32,700.

NHTSA ODI 11014194

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING AND THE BRAKE PEDAL BECAME DIFFICULT TO DEPRESS. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE AND A BURNING ODOR WAS PRESENT INSIDE THE CABIN. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER (DORAL HYUNDAI LOCATED AT 10285 NW 12 ST DORAL, FL 33172) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

NHTSA ODI 10993939

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V226000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE DRIVING APPROXIMATELY 65 MPH, THE SPEED REDUCED SIGNIFICANTLY AND THE CHECK ENGINE AND ENGINE COOLING WARNING INDICATORS ILLUMINATED. SMOKE APPEARED FROM THE REAR OF THE VEHICLE. THE CONTACT PULLED OVER AND TURNED OFF THE VEHICLE. THE CONTACT RESTARTED THE VEHICLE A COUPLE OF TIMES; HOWEVER, THE WARNING INDICATORS REMAINED ILLUMINATED AND THE ENGINE MADE A KICKING NOISE. THE VEHICLE SHUT DOWN AND WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND OPENED CASE NUMBER: 10192460. THE APPROXIMATE FAILURE MILEAGE WAS 65,109. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI 10981324

WHILE DRIVING ON HIGHWAY AT 70MPH THE TIRE PRESSURE LIGHT KEPT BLINKING, SO I PULLED OVER TO THE SHOULDER JUST AS THE TIRE BECAME FLAT. I CALLED A TOW TRUCK I WAS NOT NEAR A TOWN SO IT TOOK AN HOUR FOR SOMEONE TO GET TO ME. HOWEVER THE TIRE WAS REMOVED AND I NOTICED THAT A CHUNK OF TIRE WAS MISSING OFF THE TIRE SMALLER THAN AN INCH HOWEVER YOU COULD SEE DOWN TO THE WIRES.

NHTSA ODI 10948662

TL* THE CONTACT OWNED A 2013 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKES FAILED TO RESPOND WHEN DEPRESSED AND CAUSED THE VEHICLE TO CRASH INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE CONTACT WAS UNSURE IF A POLICE REPORT WAS FILED. THE VEHICLE WAS DEEMED DESTROYED AND TOWED TO A JUNK YARD. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

NHTSA ODI 10913736

THE ENTIRE INSIDE OF MY SANTA FE IS DAMAGED DUE TO A FIRE IN THE SEAT. MY CAR WAS LOCKED OVERNIGHT AND PARKED IN MY DRIVEWAY. THE DOORS WERE LOCKED AND THERE IS NO SIGN OF FORCED ENTRY. THE FRONT DRIVERS SIDE SEAT IS TOTALLY BURNED OUT AND DAMAGE TO THE DRIVERS DOOR IS MELTED. THERE IS SMOKE DAMAGE IN THE ENTIRE VEHICLE. THE VEHICLE HAD BEEN PARKED FOR OVER 12 HOURS AND NOT DRIVEN. WE HAVE CALLED THE POLICE AND THY SAY THAT NO CRIME OCCURRED AND THAT THE FIRE STARTED IN THE SEAT. THIS IS VERY DANGEROUS AND IT MUST BE RELATED TO THE HEATED SEAT FUNCTION IN THIS CAR.

NHTSA ODI 10905594

DRIVING 15-17 MILES AN HOUR, RUSH HOUR, ON STREET TRIED TO STOP, BUMP CAR IN FRONT, DEALER SAID I NEED AN MASTER CYLINDER AND AN BREAK BOOSTER, BROUGHT MY CAR 4/9/16, CERTIFIED USED CAR, NOW I HAVE TO PAY 1200.00 TO GET THE BRAKES FIX PLUS 500.00 DEDUCTIBLE FOR ACCIDENT PLUS 100.00 DEDUCTIBLE FOR EASYCARE, THIS IS NOT FAIR.

NHTSA ODI 10872805

TL* THE CONTACT OWNS A 2013 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE ROLLED DOWN THE DRIVEWAY WITHOUT BEING PROMPTED. THE VEHICLE ROLLED OVER THE CONTACT'S ARM AND CAUSED SECOND DEGREE BURNS. MEDICAL ATTENTION WAS REQUIRED. THE ISSUE RECURRED, BUT THE CONTACT WAS ABLE TO DEPRESS THE BRAKE PEDAL AND STOP THE VEHICLE THE SECOND TIME. IN ADDITION, THE CONTACT STATED THAT A PASSENGER BECAME TRAPPED IN THE VEHICLE WHILE IT ROLLED DOWN THE DRIVEWAY INTO THE YARD OF ANOTHER PERSON'S RESIDENCE THE FIRST TIME. THE VEHICLE WAS DIAGNOSED, BUT THE DEALER COULD NOT REPAIR THE VEHICLE WITHOUT IT BEING INSPECTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 59,000.

NHTSA ODI 10824098

GOING ON SIDE STREET AT 25MPH WHEN CAR SUDDENLY LOST CONTROL THEN HIT A CAR TIRE ON THE RIGHT OF THE VEHICLE BUT THEN ROLLED OVER ON ITS HEAD. SIDE AIR BAGS DEPLOYED BUT NOT DRIVER AIR BAG. THIS CAR HAS TO BE UNSTABLE TO HIT ANOTHER CAR ON THE SIDE (SEE PICS) AND OVERTURN. BESIDES, THERE ARE ALREADY RECALLS ON SOME SANTA FE SPORT FOR CRACKED AXLES AND BAD TIRES......UPDATED 12/03/15*BF *TR

NHTSA ODI 10789544

I WAS DRIVING WEST ON U.S. HWY 80 AT ABOUT 30 MPH, AFTER PULLING OUT OF A PARKING LOT ABOUT 1 BLOCK BEFORE I LOST CONTROL OF MY 2013 HYUNDAI SANTA FE, AT AN INTERSECTION. IT MADE A SHARP RIGHT TURN WITHOUT MY HELP AT ALL. AFTER HITTING ANOTHER VEHICLE AND THEN JUMPING A LARGE CURB, I CAME TO STOP ABOUT 18" FROM A SMALL TREE. I WAS COMPLETELY TRAUMATIZED. THE RIGHT FRONT WHEEL HAD A BLOW OUT FROM THE OUTSIDE SIDE WALL OF THE TIRE. THE MECHANIC SAID IT LOOKED SLASHED. THE BIG QUESTION IS, DID THE BLOW OUT OCCUR AT THE TIME MY VEHICLE MADE THE SHARP RIGHT TURN AT THE INTERSECTION, OR DID IT OCCUR WHEN IT HIT THE CURB? I DON'T KNOW, BUT I FEEL SOMETHING HAPPENED TO CAUSE THAT SHARP RIGHT TURN IN THE FIRST PLACE. I HAD THE MECHANIC CHECK OUT THE RIGHT FRONT WHEEL AREA (AXLE, ETC). THEY SAID THEY COULDN'T FIND ANYTHING WRONG WITH THE VEHICLES PARTS, THAT WASN'T CAUSED BY THE ACCIDENT. THIS MAKES ME MORE CONVINCED IT HAS TO BE THE TIRE. THIS IS THE SECOND TIRE THAT HAS BLOWN OUT ON THE OUTSIDE WALL OF THE TIRE SINCE I PURCHASED THIS VEHICLE IN 2013. THE OTHER BLOW OUT WAS FROM A NAIL GOING THROUGH THE OUTSIDE WALL. I ONLY HAVE 11,045 MILES ON THIS VEHICLE. TIRES ARE A KUMHO, CRUGEN, P235/55R19, 101H SL BSW OE (INFORMATION COPIED FROM A DISCOUNT TIRE RECEIPT WHEN THE FIRST BLOW OUT WAS REPLACED 5-22-15). I AM AFRAID TO GET BACK IN THIS VEHICLE BECAUSE I DON'T KNOW WHAT CAUSED COMPLETE LOSS OF CONTROL. I WILL TRADE IT IN ON A DIFFERENT VEHICLE. I'M AFRAID OF HYUNDAI'S AND KUMHO TIRES!

NHTSA ODI 10788476

WHILE TURN LEFT INTO A SUBDIVISION THE STEERING WOULD NOT RE-CENTER THUS THE CAR RAN OVER A COUPLE OF LARGE STONES LINING THE ROADWAY AT THE ENTRANCE. THE ABS DID NOT ENGAGE. FINALLY THE CAR STOPPED ABOUT 30 FEET LATER. I WAS ABLE TO FINALLY STEER THE CAR BACK ON TO THE STREET. THERE IS DAMAGE TO THE UNDERCARRIAGE, THE INNER WHEEL WELL ON THE RIGHT SIDE WAS TORN OFF, THE LEFT FRONT AIR DAM, THE EXHAUST SYSTEM, THE RIGHT FRONT WHEEL WAS DAMAGE, AND A FLAT TIRE.

NHTSA ODI 10761903