What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

The engine malfunctioned and faulty rear seat belt, it is not available for inspection because it started a fire that destroyed by car. The remains of the car is at a savage yard. We were put at risk because we were driving/riding in the car at the time it starting burning. We were able to pull the car over and park it in a gas station parking lot before it became fully engulfed in flames. I am reaching out to Ford. Since it was not an accident involved, the fire department inspected the vehicle and determine the fire started in the engine. Insurance representative has determined it is a total loss. There were no warning lamps or messages from the car. However, what caused us to detect something was wrong was the thick smoke started filling the car's cabin at which time we immediately pulled over. When we stopped the car, actual flames came from under the hoods towards the windshield of the car and we proceed to exit the car. My granddaughter in the back seat was having a hard time releasing herself from her seat belt.

NHTSA ODI 11614780

THE DASH LIT UP NOTIFYING OF A PARKING BRAKE ERROR WHILE DRIVING. GOT HOME, PARKED CAR, TURNED CAR OFF. WENT INSIDE FOR ABOUT TWO MINUTES. WHEN CAME BACK OUTSIDE, THERE WAS SMOKE ROLLING OUT OF THE WINDOW. PUT FIRE OUT. AFTER EXAMINING, THE FIRE APPEARED TO HAVE STARTED FROM SOMETHING ELECTRICAL IN THE CENTER COUNSEL ON THE RIGHT SIDE. IT CAUGHT THE SEAT ON FIRE, MELTED THE COUNSEL, AND THE ROOF. NO SMOKING OF ANY SORT HAS BEEN ALLOWED IN MY CAR SINCE I GOT IT. IT WAS STATIONARY WHEN THE FIRE STARTED, BUT IT WAS IMMEDIATELY AFTER BEING DRIVEN.*DT*JB

NHTSA ODI 11373410

TL* THE CONTACT OWNED A 2013 FORD FUSION. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE MADE POPPING SOUNDS AND SMOKE APPEARED UNDERNEATH THE HOOD. ALSO, THE OVERHEATING INDICATOR ILLUMINATED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND, WITHIN SECONDS, BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOTALED AND TOWED TO A TOW YARD. THE CONTACT CALLED A PLUS AUTO SALES AT 513-759-5470 (LOCATED AT 9253 CINCINNATI COLUMBUS RD, WEST CHESTER, OH 45069) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 16V875000 (SEAT BELTS) AND 17V209000 (ENGINE AND ENGINE COOLING) THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 90,000.

NHTSA ODI 11270234

MY MID SEAT BELT ON BACK SEAT TIGHTEND UP, NOT ABLE TO RELEASE ON THE BUCKLE MY SON GOT CAUGHT I HAD TO CUT THE BELT HE WAS SUFFOCATING HIM, NEED TO REPLACE THE BELT COVINA FORD SAID IS ABOUT $400, TO REPLACED,

NHTSA ODI 11234182

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING 25 MPH, THE CONTACT'S VEHICLE WAS REAR ENDED. THE CONTACT STATED THAT THE SEAT BELTS FAILED TO RESTRAIN THE OCCUPANTS. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE RIGHT SHOULDER, TWO BULGING DISKS IN THE LOWER BACK, A CONCUSSION, WHIPLASH, AND NECK INJURIES. THE CONTACT'S HUSBAND ALSO SUSTAINED A CONCUSSION, WHIPLASH, AND INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCATION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI 11120189

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT WAS ALERTED BY SOMEONE THAT SMOKE WAS NOTICED FROM THE REAR OF HIS VEHICLE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. THE CONTACT OPENED THE HOOD AND SAW FLAMES TOWARDS THE BACK OF THE ENGINE COMPARTMENT. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS DRIVEN TO A GROCERY STORE PARKING LOT WHERE THE FIRE RESTARTED. THE CONTACT CALLED THE FIRE DEPARTMENT, BUT THE FIRE EXTINGUISHED ON ITS OWN BY THE TIME THE FIRE DEPARTMENT ARRIVED. A FIRE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED THE HUNTINGTON BEACH FORD DEALER AT 714-842-6611 (LOCATED AT 18255 BEACH BLVD, HUNTINGTON BEACH, CA 92648) AND WAS INFORMED THAT THE TECHNICIAN WOULD CALL HIM BACK. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED RECEIVING NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V875000 (SEAT BELTS) AND 17V209000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS APPROXIMATELY 92,520. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 11083609

TAKATA INFLATORS I COULD NOT SEE HEADLIGHT WOULD GO OFF AND ON AND MY STEERING WHEEL WOULD SHAKE UNCONTROLLABLY CAME CLOSE TO 3 FATAL ACCIDENTS EVERY TIME THINGS WENT WRONG I WAS DRIVING ON THE FREEWAY ME AND MY KIDS CAME SO CLOSE TO LOOSING OUR LIVES

NHTSA ODI 11079556

TL* THE CONTACT OWNED A 2013 FORD FUSION. WHILE TRAVELING HIGHWAY SPEEDS, THE PASSENGER NOTICED AN ABNORMAL BURNING ODOR. THE CONTACT TURNED ON THE AIR CONDITIONER AND SMOKE EMITTED INTO THE CABIN OF THE VEHICLE. THE VEHICLE LOST POWER AND THE CONTACT WAS ABLE TO SEE FLAMES FROM THE SIDE MIRROR. THE PASSENGER WAS ABLE TO EXIT THE VEHICLE. WHEN THE CONTACT ATTEMPTED TO EXIT THE VEHICLE, THE DOOR JAMMED. THE CONTACT HAD TO APPLY EXCESSIVE FORCE IN ORDER TO EXIT THE VEHICLE. UPON LEAVING THE VEHICLE, IT BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FLAMES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE YARD WHERE IT WAS DEEMED DESTROYED. PRIOR TO THE FAILURE, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V597000 (AIR BAGS, SEAT BELTS), 15V246000 (LATCHES/LOCKS/LINKAGES), 16V875000 (SEAT BELTS), AND 17V209000 (ENGINE AND ENGINE COOLING). SANTA MONICA FORD LINCOLN IN SANTA MONICA, CA PERFORMED THE REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000.

NHTSA ODI 11051024

TL* TAKATA RECALL. THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT THE SERVICE ENGINE INDICATOR ILLUMINATED SEVERAL TIMES. THE CONTACT STATED THAT THE VEHICLE KEPT OVERHEATING AND WAS SLOW TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COMPUTER NEEDED TO BE REPLACED AND RECOMMENDED THAT THE VEHICLE BE TOWED TO THE DEALER. THE DEALER (COUNTRY FORD, 95 GOODMAN RD E, SOUTHAVEN, MS 38671, (662) 349-4300) MADE NO MENTION OF NHTSA CAMPAIGN NUMBER: 17V209000 (ENGINE AND ENGINE COOLING). THE CONTACT WAS NOT INFORMED THAT THE RECALL NEEDED TO BE COMPLETED. THE DEALER REPLACED THE COMPUTER AND DID NOT MENTION ANYTHING ABOUT NHTSA CAMPAIGN NUMBERS: 14V597000 (AIR BAGS AND SEAT BELTS), 15V246000 (LATCHES/LOCKS/LINKAGES), AND 16V875000 (SEAT BELTS). IN ADDITION, THE DEALER MADE NO MENTION OF THE MANUFACTURER SERVICE CAMPAIGN (15R01) FOR THE EPS MOTOR BOLTS - REGIONAL AND (14N02) FOR THE EXTENDED WARRANTY COVERAGE FOR PCM RE-PROGRAMMING. WITHIN THREE WEEKS OF THE DEALER'S REPAIR, THE CONTACT TURNED ON THE HEAT AND NOTICED A STRONG ODOR COMING FROM THE VENTS. THE VEHICLE STARTED SMOKING UNDER THE HOOD AND CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES AND THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE BY THE INSURANCE COMPANY WHO WAS TO INVESTIGATE THE CAUSE OF THE FIRE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI 11047018

RECALL: SEAT BELT ASSEMBLIES THAT DO NOT ADEQUATELY RESTRAIN THE OCCUPANT IN A CRASH CAN INCREASE THE RISK OF INJURY. CAR ACCIDENT. HIT FROM BEHIND AND THE DRIVER SEATBELT CAME APART

NHTSA ODI 11041932

CAR STARTED ON FIRE WHILE DRIVING ON THE HIGHWAY GOING HOME FOR NO REASON LUCKY TO GET OUT

NHTSA ODI 10969840

ON DECEMBER 5TH 2016 AT APPROXIMATELY 6:15, MY VEHICLE WAS INVOLVED IN A VIOLENT REAR END ACCIDENT. A 1980 STEEL PICK UP RAN INTO THE BACK OF MY STATIONARY 2013 FORD FUSION. CAUSING MAJOR REAR END DAMAGE AND PHYSICAL INJURY TO THE OCCUPANTS OF THIS STATIONARY CAR. MY MOTHER WAS PROPERLY PLACED IN HER PASSENGER SEAT'S SEAT BELT. HOWEVER, HER RIGHT ARM WAS DAMAGED DUE TO IMPROPER SUSPENSION UPON IMPACT. AS A RESULT SHE NO LONGER HAS USE OF HER RIGHT HAND DUE TO NERVE DAMAGE.

NHTSA ODI 10960265

TL* THE CONTACT OWNED A 2013 FORD FUSION. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V597000 (AIR BAGS, SEAT BELTS), 15V246000(LATCHES/LOCKS/LINKAGES), AND 15V250000 (STEERING). THE CONTACT WAS UNABLE TO RECEIVE THE RECALL REPAIRS DUE TO THE PARTS NOT BEING AVAILABLE FOR SEVERAL MONTHS. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE CONTACT LOST CONSCIOUSNESS AND CRASHED INTO TWO VEHICLES AND INTO A DITCH. NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED HEAD AND NECK INJURIES AND RECEIVED MEDICAL TREATMENT. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

NHTSA ODI 10747837

HIT DEER GOING 45 MILES AN HOUR WHEN HE RAN OUT IN FRONT OF ME. VEHICLE CHECK WAS DEPLOYED. SAID AIRBAG ACTIVATED. NEITHER THE AIRBAG WENT OFF NOR DID THE SEAT BELT RESTRAINT TIGHTENED. OBTAINED 7000.00 IN FRONT END DAMAGE INCLUDING RADIATOR, HOOD FENDERS AND PUSHED IN DRIVER DOOR. POLICE OFFICER CHECKED THE AIRBAG FOR ME AND STATED THAT I NEEDED TO LET THEM KNOW IT SHOULD HAVE DEPLOYED AND DID NOT. HAD VEHICLE TOWED AND CALLED PECK FORD. AFTER 3 WEEKS IN THE AUTO REPAIR STATED THEY RAN A CHECK AND IT SEEMED THE AIRBAG WAS FINE. THEY HAD TO DO A REALIGNMENT AND THE RADIATOR HOSE AND BOLTS SNAPPED OFF PLUS THE BODY WORK. FORD STATED IT WAS IN A RECALL BUT THAT THEY WOULD NOT HAVE THE PARTS FOR A YEAR. I TOLD THEM I WAS AFRAID TO DRIVE IT AND TOLD THEM ABOUT THE ACCIDENT AND THE FAILURE OF THE AIRBAG TO DEPLOY NOR THE RESTRAINTS. PECK FORD ALSO STATED THAT THERE WAS NOT MUCH THEY COULD DO UNLESS THE AIRBAG LIGHT STAYED ON WHEN CAR WAS OPERATING. PREVIOUSLY, IN SUMMER OF 2014, I WROTE THE WARRANTY CENTER BECAUSE MY HEADLINER HAD TO BE REPLACED DUE TO WRINKLING AND FALLING IN FRONT. THEY REPLACED THE HEADLINER BUT IT STARTED HAPPENING AGAIN SO I WROTE THEM IN SUMMER OF 2014. THEY STATED THE ONLY RECALL THEY HAD WAS FOR THE AIRBAG AND THAT I SHOULD STOP DRIVING THE CAR IMMEDIATELY AND CALL FORD. I CALLED THEM AND THEY SAID THERE WAS NO PARTS AVAILABLE AND STATED THEN THAT THE AIRBAG LIGHT HAD TO BE ON. FAST FORWARD TWO MONTHS LATER AND I HIT A DEER, NO AIRBAG DEPLOYED, THE RESTRAINTS DID NOT WORK. FEARFUL WHEN DRIVING THE CAR NOW AND NO HELP AVAILABLE. DRIVER SEAT NOW SAGS TO ONE SIDE

NHTSA ODI 10706734

WAS DRIVING APPROXIMATELY 50 MILES PER HOUR WHEN DEER HIT CAR IN FRONT . THE IMPACT TOOK OUT FRONT BUMPER BUMPER GUARD HOOD LEFT FENDER AND LEFT DOOR. THE RADIATOR BOLTS CRACKED AND DROPPED THE RADIATOR. I WAS THROWN FORWARD BUT NEITHER SEAT BELT TIGHTENED OR AIR BAG WENT OFF. THE SYSTEM RADIO WENT INTO SYSTEM CHECK AND CONTINUALLY CHECKED , STATING AIRBAG DEPLOYED BUT IT DID NOT DEPLOY. ONE SIDE OF THE SEAT ON DRIVERS SIDE WILL NOT RISE WHEN TRYING TO BRING SEAT UP AND SO SEAT SAGS TO LEFT OFFICER THAT I CALLED TO THE SCENE STATED THAT IT LOOKED LIKE THE AIRBAG STARTED TO DEPLOY BUT WHEN I GOT THE CAR FIXED THEY SAID THEY FOUND THE AIRBAG STILL IN TACK. BOTH PARTIES POLICE AND MECHANIC STATED THAT THEY WERE SURPRISED AIRBAG DID NOT GO OFF. I CALLED FORD ABOUT THE RECALL AND THEY SAID CANNOT REPAIR UNLESS AIR BAG LIGHT IS ON . I WROTE SAFETY FOR FORD AND THEY SAID THE SAME THING. I CALLED DEALER BACK AND THEY STATED THAT I CANNOT BRING IN TILL LETTER ARRIVES BECAUSE THE PARTS TO REPLACE WOULD NOT BE IN TILL END OF 2015. *JS

NHTSA ODI 10681871