What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

I HAVE HAD REPEATED PROBLEMS WITH THIS VEHICLE, AND NOW IT IS ON MY CREDIT RECORD BECAUSE IT IS BEYOND REPAIR, AND I RETURNED IT TO THE FINANCE COMPANY WHERE I PURCHASED IT FROM. I HAD TO REPLACE THE LUG NUTS BECAUSE THE FACTORY LUG WRENCH WOULDN'T WORK, THE ENGINE RAN HOT (REGULARLY) LEADING TO LONG TERM ENGINE DAMAGE, THE TRANSMISSION HAD BEEN REPLACED TWICE SINCE I BEGAN FINANCING THE CAR. THE CAR ONLY HAD 64K MILES WHEN I BEGAN FINANCING IT, BY 77K, THE TRANSMISSION HAD TO BE REPLACED TWICE (FIRST TIME IN DEC.18, AND THEN JAN.19), AND IT STILL SHIFTED HARD (AT TIMES) AND STILL MADE A STRANGE SOUND. I AM INVOLVED IN A CLASS ACTION SUIT OVER THE TRANSMISSION, BUT THE REPAIRS WERE AFTERMARKET (AND MEDIA INDICATES THAT EVEN THE MANUFACTURER IS NOT CAPABLE OF FIXING THE PROBLEM) IN APPROXIMATELY THE MONTH OF MAY, 2019, THE VEHICLE ALSO WOULD NOT START (KEY WOULD NOT TURN/NO LIGHTS CAME ON, ETC.). I CONTACTED THE CARMAKER, AND THEY HAD STATED THAT THEY'D "NEVER HEARD OF THIS KIND OF ISSUE BEFORE", BUT THEY DID OFFER TO PURCHASE THE VEHICLE BACK FROM ME (AT MARKET VALUE), BUT THEY BECAME DISINTERESTED WHEN I TOLD THEM THAT I WAS FINANCING THE VEHICLE FROM ELSEWHERE.

NHTSA ODI 11267530

AFTER PUTTING DOWN THE REAR SEAT TO MAKE ROOM IN TRUNK FOR PACKAGE REAR SEAT COULD NOT BE RETURNED TO UPRIGHT POSITION BECAUSE THE SEATBELT RETRACTOR BECAME JAMMED AND SEAT COULD NOT BE LIFTED DEALERSHIP COST ABOUT 700.00 SEAT WAS ONLY MOVED TO THIS POSITION 3 X SINCE OWNING CAR AND DEALERSHIP IDENTIFIED PROBLEM BEFORE HE GOT TO CAR TO LOOK AT IT SO THIS MUST HAVE HAPPENED TO OTHERS

NHTSA ODI 11267109

DOOR LATCH RECALL WAS PERFORMED JUST OVER A YEAR AGO. APPROX 14 MONTHS. (15S16) DOOR LATCHES HAVE A PAWL SPRING TAB THAT MAY BREAK. THIS CONDITION WILL TYPICALLY PREVENT THE DOOR FROM LATCHING. IN CERTAIN SITUATIONS WHERE THE DOOR IS ABLE TO BE CLOSED, THE DOOR MAY UNLATCH WHILE DRIVING, INCREASING THE RISK OF INJURY. SERVICE ACTION DEALERS ARE TO REPLACE ALL FOUR DOOR LATCHES. THIS SERVICE MUST BE PERFORMED ON ALL AFFECTED VEHICLES AT NO CHARGE TO THE VEHICLE OWNER. HOWEVER THE PASSENGER DOOR WILL NOT SHUT LAST WEEK. THIS OCCURRED AFTER THE RECALL HAS BEEN CLOSED OUT. I IMMEDIATELY TOOK THE VEHICLE TO AN AUTHORIZED FORD DEALER WHICH THEN I WAS QUOTED THE PARTS AND LABOR OF THE JOB. I CONTACTED FORD RELATIONS STATING THIS STILL FALLS UNDER THE DESCRIPTION OF 15S16 HOWEVER THEY CANNOT REOPEN THE RECALL ONCE IT HAS BEEN CLOSED. THE RECALL 15S16 IS POINTLESS IF THE REPLACEMENT PART ISN'T GOING TO CORRECT THE PROBLEM. MY DOOR STILL DOESN'T LATCH AND MAY FLY OPEN AT NO WARNING.*DT CONTACT STATED DURING RUSH TRAFFIC PASSENGER FRONT DOOR FLEW OPEN.*JB

NHTSA ODI 11266459

DRIVER DOOR LATCH, WHICH WAS REPLACED UNDER RECALL 15S16 IN FEB 2016 AT 57K MILES, FAILED TO LATCH IN OCT 2019 AT 108K MILES. DEALER VERIFIED THAT THE BROKEN LATCH THEY REMOVED WAS ONE OF THE UPGRADED PARTS. DOOR LATCH WORKED FINE THE NIGHT BEFORE BUT FAILED IN THE MORNING WHEN I WENT TO CLOSE MY DOOR AND THE DOOR BOUNCED OPEN AGAIN. CAR WAS NOT IN MOTION OR EVEN STARTED YET WHEN THE REPLACEMENT LATCH FAILED. CAR IS GARAGED, NO ADVERSE WEATHER THAT DAY OR THE PREVIOUS NIGHT. THE REPLACEMENT PART LASTED LESS TIME THAN THE ORIGINAL WORKING LATCH THAT WAS REPLACED AS A PREVENTATIVE MEASURE UNDER RECALL.*DT

NHTSA ODI 11265835

VEHICLE WAS IN MOTION IN DRIVEWAY WHEN BACK PASSENGER DOOR SPRUNG OPEN AND WOULD NOT CLOSE BACK. APPROXIMATELY 2 WEEKS LATER WHILE DRIVING ON DIRT ROAD CLOSE TO HOME THE DRIVER DOOR SPRUNG OPEN AND AGAIN WOULD NOT SHUT (VEHICLE WAS IN MOTION). WHEN ATTEMPTING TO CLOSE THE DOOR THE LATCH THAT SECURES THE DOOR TO THE CAR WILL NOT LOCK INTO PLACE. BOTH DOORS HAVE EXHIBITED THE EXACT FAILURE.

NHTSA ODI 11265625

MY AIR BAG LIGHT IS ON AND HAS BEEN ON FOR AT LEAST THREE YEARS OR MORE, I RECEIVED A RECALL NOTICED FROM FORD. WHEN I TOOK THE NOTICE TO THEM, THEY SAID THEY COULD NOT FIND THE INFORMATION IN THEIR SYSTEM.

NHTSA ODI 11265663

WHILE DRIVING AT 70MPH ON A CROWDED HIGHWAY, THE ELECTRONIC POWER STEERING WENT OUT ON MY 2013 FORD FUSION WITH THE ERROR MESSAGE OF "STEERING LOSS STOP SAFELY", THERE WAS NO EARLY WARNING. THE MESSAGE WAS FREIGHTING AS I WAS THEN AFRAID TO TURN THE WHEEL AS IT SAID STEERING LOSS, NOT "POWER STEERING LOSS". I PULLED OVER AND FIGURED IT WAS POWER STEERING AND NURSED IT TO A SAFE PLACE. IF I HAD BEEN TURNING INTO A CROWDED INTERSECTION I WOULD HAVE WRECKED. ACCORDING TO THE DIAGNOSIS I NEED TO REPLACE THE ENTIRE ELECTRONIC RACK AND PINION ASSEMBLY. THIS WAS A SIMILAR ISSUE WITH NHTSA CAMPAIGN NUMBER: 15V340000 FOR THE 2012 FORD FUSION. I CONTACTED FORD AND THEY SAID ITS NOT THE SAME ISSUE.

NHTSA ODI 11265689

ON 9/30/2019, AFTER LOADING MY 4 YEAR OLD INTO A BOOSTER SEAT ADJACENT THE DRIVER'S-SIDE REAR DOOR, I CLOSED THE DOOR AND, AS I PULLED OUT OF A PARKING SPACE THE DRIVER'S-SIDE REAR DOOR SLOWLY OPENED UP. I REACHED BACK TO CLOSE IT AGAIN AND IT JUST BOUNCED CLOSED AND THEN OPEN AGAIN. FINDING A PLACE TO PARK, I EXAMINED THE LATCH, WHICH WOULD NOT CATCH AT ALL WHEN THE DOOR WAS CLOSED. I HAD TO USE ROPES AND BUNGEE CORDS TO SECURE THE DOOR TO GET HOME AND MY 4 YEAR OLD HAD TO RIDE IN THE FRONT SEAT SINCE I COULDN'T RISK HIM BEING IN THE BACK WITH A DOOR THAT WASN'T SECURE. TODAY, 10/1/2019, I CONTACTED FORD LEGACY IN MCDONOUGH GA AND THEY INFORMED ME THAT WHILE THERE WAS A RECALL OUT FOR 2013 FUSION FOR LATCH FAILURES, MY VEHICLE WASN'T SUBJECT TO THE RECALL AND I WOULD HAVE TO PAY $250 FOR THE REPAIR, WHICH IS BEING PERFORMED NOW.*DT*JB

NHTSA ODI 11265364

THIS FORD FUSION HAS BEEN PROGRESSIVELY DYING AS IT COMES TO A STOP OR WHEN JUST DRIVING . IT HAS BEEN STARTING BACK UP IMMEDIATELY BUT LATELY SEEMS TO NOT TO START AS QUICKLY. ALSO STRANGE NOISE LIKE BLOWING OR PUFFING SOUND FROM UNDER HOOD. THIS IS ON CITY STREETS AND WHEN SLOWING DOWN FOR RAMP STOPS. CALLED DEALERSHIP AND UNTIL CODES SHOW UP THEY CAN'T TELL US NOTHING.

NHTSA ODI 11265370

I TOOK MY CAR IN TO WATSON FORD IN JACKSON, MS IN 2017 TO BE RECALL SERVICED. THEY FIXED EVERYTHING..INCLUDING MY DOOR LATCHES. I HAD TO BRING IT BACK IN JUNE 18 BECAUSE THE FRONT PASSENGER DOOR SWING OPEN AND MY DAUGHTER WAS IN THE SEAT & COULD HAVE BEEN SERIOUSLY HURT. NOW, MY BACK DOOR PASSENGER DOOR LATCH HAS DONE THE VERY SAME THING. I HAVE ATTEMPTED TO TALK TO THE FORD COMPANY, TRYING TO GET THEM TO FIX THIS BEFORE SOMEONE IS HURT BUT THEY REFUSE. I WAS DRIVING BOTH TIMES & BOTH TIMES MY CHILD'S LIFE WAS ENDANGERED. THEY'VE BEEN RUDE & UNHELPFUL. I ONLY WANT TO BE ABLE TO DRIVE SAFELY WITHOUT MY CAR DOOR FLYING OPEN. THIS WILL BE THE 3RD PROBLEM CONCERNING THESE DOOR LATCHES. PLEASE HELP

NHTSA ODI 11257827

PARKED MY VEHICLE TODAY AND IT WAS PERFECTLY FINE. WHEN I CAME BACK OUT A COUPLE HOURS LATER I STARTED IT AND IMMEDIATELY I GOT TWO WARNING MESSAGES ON MY CAR STATING TWO OF MY ASSISTED FEATURES WERE NOT AVAILABLE AND MY POWER STEERING WAS COMPLETELY GONE. STARTED DOING RESEARCH INTO THIS ISSUE BY CALLING MY LOCAL FORD DEALERSHIP TO SEE IF THEY COULD GET ME IN AND THEY SAID THEY COULDNT TODAY AND TO CALL BACK THE NEXT DAY AND TRY THEN. STARTED LOOKING ONLINE IN OTHER FORUMS AND RESEARCH INTO RECALLS AND NOTICED A RECALL HAS BEEN PUT OUT FOR POWER STEERING MALFUNCTIONING BUT MY VEHICLE WASNT LISTED IN THE RECALL BY VIN NUMBER. BUT YEAR MAKE AND MODEL ALL MATCHED. CALLED MY DEALERSHIP AGAIN AND THEY SAID SINCE MY VIN DOESNT MATCH ON THE RECALL LIST THEY WONT LOOK AT IT THAT WAY. DROVE MY VEHICLE HOME WITH NO POWER STEERING AND RAN A COUPLE TESTS MYSELF, I FOUND OUT MY POWER STEERING IS ELECTRONIC. HOOKING UP MY DIAGNOSTIC COMPUTER AND NO CODES WERE FOUND. UNHOOKED MY BATTERY FOR A LITTLE BIT TO TRY AND RESET THE WARNINGS THAT WERE ON AND THAT DIDN'T HELP, I DID A CHECK ON MY VEHICLE TO MAKE SURE ALL OF THE BASICS WERE GOOD, TIRE PRESSURE, FUSES, ANYTHING ELSE THAT COULD BE POTENTIALLY WRONG AND EVERYTHING ELSE CHECKS OUT. NO OTHER WARNINGS ARE ON IN MY VEHICLE OTHER THAN THE TWO ABOUT MY ASSISTED STEERING AND I CANT RECALL THE SECOND ONE.

NHTSA ODI 11257891

WHEN CAR IS IN MOTION SMOKE COMES OUT FROM ENGINE AND FROM EXHAUST.

NHTSA ODI 11257568

MY CAR WAS APART OF THE HEADLIGHT RECALL IN 2013. AFTER THE FIX THE DRIVER HEADLIGHT WAS NEVER THE SAME. RECENTLY THAT DRIVER HEADLIGHT WENT OUT WHEN DRIVING AT NIGHT. TO CHANGE A HEADLIGHT IT COSTS $30 PER BULB AND THEN A COUPLE OF HOURS OF TIME TO REMOVE/REPLACE THE BUMPER AT $160 AN HOUR. IN MY CASE, IT WASN'T THE BULB BUT THE BODY MODULE CONTROL WHICH HANDLES ALL THE LIGHTING IN MY CAR. THE HEADLIGHT IS SUPPOSED TO BE AT 12 VOLTS, BUT WAS AT A 9 VOLTS AND I'M TOLD IT FINALLY SHORTED. I THINK THIS HAS TO DO WITH THE HEADLIGHT REPAIR DONE YEARS AGO. THIS ENDED UP BEING A $1000 REPAIR. FOR A HEADLIGHT THIS IS A TERRIBLE BUILD FOR CONSUMERS.

NHTSA ODI 11256849

I HAD THE RECALL DONE ON MY VEHICLE AND NOW I HAVE TO FILL THE COOLANT EVERY TWO WEEKS, ITS CAUSING MY CAR TO OVERHEAT. THEY WILL NOT LOOK AT IT, OR FIX THE ISSUE THEY CREATED. THEY AS WELL REPLACED A PIECE OF THE HEAD GASKET IN WHICH MAY BE A SOURCE OF IT. IT'S BEGAN THE OVERHEATING ISSUE, WHAT MORE IS GOING TO OCCUR?

NHTSA ODI 11256645

I AM WRITING TODAY TO SHARE WITH YOU AN ISSUE WE ARE HAVING WITH OUR 2013 FORD FUSION. WE WERE DRIVING DOWN THE ROAD DURING THE RAIN. WHEN THE POWER STEERING ABRUPTLY FAILED. LUCKILY, WE DID NOT HAVE AN ACCIDENT. THIS IS THE SECOND TIME THIS HAS HAPPENED TO ME. THE FIRST TIME WAS 7 MONTHS AGO AND WE HAD TO REPLACE THE RACK AND PINION BOTH TIMES. THERE OBIVIOUSLY IS A PROBLEM WITH THEM AND I FEEL SOMETHING SHOULD BE DONE BEFORE SOMONE IS SERIOUSLY HURT BECAUSE OF THIS ISSUE. AFTER DOING SOME RESEARCH I FOUND THAT THERE WAS A RECALL ON 2012 FUSIONS FOR THE STEERING RACK, BUT OUR VEHICLE WAS NOT INCLUDED IN THE RECALL EVEN THOUGH IT WAS BUILT AT THE SAME PLANT, DURING THE SAME TIME PERIOD, AS THE RECALL ORIGINATED FROM IN HERMOSILLO MEXICO. I SURE HOPE SOMETHING CAN BE DONE TO STOP EVERYONE FROM HAVING THIS PROBLEM.

NHTSA ODI 11256766

RECALL OF DOOR LOCKS, FULLY REPLACED IN 2017. WAS AT WORK YESTERDAY AND THE DOOR LATCH FAILED JUST LIKE INITIAL INCIDENT. WENT TO CLOSE THE DOOR & IT BOUNCED BACK LIKE SOMETHING WAS STOPPING IT FROM CLOSING. AS PER FORD THEY AREN'T RESPONSIBLE.

NHTSA ODI 11256505

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE OPERATING THE VEHICLE, A TRANSMISSION WARNING INDICATOR REMAINED ILLUMINATED AND THE VEHICLE SHOOK AND VIBRATED. ALSO, THE VEHICLE DECELERATED AND SEVERAL UNKNOWN WARNING INDICATORS WERE DISPLAYED. THE VEHICLE WAS TAKEN TO TOWN AND COUNTRY FORD (6015 PRESTON HWY, LOUISVILLE, KY), BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

NHTSA ODI 11256325

I WAS HIT FROM BEHIND WHILE STOPPED READY TO TURN IN TO MY DRIVE WAY PICKUP HIT ME ABOUT 40 MILE PER HR.PUSH ME ACROSS THE STREET INTO SOME MEDAL PIPES WHY DID THE AIR BAG DID NOT GO OFF?????I WAS ON A STATE HIGHWAY

NHTSA ODI 11256064

AFTER I FILL THE GAS TANK AND PARK MY CAR IN THE GARAGE, I CAN SMELL GAS. AFTER THE CAR HAS BEEN DRIVEN A FEW MILES THE SMELL GOES AWAY. THE SMELL IS ONLY PRESENT RIGHT AFTER I FILL THE TANK UP UNTIL THE FUEL LEVEL DROPS DOWN FROM FULL. THIS ONLY STARTED ABOUT 2 MONTHS AGO BUT HAS BEEN PRESENT EVERY TIME THE TANK HAS BEEN FILLED SINCE THEN. THERE WAS A RECALL FOR THIS PROBLEM (13S04) SO I CALLED MY LOCAL FORD DEALER TO TRY TO GET IT FIXED UNDER THE RECALL. THE DEALER TOLD ME THAT MY VIN NUMBER IS NOT INCLUDED IN THE RECALL. I AM PRETTY SURE THIS IS THE SAME ISSUE THAT THE RECALL WAS CREATED TO FIX SO I THINK THAT FORD SHOULD RE-LOOK AT WHAT CARS THEY ARE WILLING TO REPAIR. IT SEEMS TO ME THAT THEY EASILY COULD HAVE OVERLOOKED SOME CARS THAT HAD THAT PROBLEM.

NHTSA ODI 11256232

TWICE IN THE LAST 2 WEEK MY EMERGENCY BRAKE HAS ENGAGED WILL I WAS DRIVNG DOWN THE HIGHWAY. A WARNING LIGHT CAME ON TELL MY THERE WAS A FAULT WITH MY BRAKES . SO I PULL OFF THE HIGH AND PULLED THE LEVER UP THEN PUSH IT DOWN THEN PULLED IT UP . I DID THAT 3 TIMES TO MAKE SURE IT WAS NOT ON

NHTSA ODI 11255684

THE REAR MIDDLE SEAT BELT LOCKS UP WHEN THE SEAT IS TILTED DOWN AND DRIVEN A COUPLE OF MILES. THIS DOESN'T LET THE REAR SEAT TO COME BACK UP. THE ONLY WAY TO RELEASE IT IS TO COMPLETELY DISASSEMBLE THE SEAT AND THE SEAT BELT EVERY TIME. USERS UNBOLTING AND BOLTING THE SEAT BELT REPEATEDLY CAN EASILY LEAD TO UNINTENDED ERRORS IN REASSEMBLY.

NHTSA ODI 11255296

INITIAL IGNITION OF THE CAR RESULTS IN ENGINE STALL OUT POST ABNORMAL IGNITION TIME. FUSION WILL DISPLAY "POWER RUN ACTIVE" THEN "PRESS BRAKE TO START". THIS WILL REPEAT AFTER ANOTHER IGNITION ATTEMPT AND RE-SHOW THE SAME MESSAGES ON THE DASHBOARD. AFTER A THIRD IGNITION ATTEMPT THE ENGINE DOES NOT STALL OUT. THE PROBLEM IS NOT A SUDDEN ONSET BUT INITIAL SYMPTOMS OF THE ISSUE IS THAT THE CAR WILL STALL OUT AFTER 10 SECONDS OF DRIVING. INITIAL RE-IGNITION POST STALL RESULTS IN NORMAL FUNCTION OF THE CAR WITHOUT EXTRA ISSUE. HOWEVER, THIS EVENT BECOMES INCREASINGLY COMMON OVER TIME UNTIL IT SIMPLY STALLS OUT IMMEDIATELY POST IGNITION. DESPITE MULTIPLE TRIPS TO A FORD CERTIFIED PROFESSIONAL MECHANIC, NO CODES ARE GIVEN BY THE COMPUTER WHICH RENDERS DIAGNOSIS OF THE FAULTY PART OR CAUSE OF THE ISSUE NEAR IMPOSSIBLE. PROBLEM MAY PRESENT ITSELF AS FAULTY ALTERNATOR, BATTERY, OR STARTER. HOWEVER, EVEN AFTER REPLACEMENT OF ANY POSSIBLY FAULTY AFOREMENTIONED PARTS THE PROBLEM STILL PERSISTS.

NHTSA ODI 11255071

PASSENGER AND DRIVER SIDE DOOR LATCHES BROKE WITHIN A COUPLE WEEKS OF EACH OTHER. THE CAR WAS PARKED BOTH TIMES AND WHEN EXITING THE CAR AND TRYING TO CLOSE THE DOORS, THEY DO NOT LATCH SHUT AND ONLY REMAIN OPEN.*DT *TP

NHTSA ODI 11255187

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING, THE FRONT DRIVER'S DOOR OPENED INDEPENDENTLY WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND ATTEMPTED TO CLOSE THE DOOR; HOWEVER, THE LOCK MECHANISM FAILED. THE CONTACT HELD THE DOOR AND DROVE SLOWLY TO HER RESIDENCE. THE CONTACT CALLED TED RUSSELL FORD LINCOLN (8551 KINGSTON PIKE, KNOXVILLE, TN 37919, (865) 693-7611) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,707.

NHTSA ODI 11254659

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING APPROXIMATELY 70 MPH, THE "SERVICE POWER STEERING NOW" INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ELLIOTT FORD LINCOLN (903-572-3486, LOCATED AT BURTON RD, MT. PLEASANT, TX 75455) WHERE IT WAS DETERMINED THAT THERE WAS NO RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.

NHTSA ODI 11254707