What 2,222 owners told NHTSA about the 2013 Ford Explorer Hev

See attached document for complaint.

NHTSA ODI 11747368

See attached document for complaint.

NHTSA ODI 11747376

I was driving at about 25 mph when the steering completely locked upon me going around a corner. There was no warning lamps or messages prior to it locking up. If another car would have been in the other lane I would have crashed. I would have been unable to avoid wrecking into anyone or anything that was in the way because I had zero control of my steering. There was nothing I could do to turn. It has not been inspected.

NHTSA ODI 11746989

The sync touch responsive interface for climate control fails. This failure causes the system to repeatedly respond without prompt continually causing the driver to continually attempt to disengage the system causing a significant safety hazard. The chip in the system for the effected buttons is the component that fails. There is no solution. Replacement or upgraded interfaces are not available and disconnection of the panels renders the climate control, radio/entertainment, navigation and all other systems relayed thru the touch screen completely inoperable which is unreasonable. This occurs at random while operating the vehicle with the error often occurring continuously or at very high frequency. Ford discontinued the sync touch panel control due to issues but has provided no solution for the safety hazard it has created.

NHTSA ODI 11746856

After getting my vehicle from the dealership my steering wheel was hard to turn , took it in and they replaced the struts (The old struts were binding). 6/7 Days later the same thing happened with the steering wheel. They had said it was a switch in the power steering and there was a safety recall and i would have to take it into a ford dealership. When i had called to make my appointment there wasn’t a recall and i called the ford company and they said the same thing.

NHTSA ODI 11746332

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11745607

Power steering message popped up on dash in a flash and disappeared while I was driving. Same message popped up a couple miles down (I pulled into a parking lot to check message.) Steering wheel locked and left me stranded in need of a tow truck to move car to mechanic and get home. Message pops up and disappears quickly not leaving much time to read or react.

NHTSA ODI 11743394

As I was backing my 2013 Ford Explorer Base model out of my garage I heard a pop and then my steering started making a grinding/dragging noise. When I pulled onto the street I noticed that my steering wheel would "stick". I went a short distance further down the road and it seemed to stop sticking. When I went around a curve towards the left, my steering stuck again and it was harder to get it to "unstick". I returned it back to my home and parked it back in the garage. I see that there is a recall for the steering on the 2013 models, but my VIN is NOT included in this recall. This is a huge safety hazard and could put me out of work, as I care for and transport autistic individuals. This vehicle and my job are my livelihood and this needs to be corrected/recall issued on all of the 2013 models since they all seem to be having similar steering issues. Vehicle has not yet been inspected. Vehicle is available for inspection on request.

NHTSA ODI 11743397

The contact owns a 2013 Ford Explorer. The contact stated that while reversing, the rearview camera intermittently displayed a blank image. The contact stated that the vehicle was towed to the dealer due to the front axle fracturing after the vehicle struck a curb while driving in inclement weather. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 190,000.

NHTSA ODI 11742321

The contact owns a 2013 Ford Explorer. The contact stated that the driver side seatbelt unexpectedly unlatched. The dealer was contacted; however, it was diagnosed of repaired. The manufacturer was not notified of the failure. The approximate failure mileage 150,000.

NHTSA ODI 11740389

Power steering assist fault while driving with total loss of power steering. Caused difficult steering, particularly at low speed and made for a dangerous driving situation with what seemed like complete loss of steering ability. Power steering fault and lane keeping assist failure warnings lit on display at the same time. Vehicle was towed to dealership and problem was isolated to steering module/gear failure after paying for battery replacement to verify that it was not a voltage related issue. 2013 Ford Explorers manufactured through the end of February 2012 at the Chicago plant have a recall for the same issue, but this vehicle was manufactured in June 2012 and I was told it is not covered. Repair was quoted at $4500.

NHTSA ODI 11738002

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on the driver’s side windshield started to detach. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part required for the recall repair was not yet available. The dealer was contacted, but the vehicle was not diagnosed or repaired. The dealer confirmed that the remedy parts were not yet available and were on backorder. The manufacturer was made aware of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The approximate failure mileage was 130,000.

NHTSA ODI 11737590

The car had been parked for 30 minutes in the driveway and spontaneously caught on fire. Our lives and home were at risk of serious injury due to the fire. Firefighters and police were called to the scene and the fire was put out. There were no mechanical issues prior to this happening.

NHTSA ODI 11736831

Odometer Fraud. The contact purchased a 2013 Ford Explorer. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 136,000; at the time of registration, it was discovered that the mileage was 251,393. The contact also reported the odometer fraud to the local authorities.

NHTSA ODI 11734026

I am writing to complain about Recall 24S02. The A-Pillar Trim has become loose on my car and the rubber mold underneath it now is loose and flaps aggressively in the wind creating damage to my windshield and driver side front window. I am afraid the whole piece will come off at any moment and cause a road hazard. I have called multiple dealers in my area over the past two years and were told that the parts for this recall is on "universal backorder. One dealer told me in 2025 verbatim, I'd "...have a better chance of seeing Jesus come back than to get that part fixed." I have tried getting in touch with corporate but have had not luck either. I am not sure what to do.

NHTSA ODI 11733589

After more than two years with an open recall, Ford has not been able to repair my 2013 Ford Explorer due to an inability to source the replacement parts. On Sunday, April 12th the defective A-pillar trim on the driver’s side detached while driving at highway speeds on the interstate. My Ford dealer states that there is a backorder of over 80,000 A-pillar covers. It doesn’t seem that they are very interested in addressing this recall. What recourse do I have?

NHTSA ODI 11732309

The contact owns a 2013 Ford Explorer. While driving at slow speeds, the contact stated that while turning the steering wheel there was a lack of resistance, and there was a pulsating sensation in the steering wheel. No warning lights were illuminated. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 168,000.

NHTSA ODI 11731684

The contact owns a 2013 Ford Explorer. The contact stated that while driving approximately 30 MPH, the steering wheel failed to turn left or right. The message "Power Steering Assist Fault" was displayed. The contact stopped, turned off, and restarted the vehicle several times to reset the power steering assist feature; however, the steering wheel was still difficult to turn. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 250,000.

NHTSA ODI 11730813

The contact owns a 2013 Ford Explorer. The contact stated that while driving approximately 65 MPH, the driver's side A-pillar trim was blown off the vehicle. The contact was unable to recover the trim. The contact stated that much later, while the vehicle was with the dealer, the dealer informed the contact that the passenger’s side A-pillar trim was loose, and tape was used to secure the trim in place. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part was not yet available. The dealer and the manufacturer were asked about parts availability and were informed that owners would be notified by mail when parts were available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 120,000.

NHTSA ODI 11728273

See attached document for complaint.

NHTSA ODI 11728284

The rear reverse camera malfunctions and glitches. Often the screen turning green when reversing, sometimes screen is black or no color view and most times the camera if reversing to left or appear as to the right or vise versa and sometimes it’s normal but rarely. The control buttons for windows has a malfunction where it sometimes works and sometimes doesn’t. The seatbelts are not clicking and I have kids in the rear seats.

NHTSA ODI 11726948

this recall has been active since 2023. I was told a remedy would be available ladder 2024…. I received another letter in September 2025 reminding me of the recall and it is now March 2026 with no current remedy available. This vehicle was used for my work vehicle and I am no longer able to use it to make income due to it having a recall. This has been a major problem. These parts also seem to be available by third-party online looking for help or suggestions. Not sure what to do at this point. Thanks!

NHTSA ODI 11727096

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted, but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the A-pillar trim was detached from the driver’s and passenger’s side windshields. The approximate failure mileage was 217,000

NHTSA ODI 11726796

While driving a 2013 Ford Explorer, the vehicle experienced an electrical issue that caused the power steering system to malfunction. The power steering assist suddenly failed, making the steering wheel extremely difficult to turn. The failure occurred suddenly and at the time of the incident the vehicle was traveling 2 miles and I parked it immediately.This created a serious safety hazard, especially when attempting to turn or maneuver the vehicle. A warning message stating “Power Steering Assist Fault” did appear on the dashboard .Prior to the failure, there were no warning signs. Due to the sudden loss of power steering assist, the driver’s ability to safely control the vehicle was significantly reduced, increasing the risk of a crash. The issue has not yet been inspected. The vehicle is available for inspection upon request.

NHTSA ODI 11726189

My vehicles exterior A-pillar trim is coming off and pieces flew off on highway. I was told to contact Ford.

NHTSA ODI 11726202