What 921 owners told NHTSA about the 2013 Chevrolet Malibu Eco

Battery voltage going up and down. Car will make clicking sound. Car will shut off and start back up. Battery issue will pop up n steering wheel will lock while driving and service battery charging will pop on dashboard.

NHTSA ODI 11595195

The contact owns a 2013 Chevrolet Malibu. The contact stated while driving 65 MPH and depressing the brake pedal, the vehicle hesitated to respond, causing a stopping distance delay. Additionally, the contact noticed a burning odor. There was no warning light illuminated. The contact stated that the failure recurred while driving. The contact stated upon opening the hood to inspect the vehicle, he noticed that brake fluid had spilled all over the vacuum pump. The contact stated that he added brake fluid in the vacuum pump, but the brake fluid immediately leaked out of the vacuum pump. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 91,000.

NHTSA ODI 11587369

2013 Chevy Malibu LS Headlight found shorted and was causing other electrical issues. I found out the 8pin plug one of its pins showing burnt and its male mate same You can see this issue is not just one owner incident and it’s a public complaint in this public forum link [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11582531

This car stop on the middle of the highway with my kids in the car we we’re almost crashed it’s un safe and they need too recall the Chevy Malibu it’s very dangerous to stop out of nowhere and cut off I can kill somebody one day everything has been replaced and it’s still cutting off I shouldn’t be responsible for paying for this lemon

NHTSA ODI 11581869

The contact owns a 2013 Chevrolet Malibu. The contact stated that while driving at various speeds, the systems displayed on the instrument panel suddenly powered off. The radio, heater, AC, and other electrical systems also turned off independently. The contact stated that while operating the vehicle during the warmer seasons, the vehicle stalled while idling. The contact restarted the vehicle and was able to drive the vehicle. The vehicle had not been taken to the dealer or independent mechanic to be diagnosed or repaired. The manufacturer was made aware of the failure, and it was confirmed that the failure was not covered under warranty. The failure mileage was 150,000.

NHTSA ODI 11581347

78153 miles 2013 Malibu econotec never 1 problem until out of the blue timing chain eats thru plastic and metal tensioners with metal and plastic shavings going into engine delillo Chevy Huntington Beach ca along with my mechanic confirmed engine replacement here lies my hazard and or product defect timing chain causes stalling idling compete shutdown rpms up and down no engine light comes I was on the freeway and on streets car completely stalls I have to shift in nuetral and pray it’s starts almost getting rear ended 3 times if this is not a safety issues wow you got to kick me I’ve read numerous reports of same issues and still no recalls plus 78,153 miles and I’m to replace the engine I’ve never heard a mechanic say old is that engine it’s how many miles this is my safety complaint

NHTSA ODI 11581446

The contact owns a 2013 Chevrolet Malibu. The contact stated while driving approximately 60 MPH, the stabili-trak warning light illuminated. While attempting to move the vehicle to the shoulder of the roadway, the vehicle began to shake with smoke coming from the passenger’s side rear suspension. The vehicle was taken to the local dealer where the vehicle was diagnosed and it was determined that the shock, an alignment, brake pads and rotors needed to be replaced and a new tire needed to be installed. The manufacturer was not made aware of the failure. The failure mileage was approximately 62,000.

NHTSA ODI 11581141

Not starting due to loss of power I believe it's electrical.

NHTSA ODI 11579084

Brake booster blew out due to a defect in the brake booster vacuum pump causing me to have no brakes.

NHTSA ODI 11578235

The car suddenly shows the service StabiliTrak engine power reduced, just like what was recalled on the 2016-2018 Chevrolet Malibu. Even though it's a 2013 Chevy Malibu, mine has the same issues. Please call me back at [XXX] to provide more information on the issues my car is experiencing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11576599

The contact owns a 2013 Chevrolet Malibu. The contact stated that while the vehicle was parked in the garage after two weeks, he started the vehicle and reversed onto the driveway. The driver's side and passenger's side air bags deployed without impact or warning. There were no reported injuries. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 111,000.

NHTSA ODI 11573302

The dash board goes out and you can not see speed or anything goes completely black and sometimes won't come back on for days. Unable to see information center.

NHTSA ODI 11573235

The contact owns a 2013 Chevrolet Malibu ECO. The contact stated while at a stop light, the power steering was difficult to turn, and the vehicle stalled. The Service battery charging system displayed and the check engine and battery warning light illuminated. The vehicle was towed to the residence. The vehicle was not taken to the dealer. The vehicle was repaired by the contact. The contact stated that the alternator and the starter had failed. The manufacturer was not made aware of the failure. The approximate failure mileage was 174,000.

NHTSA ODI 11571980

Air bag warning light stays on and will not reset. Driver power seat controls buttons out of plastic control cover and jammed in metal part of seat. Can not get seat control unjammed and no way to adjust driver seat.

NHTSA ODI 11568244

The Generator control module failed on the vehicle causing the battery to lose charge and then the car to shut down. When looking for the part online I came across a bulletin 13142c which talked about the same exact issue that I faced. according to the bulletin the gcm was to have been replaced, however when searching the service history at the Chevy dealer there was a note that the gcm had been inspected, but never replaced. I am looking into this matter to see if I can be reimbursed for the costs of the labor and parts related to the gcm. On a side note this failure did come directly after the car was in a accident where the driverside front end of the car was damaged. The technicians said that the gcm failure had no relationship to the accident.

NHTSA ODI 11566524

The contact owns a 2013 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the rear tow link fractured. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 21V633000 (Suspension) and the contact was informed that the lug nuts were swollen. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 250,000.

NHTSA ODI 11563486

While driving my vehicle the rear toe link broke leaving me stranded on the side of the road. With no dealers close I replaced the passenger rear toe link to get the car mobile again. Once that was done I called the dealer to setup an appointment to do the recall repair. After dropping the car off at the dealer I received a call back stating that I would need to replace my OEM lug nuts at an inflated dealer price in order for them to do the repair. My issue is that these OEM lug nuts should also be included in the recall because I've done nothing to create an issue with the lug nuts. Swelling lug nuts is a major ongoing issue among the big 3 automakers and this should be corrected. Allowing the companies to sell cars with low quality lug nuts is insane. Dealers thinking that customers should pay for a flaw in their own design of the lug nuts before they will do any repairs is even more insane. How my car sits now I am refused recall service on my car that is unsafe to drive due to them releasing cars with unsafe lug nuts. Then to add a paywall to you getting your recall repairs. This is extremely unsafe and unethical, and I pray that the NHTSA will do something about this ongoing issue that is putting millions of Americans in danger and allowing these companies to take advantage of their customer base. I took action to bring this to your attention and I hope you will take preventive action to keep Americans safe on the roads.

NHTSA ODI 11563518

The airbag maintenace light comes on every time I start it. Alot of my friends who own GMC say that it is a normal problem with a GMC vehicle and there should be a recall on it. But there is none.

NHTSA ODI 11557326

In July 2023, my husband was driving ON THE HIGHWAY when the car suddenly decelerated itself. A system error message came up saying service stabilitrak and reduced engine power - he couldn't go more than 40 mph. We took it to the repair shop and they determined the high pressure fuel failed and the engine was running off the lift pump. They replaced the high pressure fuel pump with gasket and pressure line. Then, in late September 2023, the car turned off while my husband was driving (while he was stopped). He was able to turn it back on and drive it home. There were no warning lights/messages. We took it to the repair shop, but there were no error codes and they were unable to determine the issue. Next, at the end of October 2023, when coming to a stop the vehicle shut off again - almost every time my husband would come to a stop. When this happened, it still had power (because the radio was still on), but he had to shut vehicle off completely and restart it each time. There were no warning lights/messages. We took it back to the repair shop. Again, no codes were stored in ecm/tcm. This time, they test drove it while monitoring the data. They determined that the torque converter clutch was hanging up. They also experienced some long shifts and occasional slippage and determined that the transmission would need to be replaced. The issues above are just the most recent issues. Aside from regular brakes, tires, and oil changes, other work I’ve had done on the car includes the repair/replacement of: rear suspension toe link recall (three times), water pump, brake booster vacuum, a/c compressor, timing chain, guides, tensioner, cam actuators, intake and cam actuators, exhaust cam solenoid, exhaust manifold bolts with associated hardware and gaskets, thermostat (twice), battery (twice), spark plugs, and back left hub assembly. I have still have the documentation for all of the above.

NHTSA ODI 11553194

After my car battery was professionally replaced my airbag light came on. GM dealer service got a code of B101D requiring the airbag control module to be replaced. There are no new compatible modules available in the US. Two GM dealers advised getting a used module that had not been in an airbag deployment. Upon obtaining a compatible module the dealer is now getting a code of B3902, this code indicates that the environment identifier of the module does not match the vehicle and prohibits further programming permitting the airbags to function properly. So GM has intentionally prohibited compatible modules from salvage cars and they are no longer making new modules for my car. How is this ethical, legal, safe or environmentally sound? Are consumers expected to junk a perfectly good automobile absent a $100 part? Is this practice required by some regulation prohibiting airbag modules from being salvaged and reprogrammed?

NHTSA ODI 11549251

I was looking up some info and noticed that some 2012-2014 Chevy malibu had an issue with the front and rear defrost not properly working . How would I know if my car was involved in that recall or if it was fixed. Because right now I am having trouble with front windshield defrost and also the rear window defrost and I see that was a recall and I don’t know if my car was done

NHTSA ODI 11546161

The contact owns a 2013 Chevrolet Malibu. The contact stated while driving approximately 35 MPH, the instrument panel lights started flickering, and the vehicle lost power steering functionality. Additionally, when the brake was depressed, the brake pedal was abnormally firm. The vehicle was pulled over to the side of the road and inspected. The vehicle was then towed to the residence where the battery was charged. The vehicle was taken to an independent mechanic where it was diagnosed that the generator control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 190,000.

NHTSA ODI 11545158

The instrument cluster goes out. Can't see anything on the dash speed gas or anything while driving or goes out completely. Can not drive car. Not safe to drive don't know if I have gas or how fast I'm going or if I have any warnings on the car.

NHTSA ODI 11543481

LOSS OF BATTERY CHARGE - INSPECT GENERATOR CONTROL MODULE Previous recall issued, Chevy says car issue was resolved but is not

NHTSA ODI 11542196

Car randomly goes into engine reduced power mode and won't go over 50mph. Power steering either won't turn the wheels and will start working again without warning while driving and jerks wheel to the right. Service stabilitrac warning would come on intermittently and disable traction control. Service stabilitrac warning is on now everytime I crank the vehicle and traction control is never working. I have pictures where it has went in limp mode and videos of the gauges doing crazy things after this warning has come up. Very dangerous. Car will jerk the wheel without warning when power steering warning comes on.

NHTSA ODI 11539967