What 82 owners told NHTSA about the 2013 Chevrolet Corvette

Just recently I noticed that the leather on my dashboard has started to become unglued. My concern is 1) this is a defect that is common to not only C6 corvette modes (mine) but to C7 (google it on the internet) and some C8 models (information from Service Manager at Tasca Corvette in Wheeling, Illinois when he inspected my vehicle yesterday), 2) since there is an airbag in this location what affect will the loose dashboard leather have on the deployment of the airbag(s) thus becoming a safety issue.

NHTSA ODI 11746244

Having a strong smell of gasoline in my garage after filling. After the garage had aired out the next morning the same strong smell. There no warning lights

NHTSA ODI 11737147

Fuel tank leaking Gas smell

NHTSA ODI 11713375

Strong smell of fuel after parking the car in the garage. Inspection by the dealership confirmed the fuel pump assembly is leaking. The car was left for replacement of the fuel pump assembly due to the strong possibility of fire. This is a known issue with the C6 model of Corvette and was addressed by a gm TSB in 2011 rather than more appropriately by a recall. Of more concern to me is the fact that my car was produced in 2013 with a known defective part affecting safety. The cost of the repair is over $5000.

NHTSA ODI 11665801

My Corvette c6 model has had a longterm issue with the left fuel pump, which I was not made aware of by the local dealership servicing my vehicle or the manufacturer, General Motors. I recently discovered the fuel pump issue, which results in a significant fuel leak thru the bottom left side of the vehicle. GM and the dealership failed to notify me of this issue even though they issued a Special Bulletin that addresses the fuel pump issue and which advises dealerships to repair the vehicle at no cost to the owner - me. I have complained to General Motors and I'm currently awaiting their response to my complaint and request for assistance with the repairs. As of 9:00 am Pacific Time, December 9, 2024, I've received no response from GM. My concern and reason for this report is GM's failure and the dealership's failure to notify me, and failure to issue a recall for this significant and dangerous problem with my vehicle.

NHTSA ODI 11629653

FUEL LINE CONNECTION ON TOP OF FUEL PUMP CRACKED. VERY COMMON ISSUE WITH THIS CAR AS MANY OTHER EXPERIEMCING THE SAME ISSUE.

NHTSA ODI 11584873

Strong fuel fumes filling the car and garage on [XXX] after driving {just in and out of the garage), even stronger in trunk, its a convertible. Internet search showed either faulty gas cap, I replaced it hoping that would fix it, or broken plastic elbow on top of fuel pump on drivers side gas tank. Web sites also noted GM covered this safety recall and fix for 10 years. Well, they didn't tell people not to buy this car with a serious defect that could burn down their garage and home! I bought it used with 9200 miles last Feb for almost 52K and clean carfax. I took it to my local Chevrolet dealer, Durant in Granbury, TX 1/22/2023, they called back saying the recall only lasted 10 years and they won't cover any of the $3,600+ repair cost. Can you help? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11568394

There is a strong fuel smell in the cabin of my car and in my garage if the gas tank is above a half tank.

NHTSA ODI 11559096

service active handling/service traction control

NHTSA ODI 11517546

The car has yet to be inspected by a dealer. However, there is a strong odor of fuel, in the garage by the driver side of the vehicle. This has occurred on multiple occasions even when tank not at full capacity. Upon investigation, it appears as if it is similar to a reported problem with the fuel pump from multiple Corvette owners with similar make and model. Significant concern of potential fires and/or explosion around small children in the household.

NHTSA ODI 11507334

The Primary tank module flange fuel and vapor leak. Yes, it's available for inspection upon request. It's sitting at Auto Nation Chevrolet 3215 South Auto Way Gilbert since November 28, 2022. They said they're waiting for the cross over fuel line part # 10337583. Fuel leaks where the fuel pump goes into the left gas tank and can cause an explosion. Also, I had extreme fuel vapors in my garage that could have caused my house to catch fire too. No warning lamps. I filed a case with GM #9-933208951. Based on my research its recall #15682. When I phone GM they tell me my case has been transferred to another department. The latest is James at 1 866 790 5600 ext 591-0336.

NHTSA ODI 11505848

Passenger side air bag module will not arm the air bag system when any person sits in the seat. Have made multiple attempts to purchase the air bag presence module since June of 2022. Once with dealer, could not get the part, and two more times online. Each time I am told the part is on back order and they have no timeline as to when the part will become available. So I have a $86,000 Corvette that my wife or son cannot ride in because the air bag sensor is faulty.

NHTSA ODI 11501800

My car with only 17,000 is generating a very strong gas smell, which completely fills my garage. I've read old notices that preferred to this problem and saw there was many reports in the past from your organization about this problem, that now have all been pulled. As any Corvette forms on line reflects, as it is a continuous problem. I now am keeping mine outside, because of the strong odor. There isn't a gas leak per a Chevrolet dealer and I can't afford the $1,000 in additional labor, their estimate to attempt to figure out. Please assist us (the thousands of other owners effecting 2007 -in 2013). Please help thank you very much on advance, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11493386

The vehicle fills my garage with strong gasoline vapors when enclosed. I have to leave it parked outside to clear the odor from my garage. There is a leak somewhere. I have been informed and subsequently read that it is a known problem by GM Chevrolet Corp. I cannot locate an issued recall for this widely known problem with C6 Corvettes

NHTSA ODI 11491636

Automatic Transmission Shift Lever. Only inspection would be repair invoice. Shifter would not move. Then it finally moved but would only stop at Drive Location and Neutral Location. Would not go back to the Park position. The problem was confirmed and repaired at an independent service center. Problem components inspected and replaced by an independent service center. There were no warnings . Luckly the problem first appeared while car was parked in my garage

NHTSA ODI 11481715

Airbag light in the dashboard goes on and off intermittently. There is a lot of talk on the corvette forum of other people having the same issue. I'm concerned the airbag won't work if it's needed.

NHTSA ODI 11480397

Service active handling and service traction control.

NHTSA ODI 11472171

I have just recently purchased this 2013 Corvette grand sport. I'm come out into my garage this morning March 12th 2022 and there is a trail of fuel leaking from the rear driver's side of the car. Doing a quick online search I have found that this is a common problem on these cars . There is there is a plastic fitting on top of the fuel pump or the fuel tank itself is commonly known to develop a crack. This is an exceptionally dangerous situation as the fuel tank is very close to the hot exhaust when driving. Please advise as to any recourse I may have with GM or any Chevrolet dealership . This is a 2013 corvette with only 46000 miles.

NHTSA ODI 11456406

.The internet (Youtube and Corvette Forum) is full of horror stories about the engine valves breaking and dropping into the engine causing a catastrophic engine failure without warning. I was paranoid about driving the car for fear of an engine failure and averting an accident. After reading a plethora of horror stories about numerous LS7, 427 engine failures I felt anxious about driving my car and wanted to fix my engine ASAP and not a moment to soon!!!! I took my car to a shop to determine the condition of the valves and one intake had extensive play in the valve guide - .012" wobble from side to side vs a factory spec of .003". They didn’t check the other head but assuming the worse. I just have my heads refurbed at with only 6k miles on my vehicle. This resulted in me spending $5,350 dollar to remedy the defect before the engine failed and potentially causing an accident. ........this problem seems to be a manufactory defect potentially common to all 427/LS7s built between 2006 and 2013!!!!!

NHTSA ODI 11447036

Car has a constant smell of gasoline coming from it, appears to be leaking from the top of the fuel tank located on the drivers side of the vehicle, then it runs down and fills the fuel tank mounting bracket, could possibly leak onto exhaust pipe causing fire underneath the vehicle.

NHTSA ODI 11437312

1. Strong fuel smell when the car is parked in garage. Believe it is coming from top of driver's side fuel tank. Vapor is so strong I'm afraid it will explode. Doesn't matter if tank is full or empty. 2. Seat belt air bag warning light is on in the driver's cluster unit. Car only has 35,000 miles. Don't think this is safe. Will need it checked out ASAP at dealer.

NHTSA ODI 11437174

The contact owns a 2013 Chevrolet Corvette. The contact received a TSB from the Manufacturer under Special Coverage Adjustment: 15682 (Primary Tank Module Flange Fuel and Vapor Leaks). The contact stated while refueling from the above half tank of fuel, there was an abnormal fuel odor inside and outside the vehicle. The contact took the vehicle to the local dealer to be inspected however, the mechanic was unable to duplicate the failure. The contact was informed to continue refueling the vehicle until the dealer was able to lift the vehicle and check for leaks. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 26,290.

NHTSA ODI 11433110

car only has 31,000 miles on it and it's leaking gas from the top of the gas tank. will need fuel pump replaced. not a safe thing to have cheap parks, spilling gas over the exhaust pipes. MAJOR SAFETY ISSUE TO ME! anti lock brake system is also giving issues for a couple years now, noted by previous owner. This car only has 31,000 miles!

NHTSA ODI 11426831

DRIVER SIDE FUEL TANK LEAKING/STRONG GASOLINE VAPORS INSIDE CABIN

NHTSA ODI 11419780

Very strong gas smell when tank is more than half full.

NHTSA ODI 11419074