What 92 owners told NHTSA about the 2013 Audi Q5

There is considerable rust to the point that the subframe has been structurally compromised. I also contacted Audi USA regarding this issue, but they advised that they could not provide any assistance and closed my case. I was instructed to have the vehicle inspected and see what the dealer could do. I have videos and photos documenting the compromised subframe which many Audi Q5 owners have been complaining about.... There are holes approximately the size of a tennis ball.

NHTSA ODI 11739161

Oil leak/ and tire suspension icon keeps coming on after i fixed it

NHTSA ODI 11719378

Took vehicle in for state safety inspection. Found heavy rust on subframe nearly all the way through. Was told if it gets any worse it will not pass inspection next time. Apparently there are plastic rock shields on subframe that trap water causing it to rust. Took it to dealer and they want to charge close to $4000 to replace. This seems like an engineering defect. The vehicle is kept in a garage and doesn’t have any other rust on it.

NHTSA ODI 11677300

When at highway speed, the vehicle veered hard to the left without any driver input, causing the car to cross several lanes of traffic and hit a concrete divider at ~65mph. The driver fractured her back, and one of three children in the car experienced injury. The vehicle was declared a total loss by insurance. The driver (my wife) indicated that a similar incident happened at low speed in a parking lot, but it resolved after shut down and restart of the engine. It is my understanding that the vehicle is currently either at or on the way to a Copart lot.

NHTSA ODI 11641442

I was doing maintenance on car. Had new tires and alignment done. The alignment tech found rotted out rear sub-frame underneath plastic covers. Said that it was unsafe to drive. Had it fixed there. Mechanic had another Q5 on rack, he said it had exact same problem. Tried to find used parts, ALL had rot through the frame. Found a part in Texas that was clean and bought it to replace. Asked Audi USA to reimburse me for the cost as they have a supposed 12 yr rust through warranty. They told me no because it only applies to body parts and that I didn't get it done at an audi dealer. The plastic cover is the issue as it keeps the moisture locked into the part. Audi A6s have the same frame but no cover and they don't rot. This is a dangerous situation and Audi is looking the other way.

NHTSA ODI 11622403

The rear subframe has plastic "stone guards" to protect the frame from being damaged in off-road conditions. Where these stone guards are attached, the subframe has rotted/rusted large holes. Water and salt from winter seasons can get trapped behind these guards. A subframe on a vehicle at this age should NOT have complete holes rotted through. Let alone a vehicle brand such as Audi, known for quality. The rear subframe connects the rear suspension and AWD drivetrain to the unibody of the vehicle. This is a major safety concern. It has not been inspected by the manufacturer; my Audi dealer denied this could happen. I am part of a few Audi groups/forums with others facing the same issues, and Audi replacing the subframe under the corrosion warranty. This is a widespread issue amongst the forums. There are no warnings or symptoms as of yet. I noticed the holes 3/17/24. The vehicle has been somewhat sufficient to operate. I just don't want to be traveling down the road with my family in the vehicle if the subframe collapses. I am afraid to fully remove the stone guards as others on the forums claimed that Audi would do nothing for them after removing the guards. Being that they are "protection".

NHTSA ODI 11619831

My audi uses 1 quart of oil every 300 miles. The dealership wants to charge to find the problem. Audi should fix the problem at no charge. I bought the vehicle in February 2023. Was told there were no issues with the car.

NHTSA ODI 11589507

Car started running hot, had mechanic do pressure/ leak test and he couldn’t find a leak. Took it to Audi and they said the coolant pump and thermostat housing were leaking coolant. I’ve researched and it looks like these cars have know coolant pump issues.

NHTSA ODI 11576364

Car was telling me to add 1 qt of oil about every 1500-2000 miles, even after a recent oil change. So I took it to the place I purchased the car from and they replaced the timing chain gasket thing. About a week later the same issue came back. So I took it to Audi to have the same thing replaced. And about a month later the issue came back. Took it back to Audi and they said now the Engine speed sensor seal is leaking oil. I’ve did some research and I’ve found that there is a manufacturing engine defect that causes this reoccurring issue and most Q5 owners have stopped spending money on repairs and just tops off the oil when asked.

NHTSA ODI 11576366

The vehicle oil level low light comes on every 600 miles (excessive oil consumption). I purchased the vehicle in July 2021, and in 2 weeks I had an oil-level light. I called Audi regarding the condition, they talked with the dealership regarding the issue and came back in 2 weeks and stated that the recall was up to 2011. I would like Audi to pay to repair my vehicle, because is a known problem which should have been resolved. Oil Change on 1/12/24; had to put oil in on 2/20/24

NHTSA ODI 11573371

The contact owns a 2013 Audi Q5. The contact stated that the vehicle was experiencing an abnormal oil consumption. The low oil pressure warning light was illuminated. The contact stated that she had been adding a quart of oil to the vehicle every 200 miles driven. The dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.

NHTSA ODI 11548190

The coolant system on this car was repaired by Santa Monica Audi in jan 2020. Less than three years later he the coolant is leaking again with dangerously low level of coolant in the engine. This is a real safety hazard and could lead to a fire or engine overheating This is compounded by Audi Santa Monica charging $310 to simply perform a visual inspection which confirmed the water pump and thermostat needs replacing. Even though it’s related to the earlier coolant pump recall, the burden is on the consumer to pay and the elevated Safety risk remains.

NHTSA ODI 11507912

Driving and warning light came on “steering defective do not drive.” Power steering and use of wheel went out, and wheel would not turn or move in the middle of driving down the street.

NHTSA ODI 11493317

this car should be included in the NHTSA Campaign Number: 18V229000. Having the same issues as owners of other Audi Q5 have reported. while driving the Pull over and Check coolant message appears each time in vehicle. Coolant was leaking. The coolant is leaking onto the ground while refilling the reservoir but not coming from the reservoir.

NHTSA ODI 11489219

The recalls were not completed and the dealership is charging for recall work.

NHTSA ODI 11473398

CONSUMER WRITES IN REGARD TO BRAKE THROTTLE OVERRIDE ON VARIOUS VEHICLES. THE CONSUMER STATED THAT WHEN REMOVING THE LEFT FOOT FROM THE BRAKE, THERE WAS A DELAY WHEN THE RIGHT FOOT WAS APPLIED TO THE ACCELERATOR. THE DELAY CAUSES THE INABILITY TO MERGE QUICKLY INTO TRAFFIC.

NHTSA ODI 11468312

I took my vehicle to Audi South Austin on 6/1/22 regarding my A/C and back up camera not working, continuous oil consumption issue, passenger air bag light turning on, and RPM higher than normal while idling. Christina Turner told me that the wait for my car to be service was 3-4 weeks. She quoted me a price of $275 for each diagnostic test. I mentioned a recall regarding the auxiliary heater and she told me that the recall had previously been completed. I asked her if there was a warranty and she mentioned that it was 12 months/ 12,000 miles and that my vehicle was over that time frame. I have took my vehicle serval times to Audi South Austin regarding the oil and coolant consumption. The first service was on 12/5/20regarding an oil change, multi point inspection, and coolant topped off. I was told if I had any issues with the oil or coolant consumption to let them know. I took my vehicle to Audi North Austin on 2/8/21 regarding my coolant and oil consumption. The told me that I had an oil and coolant leak. When I mentioned the recall of the coolant pump, they told me that the oil leak caused the coolant leak and wouldn’t be covered. I notified Audi South Austin regarding the issues and asked them why they didn’t notice the oil leak during the oil change and inspection. They told me that they would do the recall issue and charge me approximately $5,000 for the oil leak. After showing them the invoice from Audi North of the oil charge being approximately $1,500, they offered the same amount. I have returned to Audi South Austin regarding the oil consumption and oil marks on the side of my car and they technician tells me that it’s normal for my make and model to consume oil and that I would just have to add oil. I’m worried that there is an electrical issue regarding the auxiliary recall and could catch fire while I’m driving. I also have 2 children and it’s difficult driving in 96 degrees weather without A/C and having to wait 3-4 weeks.

NHTSA ODI 11467537

The top of the fuel pump connected to the fuel tank shows hairline cracks and fuel is spraying out of the fuel pump into a well in the rear seat

NHTSA ODI 11464638

COOLANT PUMP BECAME BLOCKED IN MY 3.0 ENGINE VEHICLE, CAUSING IT TO OVERHEAT. THIS MAY BE A SIMILAR PROBLEM TO THE 2.0 VEHICLE, FOR WHICH THERE HAVE ALREADY BEEN 2 RECALLS. MY AIR CONDITIONER STARTED BLOWING FUSES REPEATEDLY (DAILY TO WEEKLY) LAST YEAR AND THE MECHANIC THINKS IT MAY BE A RELATED ISSUE.

NHTSA ODI 11456846

The sliding sunroof exploded out of nowhere with no impact while on the Interstate. The glass rained down on us as we were traveling around 65 mph.

NHTSA ODI 11448642

The contact owns a 2013 Audi Q5. The contact stated while driving 10 MPH in a parking lot after depressing the brake pedal the vehicle began to accelerate independently. The contact stated no warning light was illuminated. The contact was able to stop the vehicle by shifting into the park. The contact stated that he had experienced the failure multiple times. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The vehicle was not repaired but was pending repairs. The manufacturer had not been informed of the failure. The failure mileage was approximately 47,000.

NHTSA ODI 11445909

The engine pistons are defective and consume an excessive amount of oil. This has been confirmed through the manufacturer's own prescribed testing of the vehicle. As a result, the vehicle is not drivable due to the safety risks include sudden engine breakdown while driving.

NHTSA ODI 11438823

My daughter drove her car to Hobby Lobby in Opelika, AL. After being in the store for about 7 minutes they announced over the intercom for the owner of a black audi to come to the front. They told her that her car was on fire. She went outside and black smoke and fire was coming from the hood. A lady had already called 911. While waiting, flames started coming from the bottom of the car. The police arrived and started trying to put the fire out, then firefighters arrived and put the fire out. After the fire was put out, the car kept trying to start itself so they had to locate the battery to disconnect it. Luckily the firefighters were a few stores down and was able to get to it quick. The car is available for inspection and we feel that this is some type of malfunction that we shouldn't be responsible for. A fire is very dangerous and could have hurt or killed my daughter if it had caught fire with her in it and also it catching fire around other cars that put others in danger or if it would have been at night at home under our carport and ended up catching our house on fire! The car has not been inspected by anyone. We didn't have full coverage insurance since I had just changed our policy since where I worked closed down so in the meantime of going from full coverage insurance to liability for a month and a half, this happened. So now we don't really know what to do, as we feel this isn't something we should have to pay for. We feel that Audi should be responsible for this malfunction/defect. No warnings and we have our vehicles maintenanced regularly.

NHTSA ODI 11429831

Panoramic sunroof glass panel shattered. Obviously, if the glass had fallen while I was driving, I (or any passengers) could have been cut and injured. I also could have been distracted and injured myself or someone else in a crash. Rockville Audi has not inspected it yet; although, they are scheduling the repair. The vehicle was inspected on July 1st at about 9:00pm by two Washington National Cathedral Police Officers (Sergeant Lozano and Officer Reyes or Navarro) shortly after it was discovered. The phone number to reach Washington National Cathedral Police is (202) 537-5667. There were no warning lamps or other symptoms that this was going to happen.

NHTSA ODI 11423235

1. ADAPTIVE LIGHT NOT FUNCTIONING. WARNING LIGHT FLASHING FOR OVER A YEAR NOW. " ADAPTIVE LIGHT DEFECTIVE" SYMBOL FLASHING. 2. AC/HEATING FAN "SQUEALING" LOUDLY. BEGAN ABOUT A MONTH AGO.

NHTSA ODI 11383444