What 526 owners told NHTSA about the 2012 Volkswagen Jetta Hev

ON SEVERAL OCCASIONS THE IGNITION WILL NOT TURN OFF. THE KEY IS STUCK IN THE ON POSITION AND CAN NOT BE REMOVED. ON ONE OCCASION IT TOOK OVER 7 MINUTES TO REMOVE THE KEY. THIS MAY NOT SEEM LIKE A LONG TIME, BUT SIT IN YOUR CAR AFTER PARKING THEN TIME 7 MINUTES AND YOU'LL SEE HOW FRUSTRATING THIS IS!

NHTSA ODI 10743600

IGNITION LOCK/SWITCH STUCK IN "ON" POSITION. UNABLE TO TURN OFF ENGINE OR REMOVE KEY. SAFETY AND SECURITY RISK BEING UNABLE TO SECURE VEHICLE OR TURN OFF ENGINE.

NHTSA ODI 10735697

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. THE CONTACT'S KEY BECAME STUCK IN THE IGNITION SWITCH WHILE IN THE RUN POSITION. THE DEALER WAS ABLE TO SHUT OFF THE ENGINE ONLY BY DISCONNECTING FOUR OF THE FIVE FUEL INJECTORS. THE DEALER STATED THAT THEY WOULD NEED TO DESTROY THE TRIM AND REMOVE AND REPLACE THE IGNITION LOCK AND SWITCH ASSEMBLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000.

NHTSA ODI 10733910

THE VEHICLE WAS BEING BACKED OUT OF A DRIVEWAY INTO THE ROADWAY WHEN THE HORN BEGAN TO SOUND CONTINUOUSLY AND THE AIRBAG WARNING LIGHT ILLUMINATED. THE VEHICLE NEEDED TO BE TURNED OFF COMPLETELY TO STOP THE HORN. SUBSEQUENTLY, THE HORN SOUNDS WHENEVER THE IGNITION IS ENGAGED SOMETIMES STOPPING ONCE THE ENGINE TURNS ON, SOMETIMES NOT. ONCE STARTED THE VEHICLE IS DRIVEABLE BUT THE AIRBAG WARNING LIGHT IS ILLUMINATED, THE HORN ON THE STEERING WHEEL IS INOPERABLE AND THE STEERING WHEEL CONTROLS ARE INOPERABLE. THE VEHICLE WAS TAKEN TO A VOLKSWAGEN DEALERSHIP AND DIAGNOSED WITH A FAULTY CLOCK SPRING THAT REQUIRES REPLACEMENT. THE INCIDENT APPEARS TO BE SIMILAR TO THAT DESCRIBED IN NHTSA INVESTIGATION PE 15-010.

NHTSA ODI 10730955

2012 VOLKSWAGEN JETTA. ATTORNEY REPRESENTING CONSUMERS REQUESTS RECALL NOTICES FOR VEHICLE. *SMD BOTH OCCUPANTS IN THE VEHICLE WERE INJURED. *JB

NHTSA ODI 10725025

THE CAR IS A 2012 JETTA SPORTWAGON TDI. IT HAS RECEIVED ALL APPROPRIATE SERVICE AND MAINTENANCE, AND ONLY DIESEL FUEL HAS BEEN USED IN THE CAR. THERE WAS APPROXIMATELY 1/2 TANK OF DIESEL LEFT WHEN THE INCIDENT OCCURRED. WHILE DRIVING ON A RESIDENTIAL STREET, THE GLOW PLUG WARNING LIGHT BEGAN TO FLASH. APPROXIMATELY 30 SECONDS LATER THE ENGINE BEGAN TO LOSE POWER, AND WITHIN TWO MINUTES DIED COMPLETELY. I WAS ABLE TO COAST TO THE CURB AND PARK, BUT THE CAR WOULD NOT START AGAIN. AN INSPECTION BY A CERTIFIED MECHANIC FOUND METAL SHAVINGS THROUGHOUT THE FUEL/PROPULSION SYSTEM, AND DIAGNOSED A BLOWN HIGH PRESSURE FUEL PUMP. THIS IS A KNOWN ISSUE WITH VW TDI ENGINES.

NHTSA ODI 10724844

2012 VOLKSWAGEN JETTA. CONSUMER WRITES IN REGARDS TO KEY STUCK IN THE IGNITION. *SMD THE CONSUMER STATED THE VEHICLE COULD NOT BE TURNED OFF. A MECHANIC UN-PLUGGED A WIRE. THE VEHICLE HAD TO BE TOWED TO THE DEALER. *JB

NHTSA ODI 10723987

CHECK ENGINE LIGHT CAME ON AND WHILE DRIVING TO DEALER FOR SERVICE THE CAR ENGINE FAILED COMPLETELY WHILE DRIVING AT 60 MPH ON FREEWAY. CAR HAD NO PROPULSION AND CAME TO A ROLLING STOP. UNABLE TO RESTART CAR. TOWED TO VW DEALER AND THEY SAID VW TDI FUEL PUMPS HAVE HAD ISSUES AND COULD FAIL. LUCKILY NOBODY WAS INJURED BUT COULD HAVE BEEN VERY DANGEROUS AS ENGINE SHUT DOWN IMMEDIATELY AND FAILED COMPLETELY WHILE ON FREEWAY. I WAS VERY SHAKEN BY THE INCIDENT AND WAS UNABLE TO MOVE ALL THE WAY TO SIDE OF FREEWAY. STILL DO NOT HAVE CAR BACK AND VW DEALER INDICATED IT WOULD BE A LARGE REPAIR

NHTSA ODI 10724183

VEHICLE ENGINE (JETTA 2.0 TDI) ABRUPTLY STALLED AND WOULD NOT RESTART. THE DEALER STATED THAT THE HIGH PRESSURE FUEL PUMP HAD FAILED; AND HAD DISINTEGRATED IN A FASHION THAT THE DEBRIS HAD CONTAMINATED THE ENTIRE FUEL SYSTEM. FUEL TANK, LINES AND INJECTION SYSTEM WERE CLEANED, FUEL PUMP AND FILTERS WERE REPLACED. HOWEVER, THE VEHICLE HAS STILL EXPERIENCED INTERMITTENT STALLING PROBLEMS EVER SINCE THIS WARRANTY REPAIR, AND THE DEALER HAS BEEN UNABLE TO RESOLVE AFTER NUMEROUS ATTEMPTS. THE VEHICLE HAS BEEN (AND CURRENTLY REMAINS) AT THE DEALER FOR 33 OF THE PAST 40 DAYS.

NHTSA ODI 10721695

AT THE TIME OF A ROUTINE TIRE ROTATION, IT WAS NOTICED THE INSIDE OF 3 TIRES WERE SPLIT. ONE OF THESE SPLITS WAS SIGNIFICANT ENOUGH THAT THE TIRE TECHNICIAN RECOMMENDED NOT DRIVING FURTHER. THE TREAD ON THE TIRES AND OUTSIDE SURFACE WAS STILL IN GOOD CONDITION. THE TECHNICIAN STATED THERE WAS ALMOST HALF THE REGULAR TREAD LEFT. IT SEEMS UNUSUAL TO HAVE SPLITS ON THREE TIRES AT ONCE IN THE SAME LOCATION ON WHAT OTHERWISE WOULD STILL BE GOOD TIRES. THIS CAR HAS NOT BEEN INVOLVED IN ANY UNUSUAL ACCIDENTS OR INCIDENTS WHICH WOULD HAVE HAD A NEGATIVE IMPACT ON TIRE WEAR. THESE ARE THE ORIGINAL TIRES THAT CAME WITH THE CAR.

NHTSA ODI 10721016

DURING FEBRUARY, THE 2012 VW TDI JETTA SPORTWAGEN WITH 59,7000 MILES STALLED TWICE WHEN TRYING TO START THE VEHICLE. ON THE THIRD START THE VEHICLE STARTED BUT THE GLOW PLUG LIGHT WAS FLASHING AND THE CAR WOULD NOT ACCELERATE TO MORE THAN 45 MPH. THE VEHICLE LIMPED TO THE DEALERSHIP, WHO FOUND METAL FLAKES IN THE FUEL FILTER AND STATED THAT THE IN-TANK FUEL PUMP HAD FAILED. THE IN-TANK FUEL PUMP WAS REPLACED AND THE FUEL SYSTEM WAS APPARENTLY CLEARED OF METAL. AT 63,000 MILES, THE GLOW PLUG LIGHT BEGAN TO FLASH WHILE AT HIGHWAY SPEED AND THE VEHICLE BEGAN TO LOSE POWER. I GOT THE VEHICLE TO AN EXIT, STOPPED IT, TURNED THE VEHICLE OFF AND RESTARTED. THE GLOW PLUG LIGHT WAS NO LONGER FLASHING AND THE CAR WAS DRIVABLE ALTHOUGH IT WAS LACKING SOME ACCELERATION AND THERE WAS A MOAN/WHINE NOISE COMING FROM THE ENGINE. GOT THE CAR BACK TO THE DEALERSHIP AND LEARNED THAT THE HIGH PRESSURE FUEL PUMP HAS FAILED AND THAT THE ENTIRE FUEL SYSTEM NEEDS TO BE REPLACED. THERE IS NO MIS-FUELING ISSUE, AND DIESEL RECEIPTS ARE KEPT AT FILL UP.

NHTSA ODI 10716571

TL* THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA. WHILE AT A COMPLETE STOP ON AN INCLINE, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A TWO SECOND DELAYED RESPONSE. THE VEHICLE WAS EQUIPPED WITH AN ELECTRONIC HILL START ASSISTANCE FEATURE. THE FAILURE RECURRED NUMEROUS TIMES. ON A SEPARATE OCCASION, THE UNOCCUPIED VEHICLE WAS PARKED ON A SLIGHT INCLINE AND THE VEHICLE ROLLED WITH THE EMERGENCY BRAKE ENGAGED. THE VEHICLE CRASHED INTO A TREE. FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE VEHICLE OPERATED AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.

NHTSA ODI 10715916

2012 VOLKSWAGEN SPORTWAGEN TDI. WHEN TRAVELING ON THE FREEWAY 4/11/15 GLOW PLUG LIGHT BEGAN BLINKING, WE NOTICED AN IMMEDIATELY SIGNIFICANT LOSS OF POWER. AT THIS MOMENT WE WERE TRAVELING ON A TWO LANE FREEWAY THAT HAPPENED TO HAVE ONE LANE BLOCKED. VEHICLES IMMEDIATELY BEGAN STACKING UP BEHIND US. AFTER PULLING OFF THE FREEWAY ATTEMPTED TO STOP AND RESTART THE ENGINE, WE HAD A VERY DIFFICULT TIME RESTARTING THE MOTOR. WAS ABLE TO DRIVE BACK TO THE DEALERSHIP, HOWEVER HAD A SIGNIFICANT REDUCTION IN POWER, SAFETY WAS A CONCERN AND WAS VERY WORRIED THAT THE VEHICLE WOULD STALL WHILE ON THE FREEWAY. BECAUSE OF THIS WE PULLED OFF THE FREEWAY AND CONTINUED TO LIMP TOWARDS THE DEALERSHIP ON LOCAL ROADS. THERE WAS SO MUCH REDUCTION IN POWER THAN DRIVING UP A SMALL HILL ALMOST BROUGHT THE VEHICLE TO A STOP. DEALERSHIP ACCUSED US OF FUELING THE VEHICLE WITH GAS INSTEAD OF DIESEL, GAS STATION WAS ABLE TO PRODUCE A RECEIPT SHOWING THAT WE HAD FILLED THE VEHICLE WITH DIESEL. HOWEVER, VW IS COVERING THE REPAIR, AND VEHICLE IS READY TO BE PICKED UP 4/16/15. DID NOT FEEL THAT THE FUEL PUMP FAILURE HAD ANYTHING TO DO WITH MISFUELING, AND WHILE VW IS COVERING THE REPAIR, IT APPEARS THAT THIS ISSUE IS A WELL DOCUMENTED FAILURE WITH VW. WE DO FEEL THAT OUR SAFETY COULD HAVE BEEN COMPROMISED WITH THIS FAILURE. *TR

NHTSA ODI 10706311

CANNOT SHUT ENGINE OFF. CANNOT REMOVE IGNITION KEY. *TR

NHTSA ODI 10705750

TIRE HAD CATASTROPHIC FAILURE ON SIDE WALL. 4TH TIME THIS HAS OCCURRED WITH SPECIFIC TIRES "DUNLOP SP SPORT 01 AS". *TR

NHTSA ODI 10703537

WAS DRIVING 40 AND WAS HEADING DOWN A HILL AND WAS COMING TO A STOP WHEN MY 2012 VW JETTA SPORTSWAGEN POWER FLICKERED, COIL LIGHT (GLOW LIGHT) CAME ON, IT MADE A LOUD NOISE AND DIED. I WAS UNABLE TO MOVE IT, COULD OF BEEN A BAD SITUATION. THANKFULLY VW DEALERSHIP SERVICE GAVE ME A NUMBER TO A LOCAL TOWING COMPANY. I WAS QUICKLY TOWED TO DEALERSHIP. IT SOUNDS LIKE SO MANY OTHERS HAVE HAD THIS PROBLEM. WAITING TO HEAR OFFICIAL DIAGNOSTICS. *TR

NHTSA ODI 10694231

WHILE DRIVING IN THE FREEWAY AT SPEED OF 20 MPH DUE TO HIGHWAY TRAFFIC, I SMELLED DIESEL FUEL THROUGH THE AIR VENTS. THE VEHICLE SUDDENLY BEGAN TO LOOSE POWER AND THE PEDAL WAS NOT FUNCTIONAL COMPLETELY AFTER, THE VEHICLE SHUT OFF AND STALLED ON THE HIGHWAY. THE MIL (MALFUNCTION INDICATOR LAMP) AND BATTERY DASH WARNING LIGHTS CAME ON. THE CAR WOULD NOT START OVER AND WAS TOWED OUT OF THE HIGHWAY. I NOTICED THERE WAS A DIESEL FUEL LEAK UNDERNEATH THE VEHICLE. THE CAR WAS THEN TOWED TO A VOLKSWAGEN DEALER AND DIAGNOSIS WERE MADE RESULTING IN FUEL PUMP REPLACEMENT. *TR

NHTSA ODI 10692707

WHEN THE TEMPERATURE IS COLD, THE WINDSHIELD WIPERS ON OUR 2012 VW JETTA REFUSE TO ACTIVATE CAUSING A SERIOUS SAFETY CONCERN, ESPECIALLY WHEN WE'RE DRIVING AND THE TEMPERATURE DROPS. WHEN THE TEMPERATURE WARMS BACK UP, THE WIPERS START WORKING AGAIN. I'VE CONTACTED VW OF AMERICA AND DESPITE THE # OF COMPLAINTS ABOUT THIS ISSUE, THEY REFUSE TO HELP ME OUT. *TR

NHTSA ODI 10692073

SINCE PURCHASING THIS VEHICLE NEW ALMOST 3 YEARS AGO, IT HAS VERY OCCASIONALLY EXHIBITED A HESITATION DURING ACCELERATION FROM A STOP. IT IS A TDI VERSION WITH THE AUTOMATED MANUAL DSG TRANSMISSION. UP TILL NOW, IT HAS BEEN IMPOSSIBLE TO INDUCE ON COMMAND, MAKING IT VERY DIFFICULT FOR THE TWO DEALERSHIPS THAT HAVE EXAMINED IT TO IDENTIFY THE PROBLEM. EACH TIME THIS HAS OCCURRED, IT SEEMS TO FOLLOW A VERY BRIEF ACCELERATION, AS THOUGH YOU ARE STARTING TO MOVE INTO TRAFFIC AND THEN BACK OFF THE THROTTLE FOR AN INSTANT BEFORE REAPPLYING THE THROTTLE. AS YOU STEP BACK INTO THE THROTTLE, THERE IS NO CHANGE IN ENGINE SPEED FOR ABOUT THREE SECONDS, REGARDLESS OF PEDAL POSITION - IT JUST CONTINUES TO IDLE UNTIL IT FINALLY RESPONDS NORMALLY. SINCE THIS USUALLY OCCURS WHEN MAKING A LEFT TURN IN FRONT OF ONCOMING TRAFFIC OR MERGING FROM A DRIVEWAY, THE THREE SECONDS OF DELAY DURING WHICH YOU ROLL FORWARD CAN BE VERY DANGEROUS. *JS

NHTSA ODI 10690205

TL*THE CONTACT OWNS A 2012 VOLKSWAGEN JETTA EQUIPPED WITH HANKOOK TIRES, TIRE LINE: OPTIMO H725A, TIRE SIZE: P205/55/R16 AND DOT NUMBER: 1GRPDYH. THE CONTACT STATED THAT THE LEFT FRONT DRIVER'S SIDE TIRE WALL WAS SEPARATING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE TIRE NEEDED TO BE REPLACED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 47,500.

NHTSA ODI 10690445

LEFT REAR CALIPER IS SEIZING, WONT LET GO OF CALIPER. MECHANIC SAYS THE CALIPER HAS RUSTED SHUT AFTER ONLY 45,000 MILES AND HE SEES THEM ALL THE TIME ON VW VEHICLES. *TR

NHTSA ODI 10682496

FOR THIS YEAR OF JETTA THE DOORS LOCK AROUND 10 MILES AN HOUR. MINE DOES NOT LOCK. THE DOORS WILL KEEP ATTEMPTING TO LOCK WITH NO SUCCESS. IF YOU GO ON A LONG TRIP AND SLOW DOWN TO THE 10 MPH RANGE THEY WILL TRY TO LOCK AGAIN. THE DOOR ALSO DOES NOT LOCK WHEN YOU PUSH BUTTON. YOU MUST KEEP PRESSING IT UNTIL IT FINALLY LOCKS. *TR

NHTSA ODI 10682366

SAME PROBLEM AS DESCRIBED IN NHTSA ACTION NUMBER: PE09035 AND NHTSA RECALL CAMPAIGN NUMBER:09V333000 CAR IS CURRENTLY AT VOLKSWAGEN DEALER AWAITING A REPLACEMENT MEGATRONICS UNIT TO REPLACE ORIGINAL UNIT. VEHICLE WOULD NOT ACCELERATE AFTER STOPPING AT A TRAFFIC LIGHT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TR

NHTSA ODI 10679447

THE CAR, A 2012 VW JETTA SE, FAILED TO RESPOND TO THE REVERSE GEAR ON 1/5/2015 AND BEHAVED AS IF THE EMERGENCY BRAKE WAS STILL ENGAGED. THE REAR TIRES WOULD NOT MOVE AND THE REVERSE MANEUVER FAILED. THE DEALERSHIP WAS CALLED AND THEY RECOMMENDED TOWING TO THEIR FACILITY. THIS WAS ACCOMPLISHED ON 1/9/2015 AND TO DATE THERE HAS BEEN NO RESOLUTION.

NHTSA ODI 10672110

TRIED TO START VEHICLE STARTED ONCE THEN STALLED IMMEDIATELY. TRIED A SECOND AND THIRD TIME VEHICLE WOULD JUST CLICK. LET CAR SIT 14 HOURS VEHICLE CLICKED ONCE THEN STARTED AND RAN ROUGH WITH WHITE SMOKE COMING OUT OF EXHAUST. READ UP ON HARD STARTS AND FOUND OUT ABOUT INTERCOOLER FREEZING. PULLED TUBING OFF AND FOUND APPROX. 2-3 OZ OF CLEAR WATER AND 4-5 OZ OF GREEN SLUDGE IN THE INTERCOOLER PIPING. NUMEROUS INSTANCES OF THIS HAVE OCCURRED EVEN ON THE HIGHWAY SOME OF THESE HAVE RESULTED IN A CONDITION CALLED HYDROLOCK RESULTING IN BENT CONNECTING RODS. THIS HAS ALSO OCCURRED IN VEHICLES BEING DRIVEN AT HIGHWAY SPEEDS. AT HIGHWAY SPEEDS THIS WILL CAUSE A RAPID LOSS OF ENGINE POWER POSSIBLY CAUSING A VEHICLE ACCIDENT. THERE ARE NUMEROUS FORUMS NOTING THIS IN 2009-2012 MODELS AND POSSIBLY 13-14 MODELS. *TR

NHTSA ODI 10672336