What 26 owners told NHTSA about the 2012 Ford Transit

The contact owns a 2012 Ford Transit Connect. The contact stated that while the vehicle was parked, the contact became aware that the front driver’s and front passenger’s seat belts were damp following a rainstorm. Upon inspection, the contact observed that the door seals on both front doors were allowing water to enter the vehicle, causing the seat belts to become damp. The vehicle was taken to a dealer; however, it was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 116,838.

NHTSA ODI 11709702

TL* THE CONTACT OWNS A 2012 FORD TRANSIT CONNECT. THE CONTACT STATED THAT THE DASHBOARD DETERIORATED, WARPED AND THE FRAMEWORK WAS VISIBLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS OVER THREE TIMES BUT THE FAILURE WAS RECURRING. THE CONTACT LATER NOTICED THE PRESENCE OF A LEAK. THE CONTACT FURTHER INSPECTED THE VEHICLE AND NOTICED THAT THE SEAMS NEAR THE WINDSHIELD HAD BECOME LOOSE, CAUSING WATER TO LEAK INTO THE VEHICLE THROUGH THE DASHBOARD AND WINDSHIELD. THE DEALER USED AN EPOXY SEAL TO REPAIR THE VEHICLE HOWEVER, THE REPAIR CAUSED DAMAGE TO THE WINDSHIELD WHICH BECAME CRACKED. ADDITIONALLY, AN UNKNOWN GRAY SUBSTANCE WAS LEAKING INTO THE VEHICLE NEAR THE WINDSHIELD AND DASHBOARD AREA. THE DEALER THEN REFERRED THE CONTACT TO AN INDEPENDENT DEALER, WHO REPLACED THE WINDSHIELD. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148.

NHTSA ODI 10670608