What 820 owners told NHTSA about the 2012 Ford Explorer Hev

The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 15 MPH, the "Service Power Steering" message was displayed. The contact pulled into a parking lot, turned off and then restarted the vehicle. The failure persisted, and the power steering feature failed to operate as needed. While in reverse, the back over prevention camera display the "Service Camera - Take to Dealer" message on the screen. The dealer was contacted and confirmed that there was a recall for the failure, NHTSA Campaign Number: 14V286000 (Steering); however, the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 237,000.

NHTSA ODI 11746616

Failure of the dealerships to fix recall in timely manner It’s been over two years and parts still unavailable

NHTSA ODI 11745848

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part required for the recall repair was unavailable. The contact stated the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was unavailable. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11743199

I received the first recall notice for this defect from Ford Motor Co. in February 2024 and took the vehicle to Sheehy Ford in Ashland, Virginia on August 7, 2025. Sheehy Ford did the required inspection and confirmed that the vehicle had defective windshield rubber molding. The inspection required that the plastic body molding on both sides of the windshield be removed, which rendered them unusable and could not be replaced. Sheehy Ford said they had ordered the necessary replacement parts from Ford Motor Co. and would notify me when they were received. I have been following up with Sheehy Ford every couple of months since August 2025 and they say the replacement parts are still not available from Ford Motor Co. It seems to me that 9 months is an unreasonable amount of time to provide the necessary parts for this Safety Recall, especially missing the plastic windshield moldings, my car is unsellable, which I would like to do.

NHTSA ODI 11738521

The contact owns a 2012 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The failed power steering warning light illuminated. In addition, the steering wheel seized. The vehicle was taken to an independent mechanic, however the failure was not diagnosed. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall which had a similar failure description, however the contact's VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,063.

NHTSA ODI 11737559

The contact owns a 2012 Ford Explorer. The contact stated that the hazard lights and other surrounding indicator systems were inoperable. Additionally, the rearview camera displayed a blank image while reversing. The dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 208,974.

NHTSA ODI 11734667

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed on the highway, the driver's side A-pillar trim clip became partially detached on the side of the windshield. The dealer was notified of the failure, but the vehicle was not repaired. The manufacturer was notified of the failure. The contact associated the failure with NHTSA Campaign Number: 24V031000 (Structure); however, the vehicle was previously repaired under the recall. The approximate failure mileage was 155,500.

NHTSA ODI 11732733

Hi! I brought my car in to the Ford dealership in Lexington, SC to get a recalled A Frame Pillar repaired. They took the part off and didn’t repair it because they didn’t have the parts in. When I called corporate to check on the status of that part, I found out they had marked the recall as “complete” which was not the case. Corporate opened the case again for me, so it should’ve read incomplete in their system. (Therefore, maybe they would call me to let me know the part was in stock. That didn’t happen.) When I called back 2 months later, they had apparently marked it as complete a second time. Which again, was false. 12 months later, they’re finally agreeing to replace the part. I also found out from corporate in that same phone call that I had a recall to a power steering component. When I called the shop, they said that had been marked as complete too so I was not eligible for a second replacement. I have a hard time trusting that the original was actually replaced now. And the steering feels like a major safety concern! Point is, I’m worried that location may be doctoring their documentation, marking recalls as repaired when repairs have clearly not been made. I’d hate for it to cause a major accident or something. Bringing this up in case it warrants an audit. I’m sure I’m not the only person they’ve done this to. I’ve opened a case with Ford’s Automatice Safety Office as well and they are investigating but I thought it prudent to mention to an outside source. Like I said, I’d hate for someone to get in accident because they thought a repair had been made when it actually never was.

NHTSA ODI 11732810

My car gave a “power steering fault” message on the dash while my son was driving on I-95 on April 12. The steering wheel locked up making turning impossible and could have been fatal. He had pull over and have the vehicle towed home.

NHTSA ODI 11730731

The steering went out on the car and I was unable to steer. Almost causing me to have a accident. I had to have a tow truck come and pick it up off the road. Thank God I was alone and my whole family was not in the car. There needs to be a recall on this there has already been so many accidents. If it has not already happen there is going to end up causing a fatality. What is it going to take a child to loose their life before Ford does something about this?? WAKE UP FORD THIS IS CRAZY!!! Really 2 questions down you ask if there was a accident or fatality? Don't wait till someone's child or grand baby dies! It not a matter of if it is a matter of when! I have seen so many people saying online saying they have had the same problem. This is scary! I thank God daily I did not crash or even worse crash and Kill another person or an innocent baby! I can get photos and tow bill but I didn't have it handy.

NHTSA ODI 11729579

Recall 24V031 has not been fixed. I got my recall notice from Ford with regards to the A-pillar applique trim. I received my recall in February, 24. I have visited my local Ford dealer several times and as recently as 1 month ago. They state the parts are not available. My driver side A-pillar applique is missing. My passenger side applique is loose. Why are parts not available? After 2 years of recall notice!!

NHTSA ODI 11719326

Plastic trims on both sides of the windshield are recalled and ford has not fixed yet. Safety hazard driving and both pieces are loose on vehicle.

NHTSA ODI 11718316

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and informed the contact that the part was on backorder. The contact stated that the vehicle could not be registered in the State of California due to the incomplete recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11713995

Started the Explorer in a parking lot. When backing out the steering wheel was impossible to turn. A Power Steering failure light came on. Pulled the Explorer back into the parking spot and turned off the vehicle. Restarted the vehicle and steering became functional again. This appears to be a common ford problem and the recall should be reopened. It would be dangerous if this happened on a the road while driving.

NHTSA ODI 11713792

The contact owns a 2012 Ford Explorer. The contact stated that while reversing, the vehicle lost power steering functionality and struck another unoccupied parked vehicle. The contact inspected the vehicle and noticed that the rear of the vehicle had sustained scratches. There was no injury sustained. No Police report was filed. The contact stated that the power steering failure was initially intermittent, but the failure had become a constant failure. The vehicle was taken to the dealer, where it was diagnosed that the electronic power steering and steering gear assembly needed to be replaced. The contact was informed that the repair was not covered because the 10-year warranty period had expired. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 80,000.

NHTSA ODI 11710962

Unknown my Steering wheel locked up while driving

NHTSA ODI 11710317

Total loss of Electric power steering assistance while driving on the interstate.

NHTSA ODI 11709483

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. In addition, the power steering and advanced traction control warning lights were illuminated. The contact stated that the vehicle was very difficult to steer. The vehicle was taken to the dealer, where it was diagnosed with an electronic power steering module failure. The contact was informed that the electronic power steering module needed to be replaced. The vehicle was not repaired. The contact was concerned that the failure might cause a crash. The contact referenced the notification of NHTSA Campaign Number: 14E001000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 138,239.

NHTSA ODI 11704528

Failure of Power Steering A hard steering wheel on a 2012 Ford Explorer with electric steering (EPAS

NHTSA ODI 11704276

The Power Steering pump (EPAS) when out on me yesterday while driving on the highway. I was switching lanes on the highway when the service advance trac light came on and the steering wheel became stiff really difficult to move putting myself in danger while driving in a higher speed limit zone.

NHTSA ODI 11701127

The rear back up camera is now displaying a message to contact dealership. It freezes up and stops working.

NHTSA ODI 11696791

My back-up camera has flipped images so the left appears on the right and the right appears on the left as well as the safety lines have disappeared. The two Ford dealerships want a diagnostic fee that doesn't even go toward the cost of the repairs.

NHTSA ODI 11696547

Faulty rear view camera. Says contact the dealership on the message.

NHTSA ODI 11694934

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the passenger's side and driver's side windshield exterior A-pillar trims had separated and flown off the vehicle while driving. The local dealer was contacted several times and was notified of the failure. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11691834

While driving, my 2012 Ford Explorer displayed a “Service Power Steering Now” warning message, and the steering wheel completely locked, making the vehicle impossible to steer safely. This happened without warning and rendered the car undrivable, creating an immediate safety hazard. This issue matches the conditions described in Ford Safety Recall 14S06 (NHTSA Campaign 14V286000) and Customer Satisfaction Program 15N01, both addressing Electric Power Steering (EPAS) system failures in 2011–2013 Explorers. Ford’s Defect Information Report to NHTSA (PE12-017) states that intermittent electrical connections in the steering gear’s motor position sensor can cause a total loss of power steering assist exactly what occurred in my vehicle. Despite this, Ford and the dealership (Tommie Vaughn Ford, Houston TX) have stated that my VIN is “expired” for program 15N01 and refused assistance. However, the failure mode and symptoms are identical to those covered by these safety campaigns.My Explorer was manufactured in December 2011, which falls directly in the affected build range. The Carfax report for my vehicle even lists program 15N01 EPAS Steering Efforts as an associated service campaign. This is a critical safety issue, and Ford’s refusal to assist due to expired coverage should not override the need to correct a known steering defect. I am requesting that NHTSA investigate whether Ford’s current handling of EPAS steering failures is sufficient, and whether Customer Satisfaction Program 15N01 should be reopened or extended to cover affected vehicles like mine that are experiencing the same safety defect.

NHTSA ODI 11691583