What 821 owners told NHTSA about the 2012 Ford Explorer Gas

The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 15 MPH, the "Service Power Steering" message was displayed. The contact pulled into a parking lot, turned off and then restarted the vehicle. The failure persisted, and the power steering feature failed to operate as needed. While in reverse, the back over prevention camera display the "Service Camera - Take to Dealer" message on the screen. The dealer was contacted and confirmed that there was a recall for the failure, NHTSA Campaign Number: 14V286000 (Steering); however, the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 237,000.

NHTSA ODI 11746616

The contact owns a 2012 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The failed power steering warning light illuminated. In addition, the steering wheel seized. The vehicle was taken to an independent mechanic, however the failure was not diagnosed. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall which had a similar failure description, however the contact's VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,063.

NHTSA ODI 11737559

Hi! I brought my car in to the Ford dealership in Lexington, SC to get a recalled A Frame Pillar repaired. They took the part off and didn’t repair it because they didn’t have the parts in. When I called corporate to check on the status of that part, I found out they had marked the recall as “complete” which was not the case. Corporate opened the case again for me, so it should’ve read incomplete in their system. (Therefore, maybe they would call me to let me know the part was in stock. That didn’t happen.) When I called back 2 months later, they had apparently marked it as complete a second time. Which again, was false. 12 months later, they’re finally agreeing to replace the part. I also found out from corporate in that same phone call that I had a recall to a power steering component. When I called the shop, they said that had been marked as complete too so I was not eligible for a second replacement. I have a hard time trusting that the original was actually replaced now. And the steering feels like a major safety concern! Point is, I’m worried that location may be doctoring their documentation, marking recalls as repaired when repairs have clearly not been made. I’d hate for it to cause a major accident or something. Bringing this up in case it warrants an audit. I’m sure I’m not the only person they’ve done this to. I’ve opened a case with Ford’s Automatice Safety Office as well and they are investigating but I thought it prudent to mention to an outside source. Like I said, I’d hate for someone to get in accident because they thought a repair had been made when it actually never was.

NHTSA ODI 11732810

My car gave a “power steering fault” message on the dash while my son was driving on I-95 on April 12. The steering wheel locked up making turning impossible and could have been fatal. He had pull over and have the vehicle towed home.

NHTSA ODI 11730731

The steering went out on the car and I was unable to steer. Almost causing me to have a accident. I had to have a tow truck come and pick it up off the road. Thank God I was alone and my whole family was not in the car. There needs to be a recall on this there has already been so many accidents. If it has not already happen there is going to end up causing a fatality. What is it going to take a child to loose their life before Ford does something about this?? WAKE UP FORD THIS IS CRAZY!!! Really 2 questions down you ask if there was a accident or fatality? Don't wait till someone's child or grand baby dies! It not a matter of if it is a matter of when! I have seen so many people saying online saying they have had the same problem. This is scary! I thank God daily I did not crash or even worse crash and Kill another person or an innocent baby! I can get photos and tow bill but I didn't have it handy.

NHTSA ODI 11729579

Started the Explorer in a parking lot. When backing out the steering wheel was impossible to turn. A Power Steering failure light came on. Pulled the Explorer back into the parking spot and turned off the vehicle. Restarted the vehicle and steering became functional again. This appears to be a common ford problem and the recall should be reopened. It would be dangerous if this happened on a the road while driving.

NHTSA ODI 11713792

The contact owns a 2012 Ford Explorer. The contact stated that while reversing, the vehicle lost power steering functionality and struck another unoccupied parked vehicle. The contact inspected the vehicle and noticed that the rear of the vehicle had sustained scratches. There was no injury sustained. No Police report was filed. The contact stated that the power steering failure was initially intermittent, but the failure had become a constant failure. The vehicle was taken to the dealer, where it was diagnosed that the electronic power steering and steering gear assembly needed to be replaced. The contact was informed that the repair was not covered because the 10-year warranty period had expired. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 80,000.

NHTSA ODI 11710962

Unknown my Steering wheel locked up while driving

NHTSA ODI 11710317

Total loss of Electric power steering assistance while driving on the interstate.

NHTSA ODI 11709483

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. In addition, the power steering and advanced traction control warning lights were illuminated. The contact stated that the vehicle was very difficult to steer. The vehicle was taken to the dealer, where it was diagnosed with an electronic power steering module failure. The contact was informed that the electronic power steering module needed to be replaced. The vehicle was not repaired. The contact was concerned that the failure might cause a crash. The contact referenced the notification of NHTSA Campaign Number: 14E001000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 138,239.

NHTSA ODI 11704528

Failure of Power Steering A hard steering wheel on a 2012 Ford Explorer with electric steering (EPAS

NHTSA ODI 11704276

The Power Steering pump (EPAS) when out on me yesterday while driving on the highway. I was switching lanes on the highway when the service advance trac light came on and the steering wheel became stiff really difficult to move putting myself in danger while driving in a higher speed limit zone.

NHTSA ODI 11701127

While driving, my 2012 Ford Explorer displayed a “Service Power Steering Now” warning message, and the steering wheel completely locked, making the vehicle impossible to steer safely. This happened without warning and rendered the car undrivable, creating an immediate safety hazard. This issue matches the conditions described in Ford Safety Recall 14S06 (NHTSA Campaign 14V286000) and Customer Satisfaction Program 15N01, both addressing Electric Power Steering (EPAS) system failures in 2011–2013 Explorers. Ford’s Defect Information Report to NHTSA (PE12-017) states that intermittent electrical connections in the steering gear’s motor position sensor can cause a total loss of power steering assist exactly what occurred in my vehicle. Despite this, Ford and the dealership (Tommie Vaughn Ford, Houston TX) have stated that my VIN is “expired” for program 15N01 and refused assistance. However, the failure mode and symptoms are identical to those covered by these safety campaigns.My Explorer was manufactured in December 2011, which falls directly in the affected build range. The Carfax report for my vehicle even lists program 15N01 EPAS Steering Efforts as an associated service campaign. This is a critical safety issue, and Ford’s refusal to assist due to expired coverage should not override the need to correct a known steering defect. I am requesting that NHTSA investigate whether Ford’s current handling of EPAS steering failures is sufficient, and whether Customer Satisfaction Program 15N01 should be reopened or extended to cover affected vehicles like mine that are experiencing the same safety defect.

NHTSA ODI 11691583

The contact owns a 2012 Ford Explorer. The contact stated that while attempting to make a turn, the steering wheel seized. There was no warning light illuminated. The contact stated that the steering wheel became difficult to maneuver, and the steering wheel failed to return to center after making a turn. The vehicle was towed to the residence. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 220,000

NHTSA ODI 11686912

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that upon purchasing the vehicle, the trim on the lower part of the windshield detached and was loosened. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Additionally, the contact stated that there was an abnormal sound coming from the steering wheel, while driving, while making left and right turns, and even while the engine was turned off. The contact stated that the failure had persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 125,000.

NHTSA ODI 11686724

Electric power steering system does not work

NHTSA ODI 11685643

Loss of power steering occasionally, getting a power steering fault, but as of now, starts working again

NHTSA ODI 11685484

The contact owns a 2012 Ford Explorer. The contact stated that while driving on several occasions at various speeds, the steering wheel became extremely stiff and was difficult to turn. Additionally, the "Steering Fault" message was displayed on the instrument cluster. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

NHTSA ODI 11681650

Clunking noise coming from rear possible tow link, clicking noise coming from steering even when vehicle not moving

NHTSA ODI 11670431

The Steering module and steering gear has failed for a second time within a 12 year window. This steering failure was under recall 15n01 and was repaired AUG. 2014, but has failed again April 2025. There is something wrong with parts failure that should not happen again and I think another recall should be filed again for this ongoing problem. This is a safety issue that needs to be addressed before someone has a fatal accident.

NHTSA ODI 11668531

Ford dealership Loganville GA Serviced recall 14s06 on this vehicle on Aug. 2014 when no problems were detected. This closed the recall with no parts being replaced. Now June 2025 the steering module and steering gear failed leaving me not many options because of being just outside the warranty window. I asked ford for a one time replacement of the steering gear since no parts where replaced at time of service but was denied. I think safety issues like this should be addressed on case by case situation. I have all documentation from my local dealership in Fayetteville Ga. I think another recall should be issued because of reoccurring problems with the steering system on this vehicle. Thanks

NHTSA ODI 11668633

Steering assist not working, could not steer the vehicle

NHTSA ODI 11667650

The contact owns a 2012 Ford Explorer. The contact stated while driving 3 MPH, the power steering fault, the turn signal, advance-trac alert, and power train warning lights illuminated. The contact stated that the steering wheel became inoperable. The vehicle was taken to an independent mechanic who determined that the control modules were inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 237,000.

NHTSA ODI 11664869

Electric Power Steering was recalled a replacement was done In 2014 under a recall. Yet it broke again and the car is under 150,000 miles. I have talked to Ford and they will not replace it again. I am not the first person to experience this issue under 150,000 miles. My car is not a giant paper weight in my yard because it cost $2000 to fix more at the Ford dealership it was bought from. I am the second owner. We purchased Ford because it is a product made in the USA but I’m beginning to wonder if that means anything anymore. My Husband has [XXX] so the repair cost is too much for our budget. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11664683

The contact owns a 2021 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 206,000.

NHTSA ODI 11663756