What 353 owners told NHTSA about the 2012 Chevrolet Sonic

The contact owns a 2012 Chevrolet Sonic. The contact stated that on several occasions, while coming to a stop, the vehicle unexpectedly remained in second gear. There were no warning lights illuminated. The contact stated that several attempts were needed for the vehicle to shift into another gear. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for additional assistance. The failure mileage was approximately 77,000.

NHTSA ODI 11720417

Transmission shaft malfunction. Doesn't shift out of 1st gear. Transmission does not engage into gear.

NHTSA ODI 11715161

Reviving the p2138 code for throttle/accelerator sensor. Still getting code after replacing 3 accelerator peddles. Possible manufacture issue with wiring that water gets into connectors shorting out that system

NHTSA ODI 11671614

UNKNOWN

NHTSA ODI 11658643

The contact owns a 2012 Chevrolet Sonic. The contact stated that when the vehicle was turned on, the brakes, ABS, traction control, and braking system warning lights were illuminated. The contact stated while driving the vehicle at an undisclosed speed, the brake pedal was depressed; however, the vehicle took longer than normal to slow down. The contact stated that while the brake pedal was depressed, the vehicle jerked abnormally. The vehicle taken to a dealer where it was it diagnosed and determined that the brake booster pump assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 159,000.

NHTSA ODI 11656528

The contact owns a 2012 Chevrolet Sonic. The contact stated while driving 75 MPH, the vehicle lost power. The check engine OBD reader had lost communication with the transmission. The contact merged to the side of the road. The contact then went to auto parts store and attempted to change the speed sensor; however, the parts store had given the contact the incorrect part. The dealer was contacted and informed the contact that the vehicle was already repaired under NHTSA Campaign Number: 14V315000 (POWER TRAIN). The vehicle had lost throttle and power. The contact then took the vehicle to an independent mechanic who diagnosed the vehicle and linked the failure to NHTSA Campaign Number: 14V315000 (POWER TRAIN). The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,000.

NHTSA ODI 11654601

I purchased this car 2 years ago and it has caused me absolutely nothing but trouble. We have replaced the fan 4 times (twice due to the resistor thats part of the fan failed), headgasket job, intercooler punctures (once inward, once outward), failed valve cover, intake maniford, turbo seals twice, failing check values, new relays for the fan (twice), another drive belt, and now I go outside and theres a puddle of coolant under my car. I have sunk over $8,000 into this car and it has been the worst financial decision ever. Why do the parts keep failing? Why isnt there a heat gage in the dang car so I know its too hot before the light comes on?

NHTSA ODI 11624090

The contact owns a 2012 Chevrolet Sonic. The contact stated that while a friend was driving approximately 35 MPH, the vehicle suddenly veered to the right and struck the curb. Upon inspection, it was discovered that the front passenger’s side suspension had failed. The vehicle was later towed to an independent mechanic who diagnosed that the front driver’s side suspension lower control arm had failed and needed to be replaced, along with the front axle and ball joints. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 111,000.

NHTSA ODI 11605355

While driving on the highway late at night, at approximately 60 mph my 2012 Sonic began to lose power and slowed to a dangerously low speed when there was nowhere for me to pull over! I literally had to coast to a spot that I could barely squeeze off the road! Then would not shift into any workable gear but 1st and after that just revved up loudly. Long story short…had to be towed 35 miles home. Then towed to a reputable garage where they concluded the transmission was shot at about 90,000 miles. Would be around $3800. to rebuild. Come to find out these cars are known for this problem! And yet somehow I’m being told by GM that it’s not included in the Turbine Shaft Fracture Recall for that car’s year/make/model!! WHY?! Needless to say….the car will be junked!

NHTSA ODI 11575685

Water pump is leaking in front of motor

NHTSA ODI 11566713

We have had to deal with severe overheating issues and failing parts our entire ownership of this vehicle, both of which then cause other parts to fail, as the parts are so poorly made and heat sensitive. We have replaced the turbocharger (twice), intake manifold + valve cover (twice), catalytic converter, the radiator (THREE TIMES), the cooling fan (twice), the MAF sensor (twice), and much more. All of this has been done over the course of 18months. This has easily been the most expensive car we have ever owned due to the constant repairs, all of which has been because of Failing Parts and overheating.

NHTSA ODI 11565421

Purchased 2012 Chevy Sonic for my son so that he can drive around as he is a student driver. Purchased on July 27th and pickup on the 29th on 30th Morning driving the car on the highway the car stopped while in drive mode and luckily no accident. reached out to the dealer i towed the car to dealership. First they told me is ready nothing wrong and said there is a problem with the key they didn't program it i picked up the car on august 2nd and while driving 5 miles it was doing stalled on the Highway near Natick Mall the Natick police came and tried to move the car to safe spot. since 12 day the car is with them on 10 August they told me that they are taking to Chevy dealership on the 11th and received a call from Dealership on 14th that they will do diagnosis today and i just got of the phone with the service manager she they the body control module need to be replaced and they spoke with USA motor sport salesman [XXX] He denied to fix and said he will bring old Body Control module from used car and will do reprogram i called the owner who is the ruddiest person in the World he started abusing and using false Language i am going to reach out to Attorney General Office and complain. he is saying i cannot call him when the car is ready he will call i need to report this to higher Authorities THE CAR IS STALLED WHIILE DRIVING INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11538672

The contact owns a 2012 Chevrolet Sonic. The contact stated that vehicle failed to accelerate while depressing the accelerator pedal. The contact stated that the check engine and ABS warning lights were illuminated. The vehicle was not diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 114,000.

NHTSA ODI 11526661

I was driving my 2012 chevrolet sonic on April 26 and was rear ended my seatbelt did not engage and I was injured. I was rushed to the hospital for a concussion and on may 4th I got dizzy from my concussion from the accident suffered on April 26 and lost control of my vehicle and struck a concrete barrier on i20 west then bounced of the barrier and struck the barrier yet again. My seatbelt never engaged and my airbags never deployed either time striking the barrier nor the prior accident.

NHTSA ODI 11520856

On 4/1/2023 my engine light went on. I had my nephews look at it. see pictures below for engine read and how oil mixed with antifreeze. Also note service paperwork. Gaskets were not up to quality to keep the oil sealed in its compartment. Manager called and tried to take care of issue because he only uses genuine parts but was told there was an issue with this part and until there were more fatalities or more people complained noting could be done. He was NOT happy. They did the best they could resorting to youtube videos and imagination. When I got it back, it was like brand new. Two days later, my engine light came on again. You will find the new engine reading which again had the oil mix with the antifreeze and no oil left. The engine would blow/seize or worse if I kept driving it. I am on disability and live alone. I cannot afford the unpredictability of having something happen to me on the road or where I am suppose to the money. I complained before to a manager at a dealership when I had a problem with my motor when my car was still new. He told me it was supposed to be like that. I keep revving in the middle of traffic lights and people were on my backend when I would get out of work at 3:00 am. The car was recalled two months later to replace many individual motor parts. I am too old and anxious to play these games. Please seriously have look into this please. Thank you for your time.

NHTSA ODI 11517535

The contact owns a 2012 Chevrolet Sonic. The contact stated that after the vehicle was taken to an independent mechanic for routine oil change services, there was an abnormal oil odor inside the vehicle. The contact stated that while the vehicle was parked, smoke was coming from underneath the hood and after opening the hood, the contact became aware of a coolant leak. No warning lights were illuminated. The vehicle was towed to the residence. The vehicle had not yet been taken to an independent mechanic or a local dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and informed the contact that the warranty had expired. The failure mileage was unknown.

NHTSA ODI 11510846

01.24.2023 Purchased Chevy Sonic 2012 three weeks ago (12.27.22) w odometer at 33,688 and manuf. date of 03/2012. It has multiple recalls, inc transmission, that GM has reported resolved. I have had to schedule a transmission rebuild for $3,200.00 in February. After pressing on gas pedal, the vehicle hesitates as though it is going to stall, then lurches forward. On open road it will buck. When slowing down to stop or make turns, it bucks and lurches. The problems duplicate those stated in almost all of the complaints reported on this site. If GM has reported this vehicle as properly repaired, then I am stuck. Also, the questionable low mileage of a ten year old vehicle and dates of the recalls make me wonder about where and when or if all the recalls were truly resolved. There is one accident reported on this vehicle, Sept. 2022; was the accident caused by the same powertrain related problems?

NHTSA ODI 11503393

THE AUTOMATIC TRANSMISSION FAILED. IT FAILED WHILE I WAS DRIVING THE VEHICLE. YES, IT WAS CONFIRMED BY A DEALER. IT HAS BEEN INSPECTED BY THE CHEVY DEALER. NO, THERE WERE NOT ANY WARNING SIGNS PRIOR TO THE FAILURE.

NHTSA ODI 11500364

The contact owns a 2012 Chevrolet Sonic. The contact stated that while coming off the freeway at approximately 30-35 MPH, the vehicle began jerking. The engine revved up as if it intended to accelerate however, the vehicle would then jerk. The contact was able to coast to the destination driving approximately 5-10 mph. The check engine warning light illuminated with a trouble code regarding the engine. The contact who is a certified mechanic determined that the failure was related to Technical Service Bulletin NHTSA ID: 14V315000 (Power Train). The contact had the vehicle towed to a dealer where the vehicle was waiting to be repaired. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 87,410.

NHTSA ODI 11486952

My vehicle will not shift out of 1st or 2nd gear. This appears to be part of a recall I just found out about, however my vin # states its not part of the recall.

NHTSA ODI 11485135

A few months after this car was purchased, we received the notice regarding recall 14234 for our 2012 Chevy Sonic. However, when we brought it to the dealership, they stated that our vehicle didn't fall under the recall. I told them we were experiencing shaking while shifting and it seemed like the exact same issue. Now about 1 year later with less than 100,000 miles, the car will not shift properly into 3rd gear. The auto repair shop informed us that we need to get a new transmission among many other related repairs. We seem to have the exact same issue as reported in the recall; however, we continue to be informed that our vehicle does not fall under the umbrella of the recall. After doing a number of searches it seems that this is a common story. All these 2012 Chevy Sonics have the same issue yet do not fall under the recall.

NHTSA ODI 11484943

I was experiencing issues with the transmission on my vehicle. I lost control and when it stop abruptly in a ditch after hitting a fallen limb of a tree the airbags did not deploy. Since this incident I have extreme pain in neck, dizziness, and weakness in both my arms. My vehicle is not listed as part of the recalls and the violent stop of my vehicle upon hitting the object was severe enough to snap both tierod ends yet airbags did not deploy. I have significant injuries as a result and a wrecked car that I feel was hard to control due to the problematic acceleration of transmission

NHTSA ODI 11478078

The gear shift in the car started sticking about 3 years ago but it would still shift so I wasn't too concerned. Since then it's gotten gradually worse until tonight where it took me 5 minutes to put it into park. I couldn't released the key or get it out of reverse and it was terrifying. Mine and others safety was put at risk because my car not going into park means it can roll anywhere and cause an accident. I haven't taken it to a dealer to get checked and it hasn't been inspected by anyone else. There never have been any warnings from the car that there is an issue.

NHTSA ODI 11465860

I have a 2012 Chevy Sonic giving a P2138 error code. I have replaced the Throttle Position Sensor and the Accelerator Pedal Sensor and the problem is not going away. I have spent over $700 on this repair and they cannot fix it. It is a known problem with this vehicle but GM is there is no recall for this issue. I wish something could be done. The acceleration loses power and drops to is unable to go above 45 MPH.

NHTSA ODI 11462354

After original P0011 engine code dealer bought from replaced VVT actuators, oil control solenoid, VCG, timing belt, water pump, antifreeze, idler and tensioner on 10/27 -11/21. Vehicle ran for one week and all thru Dec 2021 intermittently kept running rough and stalling and throwing P0011 code Camsgaft Position Sensor intake and P0301 cylinder 1 misfire. Smelled burning oil too. Replaced all separate throughout month -Camshaft position sensor intake, changed oil, spark plugs and now the ignition coil. Each time ran one day and code P0011 kept coming back. Running rough, poor gas mileage and stalls. Have extended warranty going back to dealer bought from.

NHTSA ODI 11449052