What 639 owners told NHTSA about the 2011 Volkswagen Jetta Hev

Lights coming on by themselves while in park position and draining the battery. Replaced battery 3 times in the last 7 months.

NHTSA ODI 11496902

On February 2, 2017, My car was stop in an intersection. A car coming in my direction swerved into my lane and hit me head on. The air bag was deployed, it exploded so violently that both of my hands were severly injured. There was a fracture in my right wrist. There was a laceration to the base of the thumb and my thumb finger almost fell off and required several stiches for my forefinger to be attached. The bones in my right arm was shattered into pieces and it required major surgery. My left arm requires a total of 4 surgeries. I have to undergo an eighteen (18) months of Physical Therapy for both my left and right hand. There was so much pain in my left arm and the doctor had to perfom an operation called "Proximal row carpectomy (PRC)". Proximal row carpectomy (PRC) is a motion-preserving treatment for the degenerated wrist. Three (3) very important bones in Proximal row carpectomy (PRC)surgery was removed. This surgery is done to alleviate (reduced) the pain in my arm. I was still lucky, fortunate that the car hit me in front. If my car was hit from behind, my upper body especially my head will be thrown forward and the explosion of the air bag would explode in my face and the xplosion could have killed me or break my neck. The exlposion of the air bag was very similar to the beirut explosion that was caused by ammonium nitrate which was sometimes used in the defected airbag. Very explosive. The air bag was supposed to protect me but in this case it caused tremedous damage to my both my left and right arm. After more than 5 years both of my hands have not fully recovered. It still hurts lifting some heavy object which I could easily lifted before the accident. I trully believe that the airbag is my car has a problem and it could be a Takata air bag that also need to be recalled. My neighbor’s teenage daughter is also driving the same year and model of my car and it always worry me to think what if the air bag is defected.

NHTSA ODI 11495712

This engine or transmission is acting odd it boggs down for no reason and I know for a fact there should be a recall from the wiring harness back in 2011. I accidentally clicked it was fixed when I pushed the wrong button and it wouldnt let me undue it. Stalls white smoke out the tail pipes in gusts. Foul smell in vents

NHTSA ODI 11493328

Ignition switch. Having a hard time turning car off.

NHTSA ODI 11487725

Was driving about 25-30mph when we heard a pop sound and the car started to become very hard to control. Everytime I would press the brakes the car would become even harder to control. I tried to turn into a driveway to see what happened and the car jerked and caused us to go into a deep ditch. The front passenger tire hit a concrete water drain and the car stopped abruptly. Impact caused the rim to completely break in half and also snapped the front axel in half. The tow truck driver informed us that the drivers rear axle trailing arm was broke in half and he had never seen anything like that before. That night we learned of the recall for that exact part. Over the weekend I've had a chance to go out and look a little better under the rear of the car and it appears to have the steel inlay piece that was supposed to fix the recalled part. The welding is terrible and most of it is rusty so it's been broken for a while it seems. I pulled a car fax on the vehicle and it has went in several times for maintenance at various car dealerships but it doesn't seem that anyone put the fix in the system for it. It has definitely been repaired but nothing shows that. We are waiting on insurance to look at the car. It is available as of right now to be seen. No warning lamps were on in the car. This accident could have resulted in major injuries or even death if they wouldn't have hit the ditch. I have a ton of pictures if you need more. The police did come but didn't file a report because it was a 1 car accident.

NHTSA ODI 11487509

I took my son to a birthday party. We were both out of the car for 30-45 minutes when my son wanted to get something out of the backseat. When he opened the back passenger side door, black smoke came pouring out of the car. Upon further inspection, the driver's door was on fire. It appears to have started in the door panel wiring harness - where the window control buttons are.

NHTSA ODI 11487239

I have a clockspring issue in my 2011 Jetta, which was associated with the Volkswagen recall in 2015. I called VW of America and was told that my VIN was not one of the cars part of that recall, and they would not be able to assist me in fixing this issue. With this problem occurring and being associated with a recent recall, I feel as if Volkswagen should help me in fixing my vehicle as it is a safety issue.

NHTSA ODI 11486984

Going down the road - in town - at about 35 mph and I started to hear loud clanking while I felt as the rear of the car felt "stiff" all of a sudden. I parked the car as soon as I could to check it over. The rear passenger side coil spring just snapped as you'd break a pretzel... I have never seen a broken coil spring in any of the cars we owned over three decades. As I looked for information online, it seems that this MK6 generation of Volkswagen vehicles made in MEXICO were manufactured with springs that are PRONE TO FAILURE! Even the next generation MK7 especially vehicles manufactured between 2015-2019 had a RECALL for this exact failure - 42J5. - 56,000 vehicles including Golf hatchbacks, Golf SPORTWAGEN, Jetta sedans and Tiguan SUVS. How come VW didn't have a recall for the previous generation? Obviously this is manufacturing with below par parts.

NHTSA ODI 11478915

The contact owns a 2011 Volkswagen Jetta Sportwagen. The contact stated while driving approximately 55 MPH, the catalytic convertor warning light illuminated. The contact had taken the vehicle to a local dealer who diagnosed the vehicle and determined that the particle filter needed to be removed and reinstalled. The vehicle was repaired. The contact stated that the failure reoccurred and the vehicle was taken to a different dealer who determined that the particle filter needed to be checked and reinstalled. Additionally, the EGR cooler needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact had taken the vehicle back to the second dealer; however, the vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11477382

While changing lanes we heard a twang sound and felt an impact in the floor boards. The left rear of the car was unloaded from weight shift when the noise and impact was felt. When I was able to check the car over, I found the left rear spring was broken. The vehicle only has roughly 85k miles. I have heard many other stories of this happening to others as well.

NHTSA ODI 11475501

It's the transmission when the mph needle just Bob's constantly, when sometime up to 60 mph the rps stays above the three for at least 15 sec before sometimes going down others have to push the gas pedal fast to shift gears. Constant thud sound from the motor and more condensation then should be coming from tailpipe.the odor coming from the air vents is absolutely nauseating.

NHTSA ODI 11472267

At first we had to replace the intake manifold and then a month later we had to replace the catalytic converter and now it’s in the shop having the DLF filter , fuel pump , & fuel lines . All dealing with the diesel exhaust and fuel distribution. It’s leaking diesel fuel with strong odor of diesel to the point it makes you feel sick. The Volkswagen dealership never informed me of any recalls on my vehicle. The dealership is Flow Volkswagen Greensboro NC

NHTSA ODI 11468080

The car turns off while driving and it has put me in several safety problems that I feel could an accident

NHTSA ODI 11463834

The contact owns a 2011 Volkswagen Jetta. The contact stated while driving approximately 30 MPH, the steering wheel locked and the vehicle started jerking with the check engine warning light illuminated. The vehicle was taken to several independent mechanics; however, there was no failure detected. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V615000 (Electrical System, Steering). The manufacturer was not notified of the failure. The approximate failure mileage was 126,600.

NHTSA ODI 11463846

The ABS module in this vehicle has failed as the ABS, Traction Control, Airbag, and Brake lights are all on with the brake light flashing. The dealership stated a new module would be needed to have functioning anti lock brakes. In reference to case - NHTSA: 16V913, I believe the same components are the same as the power train did not change between the two vehicles. I am having the same symptoms as stated in this document but there is no recall as of yet.

NHTSA ODI 11460999

Unknown , The vehicle is a slap shift and I can't put it in sport mode as well when driving I've been in just regular automatic it will shift slow but hard when it's in slap shift it it shifts Hard and when it is in sport mode it will shift fast and hard it's like a jerk it has a very rough idol and sometimes the windshield wiper's will work sometimes they won't and my cruise control does not work and I put my code reader on it and it says $7E8 and $7E9 along with not being able to complete smog test, and it acted like it wanted to die when I was in drive through it has well over half tank gas. Also it seems to be sucking more gas and my miles are going really fait's going really fast like they're not matching what I'm actually driving.

NHTSA ODI 11449759

The contact owns a 2011 Volkswagen Jetta. The contact stated that while operating the vehicle, the ABS and traction control warning lights illuminated and remained illuminated. Additionally, the brake light had continued to flash. While driving approximately 35 MPH, the vehicle spun out after lightly depressing the brake pedal. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 85,000. Consumer would like to withdrawal the complaint.*JB

NHTSA ODI 11447893

The contact owns a 2011 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed but the brakes locked up causing the vehicle to spin 180 degrees. The vehicle was taken to an independent mechanic and diagnosed with Antilock Brake System (ABS) control module failure. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the VIN. The contact related the failure to NHTSA Campaign Number: 16V913000 (Service Brakes, Hydraulic, Electronic Stability Control) however, the VIN was not included in the recall. The failure mileage was approximately 88,000. Consumer would like to remove the complaint.

NHTSA ODI 11444005

Car horn stopped working followed by an airbag sensor light that won't turn off. Seems like the clock spring failed prematurely?

NHTSA ODI 11441172

Car randomly stalls while driving and shuts off without warning in the middle of the road. Immediately is able to turn back on without issues. Took to mechanic and they couldn't find any issues and said the car had zero error codes. This has happened multiple times while driving low speeds, usually when driving stop and go with street lights

NHTSA ODI 11441173

Extended warranty expired 6 months before the event. HOWEVEr, I read it as a recall (it was actually warranty) so I took it in BEFORE the warranty expired, there wasn’t a problem with it then so they could not fix it since again it was warranty and not recall. The problem being my horn stopped working. Took it to Volkswagen- they said it was clock spring. Clock spring could also short out my airbags along with other SAFETY issues. Not only am I at extreme risk so are others around me. Obviously it was a problem with others if they extended the warranty. A VW specialist dealing with recall and warranty told me the extension of warranty is different because a recall would mean there’s a safety issue. HOW IS A HORN AND AIR BAG NOT A SAFETY ISSUE?!?! unsure of the exact date I noticed however, it was after extension of warranty.

NHTSA ODI 11436335

The vehicle ignition systems skips and locks the steering wheel. The makes the vehicle stops and disabled.

NHTSA ODI 11436116

P 205/55R16 Front side tire has developed cracks/cuts along side wall. Bought tires recently from NTB-National Tire & Battery in Forest City, NC. I don't know how safe is to drive like this?

NHTSA ODI 11434410

The vehicle turns off by itself while driving.

NHTSA ODI 11424379

The spring in the back left suspension fell off/broke. We heard a loud clank on the highway and were able to slowly steer to a local mechanic. The back left of the car sunk over the wheel, he looked under and told us the issue. And in fact, the same thing happened when we first bought the car to the front left suspension and we were reimbursed by VW Van Nuys. VW Ventura replaced the front two suspension systems. VW Seaside currently has the car and will be replacing the back two suspension systems. We looked up the issue, and many other drivers with this make and model have had the suspension springs go out, a rare and dangerous issue. There were no warning messages prior to failure and if the spring had punctured the tire it could have caused an accident and risked lives.

NHTSA ODI 11423741