What 87 owners told NHTSA about the 2011 Mini Cooper Hardtop

I HAVE BEEN HAVING PROBLEMS WITH MY 2011 MINI COUNTRYMAN S ALL4 IN REGARDS TO CHECK ENGINE INDICATOR. I HAVE TAKEN MY CAR FOR SERVICE OF THE CHECK ENGINE INDICATOR 4 TIMES NOW. EACH TIME IT HAS BEEN CAUSED BY FUEL IN THE CHARCOAL FILTER SYSTEM. EACH TIME I HAVE BEEN TOLD IT IS FROM OVERFILLING THE FUEL TANK, WHICH I DO NOT DO. I AM CAREFUL TO STOP FUELING THE FIRST TIME THE PUMP KICKS OFF, ESPECIALLY AFTER THE FIRST TIME THIS HAPPENED. THE FIRST 2 TIMES THE DEALER CHANGED THE CHARCOAL FILTER AT NO COST. THE 3RD TIME THEY CHANGED THE FUEL TANK AT NO CHARGE. I HAD NO PROBLEMS FOR ABOUT A YEAR, AND THE CHECK ENGINE INDICATOR CAME ON AGAIN ON 12/18/13, I SCHEDULED SERVICE AS SOON AS POSSIBLE. TURNS OUT THAT FOR THE 4TH TIME FUEL WAS IN THE CHARCOAL FILTER. THE DEALER CAN'T SEEM TO FIND THE SOURCE OF THE PROBLEM AND THIS IS VERY ANNOYING TO SAY THE LEAST. WOULD LIKE TO TURN IN THE CAR NOW, LEASE ENDS IN 7 MONTHS, AND STAY AWAY FROM BMW AND MINI FROM NOW ON!! *TR

NHTSA ODI 10556980

THIS IS THE 2ND TIME THIS HAS HAPPENED. I FILED A COMPLAINT THE FIRST TIME IN 2012. HERE IS THE COMPLAINT THAN AND IT IS A REPEAT OF THE SAME PROBLEM. I HAVE CHECKED THE WEB AND OTHERS HAVE EXPERIENCED THIS SAME DESIGN PROBLEM I HAVE SPENT $1,100 ALREADY AND NOW AN REQUIRED TO PAY ANOTHER $1,400 FOR THE SAME PROBLEM. I WENT ON-LINE AND OTHERS HAVE HAD THIS PROBLEM. I WROTE THE DEALER AND MINI-COOPER/BMW ABOUT THIS AND RECEIVED A RUDE DENIAL. HERE IS THE ISSUE (#2): "TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT THE GEAR LINK BECAME STUCK AS THE CONTACT WAS ATTEMPTING TO REVERSE FROM A DRIVEWAY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED THAT COFFEE HAD LEAKED INTO THE GEAR SHIFTER AND CAUSED THE FAILURE. THE DEALER STATED ADVISED THAT BECAUSE THE CUP HOLDER WAS ABOVE THE GEAR SHIFTER, THE DESIGN WOULD ALLOW ANY SPILLED LIQUID TO EASILY ENTER THE SHIFTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 5,000. UPDATED 03/23/12*LJ THE CONSUMER STATED THE COFFEE HOLDER SITS RIGHT OVER THE AREA WHERE THE DEALER SATED COFFEE RUINED THE TRANSMISSION COMPONENT. IT IS NOT SEALED AND THE PLACEMENT OF A LIQUID HOLDER OVER A VULNERABLE EXPENSIVE PIECE OF ELECTRICAL EQUIPMENT WITHOUT ADEQUATE PROTECTION IS A NEGLIGENT DESIGN. UPDATED EVOQ 04/18/12" [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI 10532865

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT WHILE ATTEMPTING TO REVERSE FROM A RESIDENTIAL GARAGE, BLACK SMOKE EMITTED FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO PUT THE FIRE OUT UNDER THE HOOD WITH A GARDEN HOSE. THE FIRE DEPARTMENT WAS NOT CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 3,000.

NHTSA ODI 10457204

I TOOK THE CAR TO THE DEALER ON 12/15/11 BECAUSE THE PASSANGER AIRBAG OFF LIGHT TURNED ON WHEN A PASSANGER WAS SEATED. THE LIGHT TURNED ON AGAIN JAN 7, 2012. HERE ARE THE DEALER'S NOTES FROM THE 12/15/11 VISIT: SEAT MAT SENSOR OC3 RECODING CHECK FAULT MEMORY NO RELEATING FAULT STORED. COMPLETED TEST PLAN B6577 ACM4. CHECK CONNECTOR TO SENSOR OK. TEST PLAN CONCUDED TO RECODE OC3. UPDATED VEHICLE. D6577 0000 57 310. RETEST OK. AT THE SAME TIME THE CAR ALSO ALERTED TO A TIRE INFLATION ISSUE. HERE ARE THE DEALER'S NOTES REGARDING THIS ISSUE (ALSO 12/15/11): PSI: TIRE INFLATION CHECK SET TIRES TO 33PSI *TT

NHTSA ODI 10444480

TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT THE GEAR LINK BECAME STUCK AS THE CONTACT WAS ATTEMPTING TO REVERSE FROM A DRIVEWAY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED THAT COFFEE HAD LEAKED INTO THE GEAR SHIFTER AND CAUSED THE FAILURE. THE DEALER STATED ADVISED THAT BECAUSE THE CUP HOLDER WAS ABOVE THE GEAR SHIFTER, THE DESIGN WOULD ALLOW ANY SPILLED LIQUID TO EASILY ENTER THE SHIFTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND THE CURRENT MILEAGE WAS 5,000. UPDATED 03/23/12*LJ THE CONSUMER STATED THE COFFEE HOLDER SITS RIGHT OVER THE AREA WHERE THE DEALER SATED COFFEE RUINED THE TRANSMISSION COMPONENT. IT IS NOT SEALED AND THE PLACEMENT OF A LIQUID HOLDER OVER A VULNERABLE EXPENSIVE PIECE OF ELECTRICAL EQUIPMENT WITHOUT ADEQUATE PROTECTION IS A NEGLIGENT DESIGN. UPDATED EVOQ 04/18/12

NHTSA ODI 10444433

OUR COUNTRYMAN UNEXPECTEDLY RAN OUT OF GAS WHEN THE DIGITAL FUEL LEVEL DISPLAY STILL HAD TWO BARS ILLUMINATED AND THE ON BOARD COMPUTER INDICATED THERE WERE 57 MILES LEFT. WITHOUT WARNING THE ENGINE QUIT RUNNING, WHICH IS A POTENTIAL SAFETY RISK. THERE ARE MULTIPLE OCCURRENCES OF THIS ISSUE REPORTED HERE: HTTP://WWW.NORTHAMERICANMOTORING.COM/FORUMS/R60-COUNTRYMAN-TALK/215262-RAN-OUT-OF-GAS.HTML THE DIGITAL FUEL LEVEL GRAPH IS OFTEN REFERRED TO AS CANDY CORNS SINCE ON THIS VEHICLE EACH SEGMENT LOOKS SIMILAR TO A CANDY CORN. *TR

NHTSA ODI 10426560

TL* THE CONTACT OWNS A 2011 MINI COOPER. WHILE DRIVING APPROXIMATELY 30 MPH, THE TRANSMISSION FAILED TO RESPOND. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT SHIFTED THE GEAR SELECTOR INTO PARK HOWEVER, THE GEAR WOULD NOT REMAIN SECURE AND THE EMERGENCY BRAKE WAS ENGAGED TO PREVENT THE VEHICLE FROM ROLLING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR REPAIRS. IN ADDITION, THE OIL PUMP GASKET AND MAP THERMOSTAT WERE REPLACED PRIOR TO THE TRANSMISSION FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 2,504. UPDATED 10/12/11*LJ UPDATED 3/30/12 *CN

NHTSA ODI 10424148

2011 MINI COOPER. CONSUMER STATES VEHICLE BROKE DOWN WHILE TRAVELING *TGW THE CONSUMER STATED THE ENGINE FAILED WHICH CAUSED OIL TO LEAK UNDER THE HOOD. BMW REFUSED ANY ASSISTANCE ON THE GROUNDS THE VEHICLE HAD AN OVER REV-MISSED SHIFT THAT WAS AN AFTER MARKET PART THE CONSUMER HAD INSTALLED. AN INSPECTION SHOWED A BORE SCOPE WAS USED TO VERIFY THAT THERE WAS DAMAGE TO THE CROWN OF ONE PISTON INDICATING THAT DURING THE OVER REV, A VALVE HAD COME IN CONTACT WITH THE PISTON. *JB

NHTSA ODI 10423458

THE NEW MINI COOPER THAT I LEASED STARTED TO HAVE ACCELERATION PROBLEMS AROUND 6500 MILES. WHAT HAPPENS IS A HESITATION IN THE ACCELERATION OF THE MINI FROM A START OR AT LOW RPMS. FOR EXAMPLE WHEN YOU'RE AT A STOP AND YOU ARE TRYING TO CROSS TRAFFIC THE HESITATION OF THE ACCELERATION IS DANGEROUS IN TIMING THE VEHICLE TO CROSS TRAFFIC AND WHEN THE ACCELERATION CATCHES UP THE CAR JUMPS TO HIGH RPMS. THIS IS BEING REPORTED BECAUSE I TOOK THE COOPER INTO THE MINI OF ONTARIO SERVICE CENTER AND THEY SAID THERE IS NOTHING WRONG.

NHTSA ODI 10420348

TL* THE CONTACT OWNS A BMW 2011 MINI COOPER. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE EXHIBITED A LOUD CLUNKING NOISE WITH THE ILLUMINATION OF ALL OF THE WARNING LIGHTS. THE VEHICLE BEGIN SMOKING AS HE PULLED TO THE SIDE OF THE ROAD. THE CONTACT WAS ABLE TO EXIT THE VEHICLE JUST AS IT IGNITED INTO FLAMES, FOLLOWED BY AN EXPLOSION. THE POLICE WERE CALLED AND A REPORT WAS FILED. THERE WERE NO INJURIES FROM THE EXPLOSION. THE VEHICLE WAS THEN TOWED BY THE STATE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY WOULD GET BACK TO HIM AT A LATER DATE. THE FAILURE MILEAGE WAS APPROXIMATELY 120.

NHTSA ODI 10410757

WHEN ACCELERATING, THERE APPEARS TO BE A 1-1.5 SECOND DELAY FROM COMPLETE STOP POSITION TO START WHEN DEPRESSING THE ACCELERATOR. THIS DELAYED ACCELERATION IS PROBLEMATIC ONLY FROM COMPLETE STOPPING POSITION. EXAMPLE, AT PERPENDICULAR INTERSECTION WAITING TO TURN LEFT (PULLING OUT OF A GAS STATION OR MERGING INTO TRAFFIC, THE VEHICLE REQUIRES A ROLLING OR MOVING START BEFORE THE VEHICLE WILL ACTUALLY ACCELERATE OR AT A SAFE ENOUGH SPEED TO PULL OUT INTO TRAFFIC. WHEN I AM AT A COMPLETE STOP AND TRY TO ACCELERATE BY PRESSING THE ACCELERATOR FIRMLY FROM ANY COMPLETE STOP POSITION IN A SAFE ENOUGH SPEED TO CROSS TRAFFIC WHEN TURNING, THERE IS ALWAYS A DELAYED REACTION FROM THE TIME I DEPRESS THE PEDAL AND THE TIME THE VEHICLE TAKES OFF. THIS DOES NOT TO APPEAR AS A PROBLEM THAT HAPPENS ONLY ONCE IN A WHILE, BUT APPEARS ALL THE TIME AND TO BE A MANUFACTURER ISSUES WITH THE ELECTRONIC TRANSMISSION AND GEAR CONTROL. I CONTACTED THE DEALER AND WAS TOLD THAT I SHOULD ACTIVATE THE SPORT BUTTON AND DE-ACTIVATE THE DCS CONTROL WHICH CONTROLS THE "SPIN-OUT" ACTION ON THE COUNTRYMAN. I HAVE TRIED THOSE RECOMMENDATIONS AND THE PROBLEM STILL EXIST. THIS IS NOT ONLY THE PROBLEM. THERE IS ALSO AN ISSUE WHEN I AM SIMPLY IN THE DRIVEWAY. WHEN STARTING THE CAR AND PUTTING THE VEHICLE IN REVERSE, THERE IS ALSO THAT "DELAYED" REACTION AFTER THE CAR IS ALREADY IN GEAR, ALMOST LIKE THE VEHICLE HAS TO THINK ABOUT MOVING BEFORE IT ACTUALLY DOES. THIS OCCURS EACH AND EVERY TIME WHILE IN THE VEHICLE. MY VEHICLE IS AN AUTOMATIC. I HAVE EXPERIENCE WITH BOTH AUTOMATIC AND MANUAL TRANSMISSIONS AND HAVE OVER 25 YEARS OF EXPERIENCE AND HAVE PURCHASED OVER 15 CARS IN MY DRIVING CAREER AND THIS IS THE FIRST TIME THAT I HAVE EVERY EXPERIENCED THIS TYPE DRIVING EXPERIENCE WITH AN AUTOMATIC.

NHTSA ODI 10411228

OCCASIONALLY AND INTERMITTENTLY, THE DIGITAL AUDIO DISPLAY IN THE MIDDLE OF MY MINI'S LARGE SPEEDOMETER WINDOW GOES BLANK, WHILE ALLOWING YOU TO CHANGE CHANNELS AND CHOOSE FUNCTIONS (IPOD, TELEPHONE, RADIO, SATELLITE) WITHOUT BEING ABLE TO SEE WHAT YOU'RE CHOOSING. THE GAS MILEAGE DIGITAL DISPLAY ABOVE THE AUDIO SYSTEM IS READABLE AT ALL TIMES. OCCASIONALLY ALSO AN ORANGE LINE WILL GO THROUGH THE DIGITAL AUDIO DISPLAY HINDERING THE ABILITY TO READ IT COMPLETELY. I BROUGHT THE CAR BACK TO THE DEALER WITHIN 2 WEEKS OF PURCHASING IT NEW TO ADDRESS THE PROBLEM, BUT NOTHING WAS FOUND AND THE CAR WAS RETURNED WITHOUT A REPAIR AFTER 2 DAYS AT THE SHOP. I HAVE SUBSEQUENTLY EXPERIENCED THE SAME PROBLEM AND HAVE TAKEN PICTURES OF THE DISPLAY EACH TIME. *TR

NHTSA ODI 10398373