Jun 25, 2024AirbagsCrash
The passenger seat occupancy sensor has malfunctioned, causing the vehicle to believe that there is an infant car seat in the front passenger seat. This puts front passengers at risk because the air bags will not deploy in the event of a crash. While having body work done at Swartz's Ultimate Collison repair in Lewisburg, it was noted by the technician, however Mini does not cover repair by a non dealer or accept accounting of the defect from a non dealer. I was unaware that the vehicle was nearing the end of it's warranty and waited too long to inquire again. They will not fix it.
NHTSA ODI 11596422
Oct 23, 2023Electrical system1 injury
Footwell Control Module - (FRM) was dead after battery dead. It had a safety recall repot 23V-337 on the same model and year of my vehicle BUT mine is not on the list? A extended warranty was found till 2021 and mine had problem since 2014, and I paid dealership for inspection for at least 6 times, and it was still not got replaced till it was dead completely currently.
NHTSA ODI 11551454
Nov 13, 2018Electrical systemEngineFuel systemFire
TL* THE CONTACT OWNS A 2011 MINI COOPER. WHILE DRIVING, A BURNING ODOR ENTERED THE VEHICLE THROUGH THE AIR VENTS AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE LIGHT SENSOR AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO RAY CATENA MINI OF WESTCHESTER (LOCATED AT 543 TARRYTOWN RD, WHITE PLAINS, NY 10607, (914) 347-6464) WHERE IT WAS DIAGNOSED THAT THE INTAKE BOOT AND ALL THE CONNECTORS FOR THE TURBO HOSES MELTED. IN ADDITION, A LEAK WAS FOUND IN THE OIL HOSE. THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR FEES. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 18V248000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND PROVIDED CASE NUMBER: 11105312. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
NHTSA ODI 11151193
Mar 16, 2016Fire
DROVE CAR ABOUT 4 MILES. PARKED AT SHOPPING CENTER, TURNED OFF CAR AND LOCKED IT. RETURNED 15 MINS LATER TO FIND FLAMES IN ENGINE COMPARTMENT!
NHTSA ODI 10850122
Mar 2, 2016Engine & cooling1 injury
LETTER FROM SENATOR FLAKE ON BEHALF OF CONSTITUENT RE 2011 MINI COOPER. (PLEASE RESPOND BY FAX OR ELECTRONIC MAIL: BOB_BRUBAKER@FLAKE.SENATE.GOV). *SMD THE CONSUMER RECEIVED EXTREMELY, PAINFUL , SCARING BURNS FROM THE HOT EXHAUST PIPE WHILE LEANING OVER TO RETRIEVE ITEMS FROM THE TRUNK. THE CONSUMER STATED IF ONE IS FACING THE CENTER TRUNK, THE HOT EXHAUST PIPE IS LOCATED DIRECTLY TO THE RIGHT, APPROXIMATELY 10 INCHES OFF THE GROUND. THE METAL IS NOT COATED TO OFFER PROTECTION. *JB UPDATED 03/07/16.*JB UPDATED 04/11/16.*JB
NHTSA ODI 10839479
May 2, 2012Engine & coolingFire
TL* THE CONTACT OWNS A 2011 MINI COOPER. THE CONTACT STATED THAT WHILE ATTEMPTING TO REVERSE FROM A RESIDENTIAL GARAGE, BLACK SMOKE EMITTED FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO PUT THE FIRE OUT UNDER THE HOOD WITH A GARDEN HOSE. THE FIRE DEPARTMENT WAS NOT CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 3,000.
NHTSA ODI 10457204
Jul 6, 2011Engine & coolingFire
TL* THE CONTACT OWNS A BMW 2011 MINI COOPER. THE CONTACT WAS DRIVING 50 MPH WHEN THE VEHICLE EXHIBITED A LOUD CLUNKING NOISE WITH THE ILLUMINATION OF ALL OF THE WARNING LIGHTS. THE VEHICLE BEGIN SMOKING AS HE PULLED TO THE SIDE OF THE ROAD. THE CONTACT WAS ABLE TO EXIT THE VEHICLE JUST AS IT IGNITED INTO FLAMES, FOLLOWED BY AN EXPLOSION. THE POLICE WERE CALLED AND A REPORT WAS FILED. THERE WERE NO INJURIES FROM THE EXPLOSION. THE VEHICLE WAS THEN TOWED BY THE STATE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY WOULD GET BACK TO HIM AT A LATER DATE. THE FAILURE MILEAGE WAS APPROXIMATELY 120.
NHTSA ODI 10410757