What 170 owners told NHTSA about the 2011 Mazda CX-9

The front driver-side lower ball joint suffered a catastrophic structural failure and sheared completely apart while moving. This vehicle was previously serviced under Safety Recall Campaign 15V451000 / Mazda Recall 8515G for this exact defect. The recall remedy part failed a second time, collapsing the front wheel assembly, ripping the CV axle completely out of the transmission casing, causing a hazardous transmission fluid spill, and leaving the vehicle stranded and immobilized in the middle of a live roadway in the dark

NHTSA ODI 11747329

The contact owns a 2011 Mazda CX-9. The contact stated that while attempting to park the vehicle at a slow speed in the driveway, the vehicle suddenly experienced unintended acceleration, lurched forward, and crashed into a tree before coming to a stop. The contact was unable to stop the vehicle during the sudden unintended acceleration. During the failure the vehicle sustained front end damages, but no air bags had deployed. No injuries were reported. The cause of the failure was not yet determined. The contact stated that twice in the day before the unintended acceleration, the vehicle jerked forward in traffic however, the contact attributed the issue to the brake pedal not being firmly depressed or the clutch not properly engaged while shifting gear. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was 173,000.

NHTSA ODI 11677734

While driving the side airbags exploded and I had to stop in the middle of the street, get vehicle towed to mazda dealer in Alpharetta, GA Now, im without a vehicle. What do I do now?

NHTSA ODI 11673826

The contact owns a 2011 Mazda CX-9. The contact stated that while driving at an undisclosed speed and making a turn, the contact lost control of the vehicle, and the front driver's side suspension lowered to the ground. The vehicle was towed to an independent mechanic, who determined that the subframe was severely rusted, causing the control arm to detach. The contact was informed that the subframe needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.

NHTSA ODI 11658375

I had an issue with the AWD not engaging and the 4x4 light illuminating when driving on snow and ice. No indicators when driving under normal conditions. I had no traction and had difficulty maintaining control of the vehicle while driving at speeds less than 25 mph. I had difficulty gettting momentum from a stop as the tires were spinning and engaging tracion. I took the car into a Mazda dealership for a full circle inspection and found that the 4x4 light was illuminating due to worn-out splines connecting the transfer case. The technician was able to spin the driveshaft, indicating the splines are damaged and need to be replaced. Recommendations were to replace the transmission and transfer case with a repair estimate of $5469.61. Additionally, the technician observed some seeping of oil coming from the tiing cover and reccommends re-sealing it as well as replacing the water pump ( another known failure issue in which Mazda is aware of). Cost estimate of $4319.78. The technician also observed a crack in the right rear differential mount with a repair cost of $442.10. In short, Mazda knew about all these problems. They issued a warrenty extention from my research back in 2014 but never issued any recalls. In short, I didn't own this vehicle in 2014, I purchased in 2016. I was never aware of any warrenty extentions to include these issues and if I was aware, I would have had the services done for repairs. My safety as well as my family's and others are at risk if I lose control of the vehicle due to the AWD not engaging when needed.

NHTSA ODI 11631793

Brake booster failure. The power assisted braking has stopped working. There are no leaking vacuum hoses and the check valve is working. The brake pedal travels to the floorboard.

NHTSA ODI 11620856

Driving kids to school a few months ago. Car started to smell like burning rubber. I thought it was the garbage truck ahead of us. As we turned the corner 2 blocks later, the car dead stopped and we all went flying forward. It jerked so hard, we are lucky our necks didn't snap. I put the car in park and turned it off. I waited a few minutes as I was too worked up, and started the car again. We got about 50ft before a very loud noise began, almost as if something was dragging underneath. I stopped, and had it towed home. I then had it towed to mechanic. They said bad TRANSFER CASE & DRIVE SHAFT. - TRANS PAN GASKET. I am a single mom with no money to afford to have it fixed in fear of it going bad again. They quoted me 3,500 here in PA.

NHTSA ODI 11546714

The contact owns a 2011 Mazda CX-9. The contact stated while driving 20 MPH, there was an abnormal sound coming from the brakes. The contact stated that the brake pedal was firm and difficult to depress while attempting to stop the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 67,000.

NHTSA ODI 11506010

Braking trouble recent in weeks in 2011 Mazda CX-9 vehicle. Had mechanic (Euro Motorsports in Chagrin Falls OH) check it out. Turned out to be a faulty Brake Booster. Mechanic test drove car; braking failed and he almost rear-ended another vehicle. He found on line a Mazda service notice dating from April 4, 2014 called SSP93. Mazda issued an extended warranty of 7 years or 90,000 miles, whichever came first, to have defective part replaced by an improved part. But we were never informed by Mazda of Bedford, where we bought the vehicle. Currently, our vehicle has about 83,000 miles. Never knew there was a problem until recent trouble with the braking. There are thousands of CX-5, Cx-7, and Cx-9 vehicles in operation in U.S. right now; probably many owners have no idea there is a brake defect in their vehicles that could cause a serious accident, potentially fatal. Mazda should have done a recall in 2014, not an extended warranty. Although Brake Boosters are supposedly good for at least 150,000 miles of driving, our brake failure at around 83,000 miles proves otherwise. NHTSA should order Mazda to recall all vehicles with the defective brake part and replace them at Mazda's expense, probably hundreds of dollars each time. We do not want to have our brake booster replaced by our regular Euro Motosports mechanics because a recall must typically be repaired by the dealer. We already filed a complaint with State of Ohio Attorney General's office, but their people say the complaint must first go through BBB. No urgency on their part at all, even when informed potentially fatal flaw in the brakes. To avoid dangerous accidents, NHTSA should act more swiftly. Thanks.

NHTSA ODI 11487622

The front door windows no longer work. Most recently, the drivers side back door will NOT open. The lock is completely jammed - will not open or shut, which is a safety hazard for my child. The plastic parts in this car are failing and putting my family at risk.

NHTSA ODI 11480657

Defective water pump located inside the engine that when failure occurs can cause coolant to leak into engine causing complete engine failure. This is a major safety hazard due to the fact that these cars with defective water pumps can break down with very little warning in the middle of a freeway! I have contacted Mazda who refuses to do anything due to it being outside warranty but will not acknowledge the safety concern sudden engine failure can cause on a perfectly maintained car. In California there is currently a lawsuit against Mazda for this issue and hundreds of other Ford and Mazda owners who have been caught in very dangerous situations due to this water pump failure issue. The situation we were involved in could have gone very differently and that was my family in the vehicle that Mazda seems to care about a couple thousand dollars more then the value of life... is just ridiculous! Please do the research yourself so no one has to loose their life over this.

NHTSA ODI 11440057

When getting off highway engine began to knock. Engine stalled and would not restart. Upon inspection the water pump was found to have failed and leaked engine coolant into oil. This caused engine to have a complete failure. No check engine light illuminated but when car was scanned multiple codes were found. The car was also found to have a bad Transfer Case.

NHTSA ODI 11432665

The contact owns a 2011 Mazda CX-9. The contact stated while driving 60 mph, upon approaching oncoming traffic, the vehicle unexpectedly shut-off. The contact was able to restart the vehicle and pulled the vehicle off to the shoulder. The contact stated that upon restarting the vehicle, the check engine warning light illuminated. Due to the failure and the warning light, the contact had the vehicle towed to an independent mechanic. Upon inspection of the vehicle, the mechanic informed her that coolant had leaked into the oil cylinder and they referred her to a dealer for assistance. The contact then had the vehicle towed to the dealer where they diagnosed the vehicle with a defective water pump as well as engine failure. The manufacturer was also notified of the failure and stated that the failure was caused due to poor maintenance. No further assistance was provided. The vehicle had yet to be repaired and remained in the possession of the dealer. The failure mileage was approximately 144,000.

NHTSA ODI 11428032

SIRT: I PURCHASED MY 2011 MAZDA CX 9 FROM MY CLOSE FRIEND [XXX] ON DEC.05 OF 2014! [XXX] HAD NOT BEEN ISSUED A SPECIAL SERVICES PROGRAM ABOUT THE BRAKE BOOSTER! WELL I NEVER RECEIVED THIS INFO EITHER? IN FACT I HAD TWO RECALL THAT WERE TAKEN CARE OF BY THE LOCAL MAZDA DEALER HERE IN THOUSAND OAKS CALIF. THIS KNOWN BRAKE BOOSTER DETONATION HAS BEEN KNOWN BY MAZDA.IOT IS A VERY DANGEROUS CONDITION AND IS NOT TO SAFE TO DRIVE THE CAR AT ALL- I WILL NOT DRIVE THE CAR AND SEETHE ORIGINAL MATTER SHOULD HAVE BEEN LET IT BE KNOWN TO MYSELF AND FEEL THE MATTER SHOULD BE ADDRESSED ASAP BY MAZDA -THANK YOU [XXX] ADDING BACKING -VERY HARD BRAKE - WHEN DRIVING IT HAD TO REALLY STAND HARD ON THE BRAKE TO STOP CAR B! ALL INDICATIONS POINT TO A BRAKE BOOSTER FAILURE ! TO SUMMARIZE IO WAS NEVER NOTIFIED BY MAZDA ABOUT THE SPECIAL SERVICE PROGRAM FOR THE REPAIR OF THIS EXTREMELY UNSAFE BRAKE PROBLEM! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11406762

WATER PUMP LEAKING IN ENGINE MIXING WITH OIL

NHTSA ODI 11405170

I PURCHASED A VEHICLE FROM A BUY HERE PAY HERE AND LATER REALIZED AFTER TWO WEEKS OF HAVING THE CAR THAT HAS A RECALL FOR THE AIRBAG ON THE PASSENGER SIDE...BUT THE CAR WAS SOLD AS IS FROM AUTO SALES IN BUFORD GA

NHTSA ODI 11396246

WHILE DRIVING THE CAR ON A COUNTY ROAD, WITH THE SPEED UNDER 40 MPH, AND FOLLOWING THE BEND IN THE ROAD TO LEAD TO GETTING ON THE HIGHWAY, THE CAR JERKED FORWARD AS IF I HIT SOMETHING. AS I CONTINUED TO DRIVE, THE CAR WAS MAKING LOUD CLINKING SOUNDS AND WAS JERKING IN MOTION. NO WARNING LIGHTS WENT ON. WHILE ATTEMPTING TO CONTINUE TO DRIVE, CLANGING NOISES COULD BE HEARD AND THE CAR CONTINUED TO JERK FORWARD. THE CAR WAS UNABLE TO BE DRIVEN. AFTER HAVING IT TOWED TO MY MECHANIC, IT WAS DETERMINE THE PROBLEM WAS THE TRANSFER CASE. THE SPLINES BETWEEN THE TRANSMISSION AND TRANSFER CASE HAD BEEN EATEN AWAY BY RUST. THE SEAL HAD NOT KEPT WATER OUT AS IT WAS DESIGNED TO DO. A NEW TRANSFER CASE WAS ORDERED AS WELL AS A NEW TRANSMISSION. THE REPLACEMENT TRANSFER CASE HAD SHOWN SIGNS OF THE SAME ISSUES WITH THE SPLINES. ANOTHER (2ND ONE) TRANSFER CASE HAD TO BE ORDERED. I HAD PURCHASED THIS CAR IN FEBRUARY 2019 USED. THE CAR HAD A CLEAN TITLE, NO ACCIDENTS AND WAS SERVICED REGULARLY. WITHIN 1 YEAR, I HAD TO PAY OUT $5,000.00 TO REPLACE TRANSFER CASE AND TRANSMISSION. I LOST THE USE OF MY CAR FOR OVER 3 WEEKS (DUE TO THE PROBLEMS WITH GETTING A TRANSFER CASE THAT WAS GOOD). WHEN YOU GOOGLE THIS ISSUE, MANY PEOPLE HAVE HAD SIMILAR ISSUES.

NHTSA ODI 11385491

WHILE DRIVING STRAIGHT ON A HIGHWAY THE WATER PUMP BEARING FAILED CAUSING COOLANT TO LEAK AND MIX WITH THE ENGINE OIL. THE CAR IMMEDIATELY STARTED TO MAKE A RATTLE NOISE AND SMOKE OR STEAM CAME FROM UNDER THE HOOD. THE UNDERSIDE OF THE CAR WAS COVERED WITH COOLANT AND WHAT APPEARED TO BE OIL. THE CAR WAS NOT DRIVABLE AND HAD TO BE TOWED TO A MECHANIC. ONCE AT THE MECHANIC THE TOOK THE ENGINE OUT TO GET TO THE WATER PUMP, ONCE EVERYTHING WAS PUT BACK TOGETHER IT WAS FOUND THAT THE FAILURE ALSO CAUSED DAMAGE TO THE VVT ACTUATER AND ALTERNATOR. THE ENGINE IS COMPLETELY SHOT.

NHTSA ODI 11374566

THE BRAKE PEDAL SEEMS HARD TOO STOP THE CAR WHEN IN MOTION ON PUBLIC STREETS, VEHICLE CONTINUES TOO ROLL UPON PUMPING BRAKES, HAVE TOO CONTINUOUSLY PUMP THE BRAKE HARD TOO STOP THE VEHICLE, HAD THE FRONT BRAKES REPLACED RECENTLY, AND BRAKE PEDAL IS STILL NOT FUNCTIONING CORRECTLY, POSSIBLY THE BRAKE BOOSTER.

NHTSA ODI 11351938

I CAME OUTSIDE TO MY CAR ONE MORNING AND STARTED THE VEHICLE.. I NOTICED THE AIRBAG LIGHT WAS BLINKING, AND IT NEVER WAS BEFORE.. SO I SHUT THE VEHICLE OFF TO VISUALLY INSPECT IT.. WHAT I FOUND WAS THE PASSENGER CURTAIN AIRBAG HAD MALFUNCTIONED.. IT DIDN'T DEPLOY FULLY, BUT IT PUCKERED MY HEADLINER SO NOW IT'S JUST HANGING ON THE PASSENGER SIDE.. I INFORMED MAZDA OF THIS AND I WAS TOLD IT'S ONLY A RECALL ON PASSENGER AIRBAG SENSOR, BUT NO RECALLS FOR CURTAIN AIRBAGS.. WHAT CAN I DO

NHTSA ODI 11339490

I WENT FROM HAVING BRAKES TO HAVING TO PUSH THE BRAKE TO THE FLOOR, WHICH STILL DID NOT STOP THE CAR, ALL IN THE SAME DAY. I WAS LUCKY NOT TO WRECK BUT COULD NOT STOP FOR STOP SIGNS OR STOP LIGHTS ALL WHILE MY 22 MONTH OLD WAS IN THE VEHICLE. SOMETHING IN THE BRAKE SYSTEM MESSED UP, AND IT STILL HAD A FULL THING OF BRAKE FLUID. I BELIEVE THAT IT IS THE BRAKE BOOSTER CAUSING THIS PROBLEM. *TR

NHTSA ODI 11327780

SUDDENLY STARTS TO ACCELERATE WHILE AT A STOP LIGHT, STOP SIGN OR I AM LETTING A PERSON OUT AND STILL IN DRIVE AND MY FOOT IS ON THE BREAK. IT HAS DONE IT 4 TIME SINCE I GOT HER BOUGHT 02/03/2020 THE LAST WAS 06/06/2020. I HAVE TO PRESS DOWN ON THE BREAK VERY HARD TO KEEP IT FROM GOING FORWARD LASTS ONLY A SECOND OR TWO. *TR

NHTSA ODI 11327549

BRAKES WHEN APPLIED WOULD SOMETIMES GO TO THE FLOOR BEFORE STOPPING. THE BRAKE BOOSTER HAS GONE BAD AND VERY DANGEROUS ALMOST CAUSING AN ACCIDENT. BRAKE PEDAL SOFT AND SOMETIMES WILL NOT STOP.

NHTSA ODI 11311569

TL* THE CONTACT OWNS A 2011 MAZDA CX-9. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, BOTH FRONT AND REAR SIDE DRIVER AND PASSENGER SIDE CURTAIN AIRBAGS DEPLOYED INADVERTENTLY. DURING THE INCIDENT NO COLLISION HAD OCCURRED AND VEHICLE WAS NOT DRIVEN OVER A BUMP. THE DRIVER SUSTAINED NECK AND LEFT SHOULDER INJURIES AND SUFFERED HEADACHES SINCE THE INCIDENT. MEDICAL TREATMENT WAS REQUIRED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER BROWN MAZDA OF CHANTILLY (4155 AUTO PARK SERVICE CHANTILLY, VA). THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

NHTSA ODI 11310044

BRAKES REALLY HARD TO PRESS. WIFE THOUGHT CAR WASN'T GOING TO STOP AND SHE WAS GOING TO REAR END CAR IN FRONT OF HER. SOMETIMES BRAKE PEDAL WOULD FEEL SPONGY. OVER LAST MONTH THERE WAS AN INTERMITTENT STRANGE NOISE SOMETIMES WHEN CAR WAS STARTED. MAZDA DEALERSHIP IDENTIFIED THE PROBLEM TO BE A DEFECTIVE BRAKE BOOSTER. I FOUND THAT NHTSA OPENED INVESTIGATION ON CX-9 BRAKE ISSUES PREVIOUSLY AND MAZDA IDENTIFIED PROBLEM TO BE BRAKE BOOSTER. MAZDA EXTENDED THE WARRANTY TO 7 YEARS OR 90,000 MILES AND NHTSA CLOSED INVESTIGATION. OUR BRAKE BOOSTER FAILED AT 9 YEARS WITH 79,388 MILES ON THE CAR. FROM WHAT I HAVE READ THE LIFE EXPECTANCY OF A BRAKE BOOSTER IS THE LIFE OF THE CAR. MAZDA NEVER INFORMED US ABOUT THIS POSSIBLE PROBLEM. OUR FAMILY COULD HAVE BEEN SERIOUSLY INJURED OR KILLED DUE TO THIS DEFECT. WHY DID THE NHTSA ACCEPT AN EXTENDED WARRANTY AS A SOLUTION?

NHTSA ODI 11297398