What 976 owners told NHTSA about the 2011 Chevrolet Malibu Eco

When I cranked my car, the power steering immediately went out. I had no previous issues and the car uses an electrical power steering component that does not allow me to add fluid.

NHTSA ODI 11480291

My 2011 malibu has approx 170000 miles. was driving on the highway when one by one, low fuel range, tire pressure, and antitheft lights illuminated blinking in dash. The radio flickers like loosing power, the car jerks pulling hard to right side and the power steering goes out and the car literally shuts down in drive on the highway not even giving me time to get off road. Pushed car to side of road. When i try and restart engine turns but sputters like out of gas. Again and again i try until the battery is dead but car wouldnt stay running. I check battery terminals and fuses, a friend brings gallon of gas and jumps car. Same result. I have towed home. I put battery on charger put battery back in car and it starts immediately and stays running. Again i try to go to town. The same thing happens 2 miles further from where it previously did, this time the ESC was added to the others illuminating on dash. I tried the same things i did before getting same result. I take battery call a ride and go home to put battery on charger. When i return 48 hours later and put battery in, it cranks right up.

NHTSA ODI 11474266

While driving at highway speed, vehicle stated to shake and the "Engine Power Reduced" and Service ESC. I was able to move to a safe zone and drive the vehicle home. The following day started normal and drove it, same problem occurred.

NHTSA ODI 11473205

The contact owns a 2011 Chevrolet Malibu. The contact stated while driving at an undisclosed speed, the contact heard a loud cracking sound coming from the steering wheel. Additionally, the wheels failed to respond while turning the steering wheel. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the failure was similar to the failure listed in NHTSA Campaign Number: 14E044000 (Steering) however, the VIN was not included. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 160,000.

NHTSA ODI 11467800

The transmission has a rough shift in third and fifth. It won't down shift when slowing down. It was confirmed from a independent service center. There was no warning when it did it the check engine light came on. There is many people with the same complaint with the transmission being faulty. My safety and others was at risk because the car would not down shift and come to a stop.

NHTSA ODI 11463806

Warranty policy 15356 on Torque Sensor Steering Wheel. Replaced and repaired by Chevrolet dealership in 2018. Reocccured problem started again on April 13th, 2022. Code ESC power steering started May 6th, 2022 but shaking, vibration, and "twitching" started April 13th, 2022. When turning on the vehicle now the code will show and the steering wheel will lock not allowing power steering. In 2018 this code would show up during driving and lock up not allowing you to use power steering.

NHTSA ODI 11463693

4/16/2018) Codes pulled 16188 Brake Lamp Malfunction, 13036D, and 13036C. Code 16188 was repaired and replaced by the Chevrolet dealership. A warning code would show on the dashboard then brake lights would show that the brakes are being applied at all times while driving or not show when braking.

NHTSA ODI 11463695

I drove my car to a store and parked, when I returned and proceeded to backup, the steering wheel locked and I couldn’t drive and was stuck in the road. Finally after a while I turned the ignition off and back on and was able to drive home. There was no advance warning that The power the steering needed to be serviced.

NHTSA ODI 11460248

The contact owns a 2011 Chevrolet Malibu. The contact stated while driving 25 MPH and making a right turn, the steering wheel became difficult to turn. The contact stated that the power steering warning light was illuminated. The contact stated he had experienced the failure multiple times. The contact took the vehicle to an unknown dealer and made the dealer aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 14E044000 (Steering) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was 150,719.

NHTSA ODI 11458105

Airbag light and ESC power steering light on at the same time. Service ESC on and of on the screen and after awhile the steering wheel locked and I lost control of my direction while I am turning left on a traffic light. I end up in a ditch. I took it to Chevy service dealership and they find out a diffect on steering torque sensor shaft and they recommend me to replace it. They ask me $1024.00 for labor and part.

NHTSA ODI 11454714

The headlights have went out over 10 times. The wiring keeps burning. This is a known issues. Why is there not a recall? It’s extremely expensive and hard to get the front end of the car off to replace the bulb to find out it’s not the bulb. It goes out every few months. Even the dealership service department has told me it’s a known issue!

NHTSA ODI 11452078

Chevy is aware that around 90k miles the ESC light comes on indicating that the torque sensor has gone bad and indicating you are about to lose power steering. My car is 93k miles, this light came on and the power steering is completely out. My 16 year old son drives this car. This is a major safety issue and Chevy/GM say the special coverage expired in 10/2021 so they will not pay for the repair. Chevy/GM is allowing customers to drive like this without helping.

NHTSA ODI 11451911

While I was driving in the freeway steering wheel became hard . The dash said service ecs , ecs off. Pulled over turned car off and once turned on again car was driving perfectly fine. The dashboard no longer indicated any issues or messages.

NHTSA ODI 11451705

I was driving up a hill and my Service ESC power steering came up and I suddenly couldn’t turn my steering wheel so it had locked up… I slowed down and drove closes to the side of the road as I could safe as possible … after research online I notice this has happen to several others at this mileage and that there was a recall on esc system

NHTSA ODI 11451492

MAP sensor was physically broken and replaced during a particularly cold snap (below -10 degrees F), but the check engine light and "Service ESC," "Service Traction," and "ESC off" messages continued to appear in the following weeks. Acceleration repeatedly dropped off for a split second, and would continue to dip and return until I let off the accelerator and tried again. This acceleration problem always coincided with the three ESC/Traction messages listed above, and happened multiple times every time I drove it. During a second trip to the mechanic, some "frayed wiring" was replaced and the throttle relearned, but the symptoms continued as before, prior to the MAP sensor replacement and the wiring repair. The symptoms progressed to delayed, pulsing acceleration, not just dropping out. The following week, the power steering went out while driving, preceded by a gentle automated jerking on the steering wheel upon startup. The mechanic confirmed that it was electrical, nothing wrong with the physical components.

NHTSA ODI 11451132

My power steering randomly goes out and the warning lights come on. It’s hard to diagnose, as it doesn’t show up as an error and happens randomly. The wheel locks up and with no distinguishable pattern. Once I turn off the engine and start it up again, the issue seemingly disappears and I can drive as normal. Issue started around 120k, and I’m currently at 127k. Between then and now, it’s locked up about 5-6 times. Thankfully, it hasn’t happened while around others in traffic so far. But it’s definitely concerning since it’s my daily driver. Got a diagnostic done, but nothing shows up/no error codes.

NHTSA ODI 11450531

ESC off shows up on dashboard and after driving I get "engine power reduced"

NHTSA ODI 11450479

Power steering went completely out as I'm driving down the road! It's only got around 65k miles maybe 66k,not that many miles at all for this to have happened. And they were aware of the issue as well. Now I'm out my car,I am in-between jobs at the moment,no money,and no transportation for my wife and I!! No way to go to job interviews,her very important medical appointments,and everything else!! I do not have the money to take to the shop,I don't have the knowledge either to do such a major task like that,not do I even have the space to work on it myself or anyone else for that matter.its winter time,And this car is my home,Soo now what are we supposed to do? It's unsafe to drive,and will probably just make it worse,more wear and tear on other parts by driving it the way it is now

NHTSA ODI 11448480

The contact owns a 2011 Chevrolet Malibu. The contact stated while driving approximately 35 MPH, the steering wheel became difficult to turn. The contact stated that the ESC warning light was illuminated. The vehicle was not taken to a local dealer. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 84,000.

NHTSA ODI 11447240

The power steering in the car has went out and its incredibly hard to steer the car.

NHTSA ODI 11447072

I have had my Chevy Malibu since 2016. In the almost 7 years I have had this car I has had the same issue with both starting and stalling while driving. There has been many time it has completely shut off while on the expressway. I have had it looked at by an outside mechanic and the dealership. The back Fuse box has been completely replacement 3 times twice of which were in the past year. There is a shot with the fuel pump relay causing the issue. The dealership will not acknowledge this issue. Each time I have been told it was the fuse box going out however a fuse box does not go completely bad every few years and now few month. I have same many many videos and comments from other owners of Chevy Malibu 2011 with the exact same issue. I have been lucky that I have been able to pull to the side of the road without accident due to this issue. This issue should be recalled if the vast number of 2011 Chevy Malibu's having the same issue.

NHTSA ODI 11446668

The contact owns a 2011 Chevrolet Malibu. The contact stated that while driving at 30 mph, the contact avoided hitting a dog that was on the road, but the brakes failed and the vehicle crashed into a porch. None of the air bags deploy upon impact. The contact received medical attention after his head hit the steering wheel upon impact. A police report was filed. The vehicle was towed to the contact's residence. The contact replaced the CAM sensor, intake, radiator, and front end body, and on three separate occasions, the brakes were replaced. However, the failure recurred. Additionally, the accelerator pedal would go to the floorboard and the vehicle would stall. The Electronic Stability Control (ESC) warning light and a "Reduced Power" warning message were displayed. The dealer was made aware of the failure but informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 136,000.

NHTSA ODI 11442926

car unexpectedly died on the way home with 2 children in car. Car would crank, but wouldn't start up, and sounded like a typical fuel pump problem. We had the car towed to a shop and they showed the fuel pump as working within the normal ranges and then started up the next day just fine, but paid 750 for work. A few days later the car died again, so we had it towed to the same shop, by the next day when the mechanic said it started up just fine so he wasn't able to diagnose the problem. He and i don't want to spend a 1000 every week putting parts in it that don't fix the problem while getting towed each week at 150 dollars. This is a safety concern and leaves the consumer hopeless. We want to get rid of the car, but don't want to sell it to a person for them to have the same issues and then in return blame us. GM NEEDS TO DO SOMETHING ABOUT THIS. I've read hundreds of forums of other people having the same problem with no actual fix.

NHTSA ODI 11442569

Rear window brake light stays illuminated have to keep raising the brake pad up to get it to go off and in the daytime you arent able to see it. The alarm system is not allowing the car to start correctly. It is very frustrating to have to remove battery cables in many circumstances in order to operate the vehicle. These are all issues that occur many times for over a year. not just an isolated account.

NHTSA ODI 11441799

Power steering would go in and out while driveing makeing i hard to turn wheel. 137,000 miles had to have steering column replaced $1900 just for the dealer to replace this part.

NHTSA ODI 11439416