What 52 owners told NHTSA about the 2025 Kia Carnival Hev

The vehicle began shaking and having ABS problems when driving at ~30 mph after having driven for several miles without issue. The vehicle did not have any history of problems or recent symptoms and was just over one year old. The vehicle was towed to the dealership. The dealership reported a broken driver side front wheel speed sensor wire and attributed it to rodent damage without other evidence.

NHTSA ODI 11746822

I am filing this complaint to report a recurring, life-threatening safety defect in my 2025 Kia Carnival Hybrid involving the battery and hybrid propulsion system. This defect has occurred twice, and despite dealer repair attempts, it has not been resolved. On both occasions, while the vehicle was in operation, the hybrid system failed without warning. The vehicle displayed a hybrid system failure alert, lost the ability to accelerate normally, and became unable to maintain safe driving speeds. On the most recent occurrence, the sudden and unexpected loss of vehicle power created an immediate risk of collision. The vehicle’s failure while in traffic nearly resulted in a serious crash. I was driving with passengers at the time. The vehicle was taken to an authorized Kia dealership for repair following each incident. The same defect has now recurred after the first repair was completed, demonstrating that the underlying cause has not been identified or corrected. This defect substantially impairs the safety of the vehicle. The sudden loss of hybrid system function and propulsion while driving at road speed creates a direct and serious risk of accident, injury, or death to the vehicle’s occupants and to other drivers on the road. I am a [XXX] resident and am aware that this defect is not isolated to my vehicle. Numerous other 2025 Kia Carnival Hybrid owners have filed similar NHTSA complaints regarding battery failure and sudden loss of acceleration. I urge the NHTSA to open a formal investigation into this defect and to require Kia Motors America to issue a safety recall. I am currently too frightened to operate this vehicle and request urgent attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11741345

4/6/2026 vehicle stalled in traffic multiple times, entered "Limp Mode", unable to accelerate after stopping or after deceleration. I had to press the gas to the floor to get the vehicle to move. While driving, if I had to brake or lay off the gas at all, the vehicle would not accelerate back to the original speed quickly. This put myself and my four children at risk of being rear-ended. I drove with the hazard lights on to Kia of Wesley Chapel Service center. The Battery Management System Warning displayed at the time of the stalling. The Kia Access App displayed the BMS Warning and code P0AA600 (High Voltage Isolation Fault). Initially, Kia of Wesley Chapel Service Advisor stated No warnings displayed and No historical or active codes found. I provided a screenshot of the Kia Access App showing the active BMS Warning and active P0AA600 code at 2:48PM on 4/8/2026. The Service Advisor maintained that they could not find any active or history codes. At 3:00PM the same day, the Kia Access App suddenly showed "No Issues Found". The code was obviously manually cleared. I filed a complaint with Kia Customer Care the same day (4/8/2026) and requested a Kia Technical Specialist be assigned to the case. On 4/12/2026, the original Kia Service Advisor stated "the history code has finally appeared which was the one presented in the screenshot but we cannot replace parts based off of a code that is no longer active unfortunately". He stated they would "keep driving and testing" to try and duplicate the issue. The Kia Access App shows the last trip was 4/7/2026 (the day after I dropped off the vehicle). Interestingly, the vehicle was not moved from the drive up lane at the Service Center until 10:40AM that day, after being dropped off at approximately 6PM the evening prior. I believe they could not get the car to move the evening of 4/6/2026. The vehicle remains at Kia of Wesley Chapel. I am sending the Motor Vehicle Defect Notification to Kia Corporate today.

NHTSA ODI 11732931

The vehicle shows a Driver Assistance System Warning randomly. Then the vehicle is unable to accelerate past ~30MPH. We almost got hit when this happened. The warning does not show up in notifications nor does it show up in diagnostics. It gets reverts back to normal when the vehicle is turned off then turned back on. It seems to reset.

NHTSA ODI 11719729

While driving the car it will stick in the electric mode and not go back into gas mode. You will only be able to go up to 30-35 miles an hour and in order to fix this issue as of right now all I could do was have to pull over to the side of the road put the car in park turn it off and turn it back on. I worry that this issue will be even worse if I was on the interstate and my car was getting stuck in electric mode and then it’s a safety issue, especially since I have kids in the car. I’m majority of the time being a minivan. I have seen other people post on forms about this issue and it not being fixed by Kia

NHTSA ODI 11718944

While driving around, the van will go into "limp mode" effecting my speed and acceleration. Then the battery will become drained and the car alarms me to "Check Hybrid System. Stop safely." It seems the hybrid system fails to switch from battery to engine when the battery gets too low, creating the alert. While the vehicle is still running, I will check the diagnostics on the dashboard and it shows no faults: "all systems normal." This is very dangerous as the vehicle can stop running at any moment and could leave me stranded in the middle of the road. I brought the vehicle into the dealership, but they were unable to recreate the problem. While the vehicle was at the dealership, they performed the HVAC control unit upgrade due to a recall. After receiving the vehicle back, this issue has persisted. I do not know if the dealership inspected the vehicle. No other company or entity has inspected the van. This issue first appeared in the first week of November 2025. The issue didn't happen again until 2 weeks later. Now the issue persists almost daily.

NHTSA ODI 11705121

When the vehicle is idling, the battery refuses to charge, therefore, the car suddenly dies and makes it unsafe to pull over and dyes while driving, very dangerous and transmission doesn’t shift properly.

NHTSA ODI 11691088

The car gave alert of "hybrid system failure" and showed a picture of a drained battery. After about 20 seconds, we were unable to drive over 30 mph. After about 30 more seconds, the car shut off and had to be jumped to work again. Luckily we were pulling over into a parking lot when it shut off, but were blocking the entrance. This is the 4th time this has happened in a couple of months since we bought the car.

NHTSA ODI 11688400

The contact owns a 2025 Kia Carnival. The contact stated that on several occasions the vehicle failed to start due to the 24-Volt battery failure. The vehicle was jump-started and operated normally, but the failure reoccurred. Additionally, the contact indicated that the emergency key failed to open the doors of the vehicle after the battery malfunction. A locksmith was called to the scene to open the doors. The cause of the failures was not yet determined. The local dealer and manufacturer were notified of the failures. The failure mileage was 600.

NHTSA ODI 11685733

While driving, the vehicle intermittently fails to accelerate when the accelerator is pressed; it will only coast at about 30 mph. At the same time, the hybrid battery indicator shows a low charge that continues to drop rather than recharge. The “Check Hybrid System – Stop Safely” warning also comes on. This recurring loss of propulsion creates a significant safety risk because we cannot reach or maintain normal traffic speeds. We have taken the van to our local Kia dealership about this situation on two separate occasions; the first time it was reported no faults found bc they couldn’t replicate the problem. I was told there was a recall and it should fix the problem. The second time I was able to capture video of it happening multiple times to show the service technician. I was told it was something about the air intake system not being properly positioned. Now that the car is out of the shop, about two weeks later I’m experiencing issues where I’m unable to switch gears properly on multiple occasions as well. It’s been one thing after the next since I’ve gotten this vehicle.

NHTSA ODI 11683819

2025 KIA Carnival Hybrid gets stuck in electric mode. This cause rapid draining of the electric vehicle battery, reduced maximum speed, and reduced acceleration. This has occurred while merging onto the highway. I had to pull over to the highway on ramp shoulder, turn the vehicle off and back, and then merge back until the highway. I have a video of it happening while picking up my kids from school, but it is too large to upload here.

NHTSA ODI 11664744

When pulling out onto the highway from my drive way the car would no accelerate when I pressed the gas, the car would not exceed 35mph, when caused me and my kids to almost get rear ended when pulling out since the car would not go..... the car will start to flash a " check hybrid system pull over safely" light and then the car will start to coast and I have to find somewhere safe to coast off to, to turn the vehicle off and then on again, it will run fine after that but it will eventually do it again... I have taken the car to 2 different dealerships to have it looked and and they tell me nothing is wrong with it

NHTSA ODI 11658095

When driving my van to work in the morning, I would get an alert on my screen that says to check the driver assistance system. Then I turned on to the freeway on ramp and my car lost all power, not letting me drive faster than 30 mph. I was able to get off of the freeway and on to a side street when another alert, accompanied by loud beeps, came on saying “Check Hybrid System. Stop safely.” I was able to pull to the side of the road and turn the car off. When I turned it back on it seemed everything was fine. I took it to the dealership and they couldn’t replicate the problems and the car didn’t register any errors. So they returned it to me. This morning I drove to work and the exact same thing happened at the exact same place. Only this time I wasn’t able to get over as quickly and my car shut down in the middle of an intersection. Luckily I was able to coast to the side of the road. The dealership is still saying they can’t fix what they don’t know is wrong. Which I get, but it’s weird that these major events aren’t being recorded by the car. And it is terrifying to suddenly lose power on the freeway.

NHTSA ODI 11648981

The vehicle(2025 Kia Carnival HEV) is brand new, just over one month old. We parked it in the garage, and after just 4 days of not driving, the battery was totally dead. We were not able to start the van. The battery was 4.5v when measured with a digital volt meter.

NHTSA ODI 11635179

The vehicle is brand new. We drove it home from the dealership and parked it in the garage, and after just a few days, the battery was totally dead and unresponsive.

NHTSA ODI 11629402

Battery died without cause

NHTSA ODI 11624531