What 12 owners told NHTSA about the 2025 Ford Mustang Mach-e Bev Bev

I was driving normally at about 45 mph with no strong acceleration, after about 20 minutes of driving... Then Cross Traffic Alert, Crash Alert, ABS Failure Alert, Parking Brake Fault Alert, and probably more alerts suddenly went off while driving. Warning Lights for all these features stayed on, and I completely lost regenerative braking and power braking. I'm not sure if I lost anything else because I immediately pulled over, having to stand on the brakes to slowly stop. Once at a stop, I put it in park and warnings about parking brake faults continued to go off. I turned off the car, and warning about a parking brake fault continued to go off. I waited a few seconds and then opened the door to force the normal system shutdown. I pressed the brake and hit the start button again, but it didn't seem to recognize that I had pressed the brake and started in accessory (ACC) mode. After a few more second, I pressed the brake again and hit the start button (while still in ACC Mode), and the vehicle moved to full running mode without all of the warnings. This situation could have easily resulted in a full crash if I were driving at a faster speed and/or if I required immediate stopping.

NHTSA ODI 11742703

On Thursday, May28 I was driving my 2025 Ford Mach-2 on Schrock Rd. in Columbus, Ohio at approximately 3:30 PM when the hood (the "frunk") of the car unexpectedly unlatched and opened, flying up to a vertical position and obscuring my view of traffic. I was driving in the left lane of this road at 40-45 mph. My view of the road was immediately obstructed, but I was able to crouch sufficiently to see enough of the road ahead and the mirrors on each side to navigate to the right lane and then to the side of the road, pull off safely, turn the car off, exit, and close the frunk firmly. I was away from home when this occurred. When I got in the care to drive home, there was a warning that came on, for the first time, that read as follows: FRUNK FAULT DETECTED; SERVICE REQUIRED. There was no advice to avoid driving the car. I checked the hood/frunk to be sure that it was firmly closed, then started for home, avoiding my usual freeway drive at 65mph for a slower trip on local roads. It is a good thing I did, because the risk of a major accident with injury and serious property damage would have been far greater at higher speed. I arrived home without the frunk opening again, called for Ford Roadside Assistance, and arranged to have the car towed to Germain Ford of Columbus, where it still is, awaiting the delivery of a new frunk latch system. The dealer has determined that there is likely a defective sensor in the frunk latch. This is a known issue with the Ford Mach-e, affecting not only the frunk but also sometimes the hatch lid in the rear.This is a serious safety hazard, and a review of reports over several models years from Mach-e owners indicates that I am not alone in having experienced it. At highway speeds a suddenly unlatched frunk/hood would not only open to the vertical, but conceivable also be smashed against the windshield or ripped off the vehicle and become airborne. Ford is aware of the issue, for there is are technical service bulletins covering it.

NHTSA ODI 11741785

Dash completely turned off. We could not see speed, gear, battery life, etc. See attached photo of the dash board above the steering wheel. Tried turning car off and on, tried resetting the monitor. Dealership service advisor witnessed this. The technician could not replicate it, and they did not have a solution but it is now back on. Worried it may happen again, opened up a buy back claim but dealership thinks we don’t have a strong case since they couldn’t find anything.

NHTSA ODI 11706310

Summary: My 2025 Ford Mustang Mach-E GT has repeatedly experienced a complete and unexpected loss of propulsion while driving in active traffic. Each time, the vehicle displayed a red “Stop Safely Now” warning with additional critical alerts, followed by an immediate loss of forward motion with no prior indication. This left the vehicle stalled in traffic and created a significant safety hazard. Details of Each Incident: While driving under normal conditions or coming to a stop, the vehicle triggered the red “Stop Safely Now” alert with powertrain and brake warnings. Propulsion shut down instantly and the vehicle locked in Park, leaving it immobilized in traffic lane. I had to exit the vehicle and wait for it to complete a full power-down cycle before it would restart. After restarting, the vehicle operated with reduced functionality and limited range. Ford Roadside Assistance was contacted for every incident. Safety Concern: A sudden loss of forward motion in moving traffic poses a serious crash risk to me and to other drivers. The repeated nature of this failure suggests a defect in the propulsion system, sensors, electrical components or related modules. Current Status: The vehicle is now at the local Ford dealership for evaluation. I have also notified Ford Corporate Customer Care. The root cause has not yet been identified or resolved. Requested Action: I request that NHTSA document this complaint and consider further review due to the recurring safety-related failure and the potential risk to other owners.

NHTSA ODI 11704393

I traded in my vehicle and purchased a new vehicle on September 27, 2025. After signing the contract, I was informed that there were two recalls on the vehicle that would be taken care of by the end of the day. I was allowed to use my trade-in as a loaner vehicle until the end of the day when I came back. It has been almost a full month and I still have not received possession of my new vehicle. There is no estimated date of the dealership receiving the part to repair the recall. I was told that things haven’t been the same since Covid so nobody knows how long it will take. I have been able to use my trade-in, which was paid off by the dealership, as a loaner, but I want my new vehicle or I want to know my options for looking for another car. I will be making my second payment on my new vehicle, which I have not had, in one day.

NHTSA ODI 11695844

VIN: [XXX] Recall data refreshed on Aug 09,2025 0 Unrepaired Recalls associated with this VIN Please BROADCAST the following reported RECALLs which are incomplete: 2025 Mustang Mach-E Safety Recalls* Powertrain control module and secondary on-board diagnostic control module c software upddate Recall incomplete Park rod replacement Recall incomplete INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11679492