What 308 owners told NHTSA about the 2024 Mazda Cx-90-mhev

Driver side mirror vibrates to the point where items in the rear view mirror are not clear or visible. The mirror becomes unusable on the driver side

NHTSA ODI 11585543

Car jas adaptive headlight and it malfunctions every other But when it happen low beam and high beam depth go down atlest 20%. This car has very bright light for low beam and since low beam projection tilt down and stuck there while you r driving this make situation so dangerous in night. Light low beam depth(till where it illuminates the road) is so bad it makes you blind and wont be able to judge where the road solid line going to turn. I almost ran into road divider Mazda dealer saying they don’t have solution and mazda has to provide it. I had this in writing when last went for servicing

NHTSA ODI 11584367

1st instance 12/06/2023- The battery was drained and it won't start so they changed the battery. Dashboard light says engine malfunction have the vehicle inspected. 2nd instance 02/10/2024- same dashboard light Engine malfunction and Hybrid malfunction. This time they said that DTC was P0E10. They also noticed low battery charge warning. Battery was charged with DCA8000 charger and they said that notif went away. 3rd instance-02/23/2024 same dashboard light. This time they had DTC's of 5. P0E10, P1739:12, P1B05:16, P1739:00 and P1B05:00. to think this is a brand new card purchased last october 2023 with less than 3000 miles.

NHTSA ODI 11577923

My sunroof just suddenly explode while driving at the highway with my kids, we almost got into a car accident. It sounded like a gunshot. Never get crack or hit by stone before we travel.

NHTSA ODI 11577831

Started hearing a rattle in the mid console of the car that gradually got worse. When i checked under the car, there was a bolt missing and one hanging that was suppose to be holding the propeller shaft. When i took it to the dealer, they tried to lie and say that they were only loose which is what you will see on the paperwork but when i confronted them that i saw one was missing and the other bent, they said yes, they don’t know what happened but they fixed it.

NHTSA ODI 11577767

There has been two dangerous failures both occurring in an intersection. First instance was in December of 2023 whey the fuel pump failed while turning in an intersection. The second incident was a hybrid battery malfunction, rendering my vehicle unusable in the middle of an intersection again. This was 03/2023

NHTSA ODI 11577123

An ultrasonic sensor located in the right front grill area was determined to have failed producing the following message on the dash display: I-Activsense Temporarily Disabled. Ultrasonic Sensor Obscured. Drive Safely. This message initially appeared at approximately the 1500 mile mark of service and was documented when the vehicle was brought in for routine maintenance to Fort Myers Mazda at mile mark 3583 on 3/12/24. It is my position that safety equipment should be reasonably durable and reliable which is clearly not the case in this situation. There is a small pin sized dimple in the sensor lens. The sensor is currently available for inspection. It is further the position of Fort Myers Mazda that this sensor is not covered by the Manufacturer’s warranty due to component damage.

NHTSA ODI 11576973

In October 2023 I began to notice that the steering was not working properly. When driving I would notice that the steering would stick and require more force to turn. It would click while turning. I brought it to the tully mazda (nashua NH) who told me that others were experiencing the same but that there was no fix for this yet. On 12/27/23 I again notified tully of this issue and there was no fix for it. On 2/9/2024 I discussed again with tully who advised me that there was a recall to be announced shortly. They did not tell me that there was a safety issue driving the vehicle. On [XXX] while making a left turn (there are two side-by-side turn lanes and I was in the inside/left) i completed my turn and while straightening out the wheel the vehicle overcorrected hitting the vehicle to my immediate right. I have approx $5000 in damage but there were no bodily injuries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11575130

Car has 5000 miles on it. Numerous issues with car. Unsafe steering. Dealer not able to repair steering until Mazda provides parts for recall. Now on the highway with a medium depressed foot pedal the car speeds up on its own. Happened 2 times so far. Brakes had to be applied to slow car down. It was very brief because I immediately stepped on the brake, but it was definitely an uncommanded acceleration. Both times I did NOT have cruise control on. Definitely not safe.

NHTSA ODI 11575074

The vehicle's parking "gear" would not engage. Further, the emergency brake would not engage. Puts all in proximity to the vehicle at risk due to the vehicle rolling into or onto them and damaging personal property. Dealership service department could not recreate the the parking "gear" issue, but were able to recreate the emergency brake not engaging. Vehicle has been inspected by Macdonald Mazda West representatives.

NHTSA ODI 11573328

The contact owns a 2024 Mazda CX-90. The contact stated while driving the same day the vehicle was purchased, the message "Telematics Malfunction" was displayed. The vehicle was taken to the local dealer, where the message was cleared; however, the failure persisted. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 23V718000 (Back Over Prevention, Forward Collision Avoidance, Lane Departure). The contact stated that while driving, the images of the front-view, side-view, and rear-view cameras failed to appear on the center display intermittently. The vehicle was taken to the dealer, where it was diagnosed, and the dealer determined that the view monitor control module software needed to be updated; however, the part to do the recall repair was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 8,500. Parts distribution disconnect.

NHTSA ODI 11572115

The major issue that happened to our newly purchased CX 90 last February 3 with more than 500 miles on it started around 5:30 pm of February 8, while my wife is driving this vehicle with my daughter, all of a sudden the car stopped at the middle of the road with warning signs popping up in the dash screen like I-active sense malfunction, hybrid battery malfunction, engine malfunction light on, and on top of these, critical vehicle malfunction. The car won't start and disabled. Also, the vehicle cannot switch to neutral gear to push/pull the vehicle to the side that made the vehicle blocking the roadway until the tow truck came in. My wife and daughter's life was put in danger when this vehicle suddenly stopped in the middle of the road with cars passing by on both ways. I also found out based on the NHTSA vehicle safety, Mazda recall website, carfax and Kelly blue book, that this particular vehicle with its VIN has a SAFETY RECALL due to its steering issue that may increase risk for crash. This was not disclosed to us when we are on the process purchasing this vehicle and they did state inspection and passed it that made we doubt how did it happened.. The vehicle is now with the dealership repair shop and the last update I receive was the technician is still checking on it.

NHTSA ODI 11571146

On 02/07/2024, malfunction prompts displayed on my dash relating to I-stop functionality, hybrid functionality, engine. Took the vehicle the next day to be diagnosed, the appointment was set as an inspection with oil change, filter change, and the prompts on my dash. I was advised that the issue to the prompts stemmed from the hybrid battery. I was told that contact was made to the manufacturer and that the battery would have to be replaced. The battery is on backlog and it would be about a month to arrive. I called in after leaving with additional questions as to the safety of the vehicle with the hybrid battery problem. The man on the phone said it is safe to drive, what would be affected would be the mileage I would not get because the hybrid portion was not functioning. He mentioned that a separate case was created with another 2024 cx-9 car owner with the same hybrid battery issue. It’s now two known cases with the hybrid battery issue. I called customer service and was provided with case number 00174049. The resolution to that call to corporate customer service is that I would receive a call back from the local dealership about a loaner car with about an hour. I became aware of a fourth recall, that the corporate agent referred to as a campaign, pertaining to the steering wheel. I asked my dealership advisor if that can be looked in addition to the other issues. She stated that she could not because it has not been launched. The corporate agent advised me that notification would normally happen 2-3 weeks. I looked up the steering wheel recall on the dep of transportation website. The recall has been published since the 18 of Jan 2024 and have yet to receive notification. I only found out today when I took the vehicle in for inspection.

NHTSA ODI 11570599

We called the dealer to have the recall taken care of. We were told that they were not sure if the part would be in in time for the date that they had set to do the fix. HOWEVER, the dealer also told us that we would be secondary to the fix vs their current on the lot inventory that they want to fix to sell! THEN, we will be able to have the required fix as there is availability of the part. Who should come first as this is a safety problem: The loyal customers that are actually out there driving the cars every day under the safety risk or cars sitting on the dealers lots waiting to be sold sometime down the road. Should an existing driver have an issue this would most certainly be a lawsuit. (We are on Facebook Mazda CX-90 North America website. It seems like the fix for this steering problem doesn't fix the issue) This is my second complaint with this vehicle. The first tracking number is: 11554525. NHTSA # 24V-022. (this complaint came as our car was at the dealership for 6 full weeks. They had to drop out the entire motor and transmission!). Pictures below uploaded. We also have been told that there will be several additional recalls to come. We are beyond frustrated with this whole process and car. Thank you for giving us a platform to lodge our concerns and issues.

NHTSA ODI 11569603

The lane assist safety feature stops working. The car will allow drifting across well-marked lanes, despite being a clean car and a clear weather day. The car will not attempt to keep the car in the lane. The events are unpredictable. I have checked the settings when it has happened and they all appear to be the same - the lane assist and related boxes remain checked, etc. After turning off the vehicle for an hour or two, the system seems to reset and work again. This has happened twice that I know if, but could have happened at other times that I did not notice.

NHTSA ODI 11569335

The “360 View Camera” image periodically goes blank, providing no image, just a blank screen with the colored lines showing vehicle and wheel direction. So when the car is put in reverse or forward, no image of the surroundings are visible. This will not resolve until the vehicle is turned off for an extended period. (An immediate restarting of the car will not resolve.) This car has had the other camera recall addressed and another camera TSB addressed. The issue continues to occur at random, unpredictable times. It has perhaps occurred 10-11 times.

NHTSA ODI 11569341

Both lower front control arm ball joints squeak when turning vehicle at slower speeds. Squeaking sounds were noticed at 970 miles. Dealer applied grease as a temporary fix per Mazda TSB #02-002/23. This is a family SUV and I take my wife and kids in it. I am concerned that this is a safety issue as there is a high chance of the lower control arm ball joint failing resulting in inability to steer vehicle in the proper direction. Please look into this issue. Thank you.

NHTSA ODI 11568194

I have raised case [XXX] [XXX] [XXX] ] with Mazda regarding my 2024 CX90 where there's a suspension and emergency automatic forward Collison breaking since I purchased the car and now this steering issue safety recall. They are not replacing or buying back. I'm feeling unsafe and fear to drive as if this malfunction car leads to accident. Please assist. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11567999

When driving on the highway next to a large truck or semi and on a curve, the adaptive cruise control thinks that there’s a vehicle in front of you and slams on the brakes. This has happened a few times with my vehicle. Thankfully, there were no vehicles immediately behind me, or the results could’ve been tragic.

NHTSA ODI 11567288

Climate control system issues. Fails to maintain set temperature. Overheats interior when temperature is selected at 68 degrees. Have to turn it down to 62 degrees to maintain an acceptable temperature. This is in the Midwest with outside temperature below 30 degrees and climate control set to auto.

NHTSA ODI 11565417

During cruise control engagement when passing a larger vehicle the system sometimes will execute aggressive braking potentially causing an accident with a vehicle following behind. Have to be ready to disengage cruise control during all situations with other vehicles in proximity. It will always perform the aggressive braking maneuver when passing a semi-truck on a curved highway.

NHTSA ODI 11565420

Passenger side, side view mirror will intermittently turn all the way in and down. This makes it impossible to see traffic on your side. Once it turns in, it is stuck and you need to get out of the car to physical move it so the motor will adjust it again. This can happen at anytime and has happen at least 10 times since we've purchased the car on 12/29/2023

NHTSA ODI 11565142

In tighter corners the car coasts/brakes unnecessarily while cruise is on. Seems like a safety feature possibly or a malfunction as I haven't had that on any other cruise controls on other vehicles. Then after the corner it accelerates. I find very annoying. If this is considered a safety feature then ok but it is way to sensitive currently and needs an update.

NHTSA ODI 11564261

On highway traveling the steering becomes tight and stiff. You have to use 2 hands to keep in lane. I have noticed it usually starts 30-45 minutes into the trip and get worse. Today is 3 trip it has happened.

NHTSA ODI 11563016

Turning left at intersection at green light , the oncoming traffic sped up and I needed to floor it to not get hit. The my car switch to hybrid and went into a crawl pace. I had to floor it again to wake it up and get the heck out of the way. I don't think the computer is doing a good job talking to the hybrid system and the powertrain during emergency maneuvering. This can be dangerous. I know it scared the hell out me.

NHTSA ODI 11563143