What 41 owners told NHTSA about the 2023 Volvo XC40 Recharge Twin

While I was driving, the infotainment system turned itself off twice during the same trip. First time was on a highway and was extremely scary. I wasn’t in a place I could easily pull over to assess. Both the main screen in the middle console and the screen behind the steering wheel went dark. Volvo NEEDS to figure it out re infotainment. It shouldn’t be turning itself off mid drive and then ultimately rebooting itself while the car is moving. I have already installed all the updates, but clearly it wasn’t enough/effective.

NHTSA ODI 11744378

I pulled into a parking spot with a concrete barrier pole at a pharmacy to pick up my sister. I had my foot on the brake while she was getting into the vehicle when the vehicle suddenly accelerated forward crashing into the pole. I have also had an incident where I tried to start the vehicle and could not get the vehicle to go from park to reverse. This is concerning that there could be some faults in the electrical system, sensors or brakes.

NHTSA ODI 11741990

The supplied 240V Level 2 charger has a design defect that causes the J1772 handle to detach from the high voltage supply cable exposing the individual wires to a possible fire condition.

NHTSA ODI 11675339

Going back to last year I have reported to Volvo the software issues on the car. 1. Automatic Emergency Braking - Currently the car is ABRUPTLY breaking in the streets thinking it there is a car in front. It's so incredibly dangerous. I've reported it and they have not done anything about it. (Most Recent Issues) 2. Electrical - the screen every other week needs to be reset - it reads that it does not have air-conditioning, airbags, and all the buttons are grayed out. I've reported this since December of last year. NOTHING HAS BEEN DONE 3.

NHTSA ODI 11663690

I went through a car wash and then pulled into the first parking spot near the vacuum cleaners. As I was braking and coming to a stop, the car suddenly lurched forward and accelerated on its own. Despite pressing the brake pedal multiple times, the car did not stop until it went about 15ft. To avoid hitting the building wall directly in front of me, I swerved to the left. The car collided with the metal pole supporting the vacuum cleaner structure, causing significant damage to the entire side of the vehicle, and also clipped the corner of the building on the right as it went through the area. There were no warning lights, messages, or other indications of an issue before the incident. I have videos of the incident from the car wash. -The issue involves unintended acceleration, potentially related to the accelerator pedal sensor (APS), throttle control system, or braking system. It may also be electrical, as similar issues in 2021 and 2022 Volvo XC40 Recharge vehicles were reported due to water damage and corrosion in the cable harness, leading to unintended APS signals. The vehicle is available for inspection upon request. -The vehicle suddenly accelerated without input causing a collision. To avoid hitting a building wall in front of me, I swerved to the left, and the car struck the metal pole supporting the vacuum cleaner structure. The impact caused significant damage to the side of the car and clipped the corner of the building as well. This incident could have resulted in severe injury or damage had anyone been nearby or if the car had collided directly with the building (which held the car wash electrical panel). As it stands I have a stiff neck and some PTSD. -No, the problem has not yet been reproduced or confirmed by a dealer or service center. It's at the collision center. -No, the vehicle has not yet been inspected by the manufacturer, police, insurance, etc. -No warning lamps, messages, or other symptoms appeared before/during/after the incident.

NHTSA ODI 11629892

While driving, car suddenly stoped and all electrical functions stoped working. Could not even turn on hazard warning flashers. Very lucky for not being rear ended.

NHTSA ODI 11618188

The contact owns a 2023 Volvo XC40. The contact stated that while driving at various speeds, the message "Do Not Drive - Stop Immediately" message was displayed on the instrument panel. The vehicle was taken to the dealer where the contact was informed that the START/STOP feature was inoperable and was the cause of the failure. The dealer attempted to recharge the START/STOP battery; however, the battery failed to hold a charge. The dealer then decided to replace the main battery but that repair also failed to correct the failure. The vehicle remained in the possession of the dealer unrepaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 4,000.

NHTSA ODI 11614296

Backup camera frequently flickers between video stream and black screen, creating a dangerous situation while backing up. Display screen also frequently displays message sharing camera is not available when shifting into reverse. After multiple trips to Volvo dealership they state the problem is common but nothing they can do about it.

NHTSA ODI 11595667

The contact owns a 2023 Volvo XC40. The contact stated that while her son was driving at various highway speeds, the brakes inadvertently activated, causing the vehicle to abruptly stop even though were no other vehicles or objects nearby. Additionally, the vehicle occasionally stalled and hesitated while accelerating. The contact also stated that the display screen occasionally became inoperable, and messages and safety warnings were not available to the driver. The vehicle was taken to the local dealer who was unable to duplicate the failure. The dealer had replaced unknown sensors, but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was 13,000.

NHTSA ODI 11547353

The contact owns a 2023 Volvo XC40. The contact stated that the SOS button had malfunctioned and had caused several different calls to be made except for a call for roadside assistance. The contact contacted the dealer; however, the vehicle was not diagnosed. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage 700.

NHTSA ODI 11511962