What 142 owners told NHTSA about the 2023 Toyota RAV4 Phev

Vehicle was traveling straight approximately 70–80 mph in very light drizzle. No warning lights or messages before the event. Vehicle suddenly entered an uncontrolled spin multiple times. During the spin, I heard a grinding noise. After stopping, brake/parking brake system warnings appeared on the dash, video after the event recorded.

NHTSA ODI 11748288

When pulling into a driveway, sudden acceleration while slowing down caused crash into side of the garage and damage to the right front fender, side panel and hood.

NHTSA ODI 11716165

My wife was going at about 10 - 15 mph coming up about 2 car lengths to a small curve in a residential area when all of a sudden she heard a pop or snap and the Rav4 went to a super high speed by itself. The acceleration could not be stopped even though she had her feet on the brakes. She had both hands on the steering wheel to avoid hitting a house and ended up going through a wall in the yard. There were no warning sounds and no signals indicating a problem. it appeared that the display was blank. There was no pre-collision warning or braking except as my wife was pushing on the brakes. She also hit the right side into side wall. No air bags deployed even though Windshield and all door glass on sides shattered. My wife the driver was okay and not hurt, and the grandchild in the car seat behind my wife was fine also. Neither had injuries. There were checked by emt. The police looked but all would not try to get in except to remove my granddaughter. My wife was removed also because she could not get out the door was jammed against shed and rock, and handles broken off This happened after the recall work was done by toyota dealer on 12/04/2025. There were no problems prior to the recall. I've listed the recall below. 25TD01 Rear Traction Motor Cable Corrosion - Multiple Model & Model Year Toyota Hybrid (AWD) Vehicles NHTSA Recall ID AWAITING# Recall Date Dealer Reference ID 25TD01 Description The subject vehicles are equipped with a rear motor unit and an HV Floor Under Wire that provide high voltage to operate the motor. Mud, water, or road salt could potentially enter the HV Floor Underwire connector housing and could cause corrosion over time. Excessive corrosion could cause AM Radio Static during certain driving cycles, or the vehicle may not start. Status Remedy Available Remedy Any authorized Toyota dealer will apply a wire harness protector seal to the HV Floor Under Wire Connector. Toyota corporate engagement is looking into this.

NHTSA ODI 11706225

While entering my garage (video available)The 2023 Hybrid Rav 4 accelerated on its own when I was braking to put it into reverse to back up to realign to park in my space. I was hitting the brake and the brake lights were on the dashboard while the car keep accelerating hitting the garage wall.

NHTSA ODI 11704375

We discovered severe mold contamination and water intrusion in our 2023 Toyota RAV4 Hybrid. My wife, our [XXX] child, and I have been experiencing dizziness and nausea for months whenever we were inside the vehicle, but we did not know the cause until the dealer (DLL) showed us extensive mold throughout the cabin and standing water trapped inside the vehicle. The dealer confirmed that this was not normal wear and tear. The mold has spread into the floors, interior panels, and even the steering components. This is a serious health hazard. After doing research, we found many other RAV4 Hybrid owners reporting similar water leaks and mold growth issues. This raises the concern of a potential design or sealing defect in this model. This vehicle is unsafe to drive, especially with a young child. We are requesting a full safety investigation into the water intrusion, sealing integrity, and air quality risks associated with this model. Symptoms:     •    Dizziness     •    Nausea     •    Headache     •    Strong mold smell     •    Corrosion of interior components This is a serious safety and health issue, and we are asking NHTSA to investigate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11699395

I was in a very bad accident on [XXX]. I was side swiped from the front passenger side of the car. I was not at fault of the accident. My car then hit a fire hydrant and a pole. The airbags did not deploy and my head hit the steering wheel I own a 2023 RAV4 XLe premium. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11694907

The vehicle was a 2023 Toyota RAV4 hybrid. When the driver attempted to park the vehicle in a parking lot, it suddenly began moving forward without use of the accelerator. The driver applied the brakes but the pedal went to the floor without braking. The vehicle seemed to be moving faster than expected without use of the gas pedal and went through the parking lot. The driver stopped the vehicle by running up over a curb, through a traffic island with soft dirt and mulch and finally crashing into a metal storage unit. Two air bags deployed. Toyota was notified of the crash and a Toyota representative made the 911 call. A New York state trooper and two fire trucks arrived. The vehicle was towed and eventually collected by our insurance company. The tow truck driver said the brake pedal went to the floor when he tried it. The car was declared a total loss. 1. The notable failure was in the braking system. The car also seemed to be traveling faster than it should and didn't slow down. The insurance company has the vehicle now. 2. The safety issue was loss of speed and braking control of the vehicle. Steering was normal. Fortunately the parking lot had few cars or people in it. 3. No investigation of the problem aside from assessment of damage that I know of. 4. Liberty Mutual assessed the damage. The NY state trooper made a collision information form and gave us a copy. 5. No warning lights or related symptoms were noted prior to the car traveling on its own. After the crash, a local Toyota dealer called and said that they were notified that the check engine light was on and there was a problem with the hybrid system, along with other warnings.

NHTSA ODI 11671474

Sudden surge and acceleration upon parking. I had brakes depressed pulling into a parking space when the vehicle felt like it jumped and quickly accelerated. It veered left missing the parked van in front of me but crashing into the parked Honda Accord two spots over and one in front. It crashed into the back tire and fender area of the passenger side of the Honda pushing it completely out of its spot and sideways. My vehicle kept going even though pushing the brakes to stop. I had to force it into park to stop. The car’s air bags deployed but my Toyota’s airbags nor crash warning system worked.

NHTSA ODI 11654811

I was driving over 120 MPH and my car slid and hit the front car. My car later caught fire and ruptured shortly after. The FD extinguished it and it was a total loss. I have no clue as to where it was taken after the accident. Sorry :(

NHTSA ODI 11653295

I was pulling into a parking spot and my vehicle suddenly accelerated. I slammed on the brakes and the car did stop, but not before hitting a railing in front of me. There were also trees close to the railing, so the camera should have detected those as a barrier and I believe the veauto-braked, even if I had not hit the brakes. This is a safety concern because the vehicle would have plowed over any person in front of the vehicle.

NHTSA ODI 11640212

Rearview camera quit for 3-4 seconds when I was backup. There was a car in my blind spot, aft right quarter, that I couldn't see and I hit his left front panel/headlight causing $2200. damage to his car plus my car.

NHTSA ODI 11637124

While making a slow right turn into a carport (1-2 mph), the vehicle suddenly accelerated on its own and crashed into the carport wall, continued to full throttle causing the tire to skip along side of the wall. The vehicle is currently not being used as we continue with the process with our insurance provider and begin to initiate contact with the car dealer. There were no warning lights or indications of a malfunctioning vehicle prior to that point. Initial online research provided at least 10 other reports that the exact same occurence happended to other 2023 RAV owners causing vehcile and property damage. We are fearful to use this vehicle now and would like to submit a safety report to prevent any similar instances in the future that may result in serious injury or death. NOTE: We also have video footage of the incident from our carport security camera, if you need that for further review.

NHTSA ODI 11607856

Driving NB when a Toyota Corolla drove into my lane of traffic hitting me head on. No air bag deployed in my RAV but all air bags deployed in the Corolla. No air bag light was on prior to the accident. My vehicle data recorder was copied by a Bosch technician and forwarded to Toyota Corp. The body shop manager stated that my vehicle was the first he had encountered with the extent of front damage where the air bag(s) did not deploy

NHTSA ODI 11597173

The brakes failed, without warning, while parking; causing me to hit a pole/wall in my employer’s parking garage on April 12, 2024. I was injured, and obtained care from UChicago Medical Center. Toyota assigned an independent investigator to assess my vehicle; which was completed on April 29, 2024. Per Toyota, no brake issues were noted. My vehicle remained at Oak Lawn Toyota from April 12, 2024- May 31, 2024.

NHTSA ODI 11592300

The incredibly frightening incident occurred 2 times within 3 days. My 2023 RAV unexpectedly and very forcibly accelerated on its own when I was pulling into a parking space. Luckily I am in the habit of parking my RAV far away from other vehicles in parking lots when the option exists. The first ‘acceleration and/or braking’ malfunction occurred 5/31/24 in a Walmart parking lot. When pulling into a parking spot my right foot was fully off the accelerator (I use my right foot only for the accelerator and brake pedals) and was gradually depressing the parking brake pedal to come to a complete stop. Instead my RAV suddenly and forcibly accelerated forward through the empty parking spot in front of me and beyond!! I would have absolutely smashed into the car and or person if one were there!! As the RAV shot forward I began desperately pushing full force on the brake pedal; the RAV did not stop! so, I began full force repeatedly pushing and pumping the brake pedal. My RAV eventually came to a halt as the tires may have locked up which it skidded about 12-18 inches. By God’s grace no one was hurt! On 6/2/24 ‘it’ happened again!! Pulling into a parking spot at an outdoor cafe, as I was gradually depressing the brake pedal to come to a complete stop my RAV instead quickly and forcibly accelerated forward!! I thank God that I did not pull into the other spot (my sister took that one) which was just a few feet away from around 12 people and families enjoying their outside lunch dining!!! This 2nd horrifying incident my RAV took longer to come to a complete stop. I fully and forcefully pushed on the brake pedal but my RAV kept going!! I continued repeatedly releasing and fully depressing the brake pedal but it kept going! The next thing my RAV was approaching was someone’s backyard and house!! I forcibly pushed the brake pedal one more time and also threw the RAV shifter into “park” finally the RAV stopped! I am so shaken up by these traumatic malfunction incidents.

NHTSA ODI 11592021

Unintended sudden aggressive acceleration when I made a right as I was slowly pulling into a spot in the parking lot. Breast’s did not work fast enough and car ended up going up the hill and front colliding with it.

NHTSA ODI 11588350

A car pulled out right infront of me at an intersection, I hit their back drivers side rear with most of the front of my car. I was doing approximately 41-45 mph. No airbags were deployed and my SOS button didn't work nor did it call for help.

NHTSA ODI 11585406

A strong fuel odor was evident in the cabin, and also under the hood after operation. Vehicle use was low, approx. 6K miles from new. My wife reported this to the dealer service department. They said nothing was wrong with the vehicle. Approx. 2K miles later, I reported the same problem to the dealer. Service rep said vehicle was unsafe to drive due to over torqued and leaking fuel line. They repaired it for no charge. No fuel vapors now, but if this is a production quality issue that others have reported, only to be told nothing was wrong, I think a major fuel-combustion safety issue may be overlooked. I am submitting documentation. Also, I am concerned about health effects of sustained fuel vapor exposure over months of driving. My wife rear-ended a stopped vehicle, possibly due to cognitive impairment from fuel vapor exposure. No warning indicators were ever triggered. Thank you.

NHTSA ODI 11576220

I was pulling into a handicaped parking space and the car just jumped over the curb and hit the handicaped sign plowed into the landscapping. it went from 5miles an hour to 20miles an hour in 5 seconds by itself . computer took over . no air bags were deployed .

NHTSA ODI 11568860

I was coasting into a parking space (at 6.8 mph) and as I attempted to park, the car suddenly accelerated and went up and over the concrete rectangle park stop and smashed into a brick building (12.4 mph) and went back over the park stop before the engine in the vehicle finally died. During the acceleration, I was trying to brake the car, but the car wouldn’t stop. I was yelling to my husband that the car wouldn’t stop. The driver airbags deployed as well as the knee air bag. The passenger airbags did not deploy as there was not a passenger in the front seat. The car had 4258 miles and was totaled. My husband and I both sustained injuries. According to the Toyota app, the vehicle had a “0” rating for fast acceleration and a “1” rating for harsh braking during this particular trip. I contacted Toyota and an investigation was conducted using Bosch Crash Data Retrieval Tool 23.2.1. The data shows a 5 second timeframe with .50 second intervals. The vehicle speed at the 5 second mark was 6.8mph with 0% accelerator pedal. At 2 seconds, the speed was 5.0mph with 8.5% accelerator pedal. And, at the crash point the vehicle speed was 12.4mph with 100% accelerator pedal. Toyota product liability contacted me with their report stating that there was no brake pedal application prior to the impact and that pressure was applied to the accelerator pedal at wide open throttle seconds prior to the impact, and they found no obstructions or interference with the operation of the accelerator pedal. Further, they found the brakes to be operational However, the vehicle could not be test test driven as it would not turn on. In summary they did not find any evidence of an issue or defect with the vehicle based on inspection and electronic data.

NHTSA ODI 11551174

Backed into a mailbox on the passenger side rear taillight. Car did not detect the mailbox and give any warning to the driver. Mckinnon Toyota in Clanton Alabama advised that this vehicle is not equipped to detect a stationary object behind the vehicle. Three individuals at Toyota customer service advised that it did. R/O Number for the visit is [XXX]. The reference number from Toyota customer service is [XXX]. Car was purchased on 6/2/23. Car was purchased with the expectation that it was equipped to detect rear stationary objects when in reverse. I consider this a safety issue if it will not detect a person behind the car in reverse. This is my daughter's car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11550585