What 191 owners told NHTSA about the 2023 Tesla Model X (all Variants 6-seat)

I own a 2023 Tesla Model X and I am reporting a steering-related safety concern. When making hard left turns, the steering wheel/front end shakes or shudders and makes a LOUD sounds. This does not feel or sound normal and appears to be related to the steering or front suspension system. The issue happens during low-speed turning/maneuvering when the wheel is turned sharply to the left. I contacted Tesla Service regarding the issue. Tesla advised that this is a known issue and that there is currently no available fix. Despite acknowledging that it is a known issue with no repair available, Tesla still wants to charge me a diagnostic fee. I am concerned because this involves the steering system, and I do not believe a vehicle should have steering shake or shuddering during normal turning, especially on a 2023 vehicle. Since Tesla has stated this is a known issue but has no fix, I am requesting that NHTSA review this as a potential safety defect affecting the 2023 Tesla Model X. The issue has not been repaired because Tesla stated there is no fix available at this time.

NHTSA ODI 11747871

My 2023 Tesla Model X suffers from severe, intermittent safety system failures. Specifically, the Automatic Emergency Braking and Steering Assist randomly become unavailable while driving. Tesla Service refuses to repair this, claiming they are "unable to replicate" the intermittent alerts. However, the vehicle's history proves severe safety flaws: Tesla previously had to replace the entire steering wheel assembly and the driver's seat belt lap pretensioner due to failures, and had to recalibrate the forward ADAS camera because it went out of spec causing Autopilot failures. These unresolved, randomly occurring defects pose a severe crash hazard that Tesla is ignoring.

NHTSA ODI 11725133

Peeling steering wheel, eventually will need to replaced due to not being able to grab wheel and lose grip when I turn. Many others complain of the same problem with model x and Tesla wants $1800 to replace. I refuse to use my insurance to pay for this so they have not inspected it.

NHTSA ODI 11672083

In many near hit collisions where I need to honk the horn, memory reflexes goes to press down the center of the steering wheel to alert but the horn button isn’t there on this vehicle. It’s put as a button on the right side but after 25,000 Miles and at least 4 times, I could not locate it quick enough. This is a serious safety issue.

NHTSA ODI 11671448

On my 2023 Tesla Model X, the horn button is a capacitive touch button among several other buttons and it is difficult to use on a daily basis and impossible to find in an emergency. Yesterday, another car was drifting into my lane on the highway traveling at 70 MPH and I could not locate the horn in time to alert them. I had to drive evasively to avoid a serious accident. This has happened at least 7 separate times already. 2024 Tesla Model Xs now have the button in the center of the steering wheel where it is on every other car I have ever driven. Yesterday, I contacted Tesla service about this critical safety issue and demanded the replace my steering wheel with a center horn button because of the document safety issues. They refused. There needs to be a recall forcing Tesla to replace these defective steering wheels with the new and safe design before people get killed.

NHTSA ODI 11649939

The horn is a button on the top right of the yoke steering. With a turning wheel the position is not stationary and in situations where it is warranted to warn other vehicle or person you keep looking for it and get distracted. I have had this vehicle for about three weeks and I find this as a serious safety issue. Today I contacted Tesla and it seems they have a new steering that come with manual horn in the middle but they would not replace it without charging $2000 for it or there is some defect like peeling on it. There are numerous online chats where people have got it replaced citing safety reason. In my view this should be under the recall especially when there is an option.

NHTSA ODI 11647021

The steering wheel doesn't comes with a horn. Meaning on a regular car, when you need the just press the airbag but in Tesla there a tiny button needs to press in order to get the horn which is impossible to do in case of an emergency.

NHTSA ODI 11645907

The horn doesn’t get activated when the center of the steering wheel is pressed. The horn button is on the right hand side on the wheel. It’s a safety hazard trying to find the button while driving especially in round abouts. In the place I live, there are couple of roundabouts; one car almost hit me since they didn’t yield to me when I was on the roundabout. I couldn’t find the horn button and had to hard brake.

NHTSA ODI 11633732

The steering wheel design includes a small button to engage the horn rather than a common practice of having the horn engage on center press of the wheel. In practice, this has turned out to be a significant safety issue and cause of confusion due to its in ability to effectively find the button or safely reach the button during safety concerns especially when the wheel is rotated since its general proximity is never consistent. Additionally, it is very close to other buttons which has caused it to accidentally be pressed and create confusion and anger with other drivers on the road.

NHTSA ODI 11632602

2023 model X is NOT equiped with a center steering wheel horn, instead a small button on the right of steering wheel which is nowhere to be found when you need in an emergency, i almost got in to 3 accidents for lack of horn. Tesla must replace these for traditional horn button

NHTSA ODI 11631748

I took an exit form the highway on [XXX] towards Bothell. As Soon as I did and ended up coasting towards the first red light, all the warning signs came on on the car and my steering wheel locked up. And my braking also got reduced. Only thing that worked was the Acceleration pedal. I struggled to get the car towards any safety. There was a message on the dashboard saying that assisted steering is reduced will require more power. however it was locked. I tried with all my might to steer the car in any direction but it would not budge. I was super scared I was going to be in an accident. With the limited braking as well I had to find a curb in the road to be able to safely park the car or a slope where the car could slow to a halt. Luckily I was able to do that and slowed down. on a curb like area and then I was able to turn on the parking brake. On contacting support they told me to reset the car and in doing so it should bring back functions. However, it did not. This was extremely dangerous and I was very lucky to get out of this alive without harming anyone else as well. Had this happened on the highway I was a sure goner. They had to finally get the car towed from there. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11627938

The horn button on the steering wheel is extremely dangerous. It is too hard to find it with my thumb in time, and has almost caused me to get into multiple accidents. When others cannot see me while yielding to traffic, I tried to honk and because there was no center haptic horn, I had to slam on the breaks. The horn should be in the center of the steering wheel. It is extremely unsafe as a tiny button because you cannot find it in time during an urgent traffic incident.

NHTSA ODI 11627057

The horn button on the steering wheel is not mechanical and is located outside of the center steering wheel location. This poses a serious risk to driving as the horn button is very difficult to reach when turning the steering wheel.

NHTSA ODI 11620223

After messaging Tesla due to noise and vibration, they reviewed the videos sent and preliminarily diagnosed the issue a control arm problem. They then stated that instead of having it assessed to determine the extent of the problem, that it was ok to drive and to wait 39 days in order for the problem to be assessed. I attempted to call Tesla they continually put me on hold for extended times up to 1 hour long without speaking to anyone. They state the manager call but none has called to follow up. I do not feel like driving with control arm issues is safe without having the car formally assessed. It is unclear why Tesla is pushing back on this. Waiting 39 days for this is unacceptable.

NHTSA ODI 11617549

The steering wheel horn is a small button on the side rather than on the middle of the steering wheel. Because of this, in an emergency where I was about to be hit in a T-bone vehicle accident, I tried to hit the horn to alert the other driver but was not successful in doing so. I find it dangerous to not have the horn available on the middle of the steering wheel, or at minimum a more easily accessible button.

NHTSA ODI 11617055

The horn placement on the steering wheel is on the side as a haptic touch button and not in the center of the steering wheel as an airbag horn switch, probably the only car and model with such button. It puts everyones safety at risk. If somebody is trying to make a bad merge into my lane and i have to honk in emergency , the hand by intuition goes to the center of steering wheel. Even if the hand goes to the side, because of emergency maneauver several buttons get pressed resulting in loss of precious time for me or the other driver to maneuver out of the lane, This happened with me today and i narrowly escaped the accident. This needs to be fixed ASAP before any bad thing happens with someone.

NHTSA ODI 11611168

My Tesla vehicle is equipped with a yoke (instead of a steering wheel), and a small button for the horn on it. Last week while making a (legal) u-turn, another vehicle suddenly entered my lane. I tried to honk the horn to alert the driver, but given the awkward position of the yoke (in the middle of the u-turn) and off-center placement of the horn button, my hands could not find the horn button and I was unable to honk the horn in time. I came a few inches away from hitting the vehicle and sustaining thousands of dollars in damages. The placement of the horn button on the yoke is a serious safety issue, especially in such situations. I would like Tesla to replace it with a standard steering wheel with a horn in the middle.

NHTSA ODI 11598343

In dense rush hour traffic at approximately 7:20pm EST [XXX], a bus started merging in my lane just on my side on [XXX] . The horn in the 2023 Tesla Model X is a tiny button located in proximity of the right hand scroll button on the wheel right spoke. It’s difficult to hit in an emergency and in attempt to signal the bus I probably hit the scroll wheel several times instead. Pressing the scroll wheel once activates the autopilot (“full self driving” in my case). The car shook and lurched likely due to the conflicting inputs of activating autopilot and braking (my guess) or for some other reason. The location of the horn as a tiny button on the steering wheel close to other buttons affecting the car steering response is extremely dangerous. I failed to signal the bus and I almost crashed my vehicle in confusion of the wheel shaking response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11596872

Hello, this is a complain for the placement of the horn on the 2023 Tesla Model X. The horn is a button on the side of the steering wheel and it is very hard to use especially when the wheel is turned. I almost got into an accident because I couldn't honk and alert the other driver in time.

NHTSA ODI 11596350

Safety hazard / concern over Horn Button on steering wheel as well as Turn Signal buttons. Not having a center horn has been challenging and dangerous as instinct is to press the center of the wheel and not look for the horn button in quick road hazard situations, merging traffic, etc.

NHTSA ODI 11596106

The horn is a small button on the steering wheel vs a large horn in the middle of the steering wheel. In an emergency situation the horn requires thought to press. Time is not something you have in an emergency.

NHTSA ODI 11596028

The horn is not mechanical and is not located in the center of the steering wheel. It is dangerous that it is a switch on the right side of the wheel. The horn is located next to the wiper switch and I have had multiple incidents where I could not initiate the horn and used the wipers. Tesla has a retrofit where they can put the horn in the middle and the newer models have it in the center of the wheel like traditional vehicles but are charging 2400+ for owners to get it corrected.

NHTSA ODI 11595808

2023 Model X Plaid. All stalks and physical horns have been removed. They are now capacitive buttons on the steering wheel that move with the wheel, are not raised to find easier, and are difficult to find in emergencies. I was nearly in a head-on collision and couldn't find the horn fast enough so I had to swerve excessively to avoid getting hit. The other driver didn't even know I was there. The 2024 model now has a physical horn, but Tesla refuses to swap out mine citing "upgrade paths" I have less than 2000km on this car.

NHTSA ODI 11595009

Honk as a button instead of at the center. Came close calls a few times where accident could have been avoided if I am able to honk within split second. I kept pressing center of the steering wheel. Safety Recall should be made. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11594709

Horn button is not in center of steering wheel. This makes sounding of the horn by a driver less accessible in an emergency or urgent situation to avoid a collision, accident, or pedestrian. Please request a recall for a standard center horn location I'm the steering wheel.

NHTSA ODI 11594710