What 412 owners told NHTSA about the 2023 Tesla Model 3 Bev

Power steering is intermittently and unpredictably failing. The issue has occurred approximately 10 times in total and has occurred both while exiting parking spots and while driving on the road. The vehicle is available for inspection upon request and has been given to Tesla Service Center for review. The service representative was not able to reproduce the issue and the vehicle was returned. Especially while driving, loss of power steering could force me into an accident, as I'm not able to control the vehicle in a reliable manner. When the issue occurs, I receive an error that says "steering assist reduced, steering may require increased effort."

NHTSA ODI 11544569

The contact owns a 2023 Tesla Model-3. The contact stated while driving at an undisclosed speed, the vehicle inadvertently drifted into the left and right lanes. The contact then stated that while attempting to make a left or right turn, there was a clicking sound in the steering wheel. The contact also stated that the steering wheel failed to align with the front wheels. As a result, the vehicle failed to drive straightforward. the contact was concerned for his safety while operating the vehicle. The vehicle was taken to the dealer where it was diagnosed that the steering rack failed and need to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,387.

NHTSA ODI 11544288

Loss of power steering. Car started normally, but with no warning from the car, the steering wheel could be turned only with extreme effort. I tried to make a circle around the house, but barely avoided hitting other parked cars and called Tesla service.

NHTSA ODI 11544368

I picked up a new Tesla Model 3 on July 29, 2023. On July 31, I received a steering reduced alert as I was backing out of my driveway and could not move the steering wheel. After I did a hard power off, the alert went away. I called Tesla service, and was told that this was not a typical issue but to schedule a service appointment and cancel if the issue did not recur before the next available date (Aug. 23). Two days later, on Aug. 3, I saw news articles about an NHTSA investigation into the same steering issue in 2023 Model 3s. I called Tesla service again, and now was told that they could not say that my car was safe to drive, and that there was no "official" response from the Company. I was directed to emergency assistance, which told me that the car was safe to drive at least to the Milford, CT service center, and noted that had I waited until Aug. 23, the alert would have been deleted from the system. I brought the car to the service center on Aug. 4. I was told that my steering rack needed to be replaced, and they gave me a loaner because the repair would take a few days. Soon after I drove back home (which is 30 min. away), I received notice saying that the service was complete. The service center did not give a coherent explanation for why they did not replace the steering rack and the correction codes did not line up. I told Tesla that I wanted to return the car, including bc it seemed like Tesla was trying not to perform an expensive repair they had listed themselves in their own documents with NHTSA scrutiny on this issue. I received no response, but was told by TD Bank that Tesla had agreed to a flat cancellation on my auto loan as of Aug. 9, with title to be reverted back to the dealership, and to discuss next steps with Tesla. I then contacted Tesla to return the car and obtain my deposit, and received no response. Then TD told me that Tesla reapplied for the loan on Aug. 22, without my consent. This whole ordeal has been a nightmare.

NHTSA ODI 11543949

Lots of power steering. Unable to move vehicle…extremely unsafe.

NHTSA ODI 11543323

The contact owns a 2023 Tesla Model 3. The contact stated that the vehicle failed to drive straight. While releasing the steering wheel, the vehicle would either veer to the left or the right. There were no warning lights illuminated. The vehicle was taken to the local dealer five times, where it was diagnosed that the vehicle was out of specification. The vehicle was not repaired. The contact was concerned about a possible crash due to the failure. The manufacturer was contacted, but no assistance was provided for over thirty days. The failure mileage was approximately 12.

NHTSA ODI 11542837

Steering wheel could not turn after after parked and tried to drive again. Car could only go straight forward or backward. Also tried to restart the whole car computer, problem still persisted. The car screen displayed error message UI_a020 Steering assist reduced, Steering may require increased effort.

NHTSA ODI 11542213

Steering wheel locked up while operating not allowing me to turn the wheel. Loss of power steering and control. Screen displaying error "Steering assist reduced" when in reality was completely unable to steer. Vehicle still powered and accelerated however no control over steering.

NHTSA ODI 11540339

Steering wheel got jammed while driving on highway. Stopped vehicle on rode side and called for Tesla road side assistance. Tesla towed my vehicle and replaced steering rack. Invoice attached for details

NHTSA ODI 11540002

Car lost power steering without warning

NHTSA ODI 11540124

While driving yesterday night, I lost steering control. I stopped the car in the middle of the street and tried again but the steering wheel was very stiff. It took so much effort to change the lane and find a safe place to park. It was a scary moment for myself and my 2 kids. I was about to crash into other cars. A message appeared “ui_a020 - steering assist reduced”.

NHTSA ODI 11539692

I was driving and the power steering stopped functioning. The car had just over 1000 miles and both the lane departure avoidance and steering assistance cut out. Restarting the start would bring it back on temporarily but it would cut out again after a minute or two.

NHTSA ODI 11539670

The contact owns a 2023 Tesla Model 3. The contact stated while driving at various speeds, the steering wheel seized, and excessive force was required to steer the vehicle to the left. The "Steering Assist Reduced - Steering Require Increased Effort” message was displayed on the contact's smart phone, but not on the radio home screen. The contact sent a message to Tesla through the app; however, the contact had not yet received a response. The vehicle was not diagnosed or repaired. The failure mileage was 4,369.

NHTSA ODI 11539205

The contact owns a 2023 Tesla Model 3. The contact stated while driving at an undisclosed speed and making a right turn, the steering wheel became firm with the message “Automatic Steering Unavailable” displayed. The vehicle was towed to the dealer, but the vehicle was not diagnosed. The manufacturer was contacted and provided towing service to tow the vehicle to the dealer. The vehicle was not repaired. The failure mileage was 1,859.

NHTSA ODI 11538756

After charging my car at a charging center, the steering assist reduced message appeared on the screen. Then the power steering gave out and i couldn't turn the steering wheel. I had to get the car towed to a service center.

NHTSA ODI 11538329

While traveling on a busy interstate highway, my Tesla 3 presented four errors on the control screen: Automatic Emergency Braking disabled, Power reduced, Vehicle shutting down and Unable to drive. The left hand side of the screen flashed red and instructed me to pull over safely. The car was immediately slowing down, and as I was in heavy traffic, I was unable to pull over to the shoulder safely. I turned on my hazard lights and performed a soft reset of the car - which caused my hazard lights to turn off, all while cars were honking and whizzing around me. After the car reset, I was able to drive a short distance, with enough speed, to cross several lanes of traffic and come to a stop on the shoulder emergency lane of an exit ramp. The car is only 6 months old, with 4000 miles, but had to be towed to the Tesla service center. The problem has been diagnosed as a problem with the rear drive unit inverter and will be replaced under warranty. While I appreciate the resolution and that it will be fixed, it could have been a very serious situation and caused an accident. Thankfully, I was able to get to safety and wait to be towed.

NHTSA ODI 11537656

I took delivery of a Tesla Model 3 on July 7. On July 18, I received a digital message indicating that the software needed to be updated, and I complied. Later, when I got into the car to drive it, I got two error messages -- one indicating that the driver-assist steering might not work and the other relating to warning of approaching vehicles. I drove the car about 50 feet before realizing that I had no power steering and would not be able to control the car. Using all my weight to turn the steering wheel, I managed to pull over to the righthand shoulder of my street, where I left the car. A few hours later, I tried to drive the car again, and the problem had resolved itself. But I was nervous about driving it without an assurance from Tesla that it would not happen again, especially wile driving it, so I reported it to Tesla. Tesla's "remote team" did an analysis and reported six days later: "After reviewing your concern we have concluded that it can be chalked down to a known firmware issue that appears during the first start after completing the most recent update and goes away after leaving the vehicle and coming back. We are seeing no further issues with the steering assist, and no repair is needed at this time." Meanwhile, I had not driven my new car for six days out of concern that the steering wheel could freeze up while driving. When I search online, I found many, many reports from drivers about this problem, some of whom said they'd had to have their whole steering column replaced. I read this week that NHTSA had opened an inquiry, so I am submitting my experience so you can see the problem is not limited to 12 vehicles. Also, I suggest you do a Google search to amass more evidence of how common it is.

NHTSA ODI 11537287

On May 22, 2023 I had an annual physical exam at the doctor's office at 9:00 am. Upon completion of the visit, I drove my model 3 from the parking spot (3rd level) towards the ground floor. At the final turn, at the ground floor, I felt that the car had an unusual resistance when I tried to navigate the turn. The steering wheel felt as if it were locked. As a result of not being able to turn the steering wheel, I hit seven cars that were parked at the ground floor and incurred substantial damage. The car is totaled unfortunately. I am hoping that the NHTSA may have a way to analyze the true cause of this accident before they send the car to the salvage market.

NHTSA ODI 11536744

2023 Tesla Model 3 with 3,000 miles. No accidents or impact with potholes or curbs. Started vehicle, put in drive, pressed accelerator, car went forward but would not turn. Steering wheel was stuck in straight position. I stopped the vehicle and put it in park, same symptom of stuck steering wheel. My wife (passenger) and I did not notice any error lights or messages. I exited the vehicle walked away to trigger automatic locking. Returned to the vehicle, started it , and tested steering. Steering was free. Took approximately 5 mile test drive. Steering was erratic, making small movements to the left and right. At times it felt the car would veer offroad or into oncoming traffic. Contacted support. Dealer dispached tow truck to return vehicle for inspection. Was informed by dealer that no loaner vehicles are available, they only offered Uber credits.

NHTSA ODI 11536750

Steering wheel stuck in straight position, unable to turn. Also, A/C line supermanifold defect present, needed to be replaced. Steering rack and harness both needed to be replaced. Tesla model 3, only had 40 miles before needing to be towed.

NHTSA ODI 11536715

The contact owns a 2023 Tesla Model 3. The contact stated that while decelerating to make a right turn, the steering wheel became difficult to maneuver as the lane shift avoidance reduced, and power steering assist reduced warning messages displayed. The contact stated that she pulled into a parking lot and parked the vehicle and after 20 minutes restarted the vehicle and resumed to normal functions. The manufacturer Tesla was contacted and advised her to reboot the computer as well as make an appointment with the Tesla service center. The computer was rebooted however several days later while making a left turn the steering wheel was difficult to maneuver with no warning messages displayed. The vehicle was towed to the dealer and the power steering rack was replaced. The failure reoccurred for a third time on July 7th while she was making a right turn with the message displayed steering assist reduced. The vehicle was towed back to the dealer where they replaced the steering rack and updated firmware however the failure reoccurred. The vehicle was towed back to the dealer they diagnosed the failure as a power steering harness that was replaced. The contact was relating the failure to a NHTSA Action Number: PE23014 (Steering) The failure mileage was 480.

NHTSA ODI 11536526

The contact owns a 2023 Tesla Model 3. The contact stated that while attempting to make a left turn, the vehicle experienced gradual loss of power steering assist. The contact veered to the side of the road and contacted roadside assistance. The contact turned off and restarted the vehicle, and the steering wheel responded as needed; however, the contact stated that the failure had been reoccurring while driving. The power steering assist warning light was illuminated. The manufacturer was notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was 834.

NHTSA ODI 11536260

Car started pulling to the right after leaving the parking lot and vehicle warning stating Steering assist reduced. I pulled over to see the left wheel was turned in while the right wheel was straight ahead. Towed to nearest Tesla service center where they stated the steering rack failed and would require a complete replacement. I was told this was not a warranty issue and I must have hit something. I protested stating there was nothing abnormal about the drive. Took to the nearest certified bodyshop where the steering rack and front control arm were replaced.

NHTSA ODI 11536042

On 7/21/2023, I received an alert saying “steering assist reduced”. I could not turn the steering wheel. Luckily I was parked and trying to back out of my spot. The steering assist came back after getting in and out of the vehicle. Contacted Tesla about this and they told me to monitor the situation. I took delivery of my vehicle 7/20/2023 around 3pm EST. So I had the car less than 24hrs.

NHTSA ODI 11535708

Steering rack failed. Not able to steer vehicle The consumer stated that the vehicle was repaired.

NHTSA ODI 11535760