What 64 owners told NHTSA about the 2023 Ram Promaster

The vehicle experienced a thermal event that was caused by a defective fan motor. The vehicle has been inspected by stellantis and a third party investigator. Report attached

NHTSA ODI 11741579

On December 23, 2025, a 2023 RAM ProMaster 2500 Van used as a commercial fleet delivery vehicle in [XXX] suffered an engine compartment fire. The vehicle was declared a total loss by the insurance carrier. At the time of the fire, the vehicle was subject to open Safety Recall 25V-720 / Manufacturer Recall 67C, issued by FCA US LLC for a defective cooling fan module with premature bearing wear and inadequate fuse protection on the 400W fan circuit — the exact defect identified as a known fire risk. No remedy was available at the time of the incident. The interim recall notification letter had been received but the vehicle could not be repaired as FCA had not yet developed or made available a fix. The vehicle was inspected by insurance representatives and declared a total loss. No warning lamps or prior symptoms were observed before the fire occurred, consistent with NHTSA's own warning that affected vehicles may fail suddenly with no prior dashboard alert. The component believed to have failed is the cooling fan module. It is unknown whether the component remains available for inspection as the vehicle has been transferred to the insurance carrier as part of the total loss settlement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11728539

12v DC outlet caught fire

NHTSA ODI 11722552

The contact owned a 2023 Ram Promaster 2500. The contact stated that the employee had reported that the front end of the vehicle had caught on fire immediately after parking the vehicle. The vehicle was unoccupied at the time of the incident. The fire was extinguished by the fire department, which reported that the fire originated from the front end of the vehicle. There was no injury sustained. The contact stated that the front end of the vehicle had completely burned. The contact stated that the fire seemed to have originated near the engine compartment. The vehicle was towed to the residence and was totaled. No police report was filed. The dealer and the manufacturer were notified of the failure. The manufacturer informed the contact that they were not liable for the failure. The failure mileage was approximately 30,000.

NHTSA ODI 11696578