What 199 owners told NHTSA about the 2023 Hyundai Santa Fe

The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving and decelerating to approximately 10 MPH onto an exit ramp, the vehicle suddenly stalled and failed to restart. The contact noticed that there was blue smoke coming from the exhaust pipes, and several unknown warning lights and messages illuminated, including the Check Engine warning light. The vehicle was towed to the local dealer, who diagnosed that a fuel injector had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 35,652.

NHTSA ODI 11742763

On March 4, 2026, at approximately 7:30 AM EST, while driving my 2023 Hyundai Santa Fe Limited on [XXX] , the vehicle experienced a sudden loss of propulsion while traveling at approximately 70 mph (posted speed limit). The vehicle would not accelerate or maintain speed and would not move forward when placed in drive, indicating a failure within the powertrain/transmission system. The vehicle is currently located at a Hyundai dealership and is available for inspection upon request. This incident created a significant safety risk, as I was traveling at highway speed in active traffic when the vehicle unexpectedly lost the ability to move under its own power. This placed me at risk of being rear-ended and made it difficult to safely maneuver out of traffic. The vehicle was inspected by a Hyundai dealership. Diagnostic trouble code P284001 (Shift Fork “D” Position) was identified, and I was informed the failure is transmission-related. The condition was reproduced by placing the vehicle in drive, at which point the vehicle would not move. The vehicle has been inspected by the dealership. The manufacturer has been notified but has not physically inspected the vehicle. No police or insurance inspection was involved. There were no warning lights, messages, or prior symptoms before the failure. The issue occurred suddenly without any indication of a problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11728065

While driving on the interstate at 70mph the vehicle’s fuel injectors failed causing the vehicle to lose power suddenly.

NHTSA ODI 11724503

Fuel injectors are bad. The car misfires, I smell gas, runs rough. They fixed one the second week of December 2025. I had the same symptoms when my light came on again on December 23,2025, they said they couldn’t find anything and gave me the car back. On January 3, my engine light came on again, I had warnings sent to my email and phone app about potential engine failures they said today ( 1/6/26) that it was another fuel injector and was told they would not replace the rest until they went out. When I asked them how safe I would be on an upcoming trip, I was told to just check the car every day before I go!

NHTSA ODI 11709104

From a complete stop when pressing the accelerator, the vehicle does nothing. This can last 1 second or in longer episodes it can last 4-5 seconds. No lights on the dash. It’s random and happens sporadically. But when it’s bad, you have enough lag to count to 5 and turn on the hazards

NHTSA ODI 11678655

At 22000 miles wheel speed sensor went out, all control system shut down and car became unstable. At 44000 miles fuel injector went out, was driving on freeway and car started shaking and losing power, then in parking lot would not start at all, had to be towed to dealer. This is way to many breakdowns for a car with such low mileage.

NHTSA ODI 11678488

The accelerator stuck and the vehicle crashed. The vehicle is totaled. It happened [XXX]. No one has yet inspected the vehicle. I notified Hyundai about 5 days ago. The phone number of the towing company is 516 433 1011. The following link is a YouTube video of the accident: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11644603

First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.

NHTSA ODI 11628751

There is an extreme amount of hesitation/delay from when you depress the accelerator and when the vehicle accelerates. I have had multiple incidences (both from a complete stop and while already moving) where I depress the accelerator and there is a concerning amount of lag time before the vehicle initiates movement. This has almost led to multiple accidents. This defect happens in all drive modes. This issue appears to have gotten worse over the time we have owned the vehicle. We did not notice this issue earlier on. We bought the vehicle brand new in Dec. 23.

NHTSA ODI 11599523

Several times lately of extended crank. Saturday evening, car had been parked for 4 hours, did remote start and had extended crank of about 2 seconds. Car ran for about 3 minutes before we left. We left home and hit main road, tried to accelerate and vehicle seemed to go into limp mode. Would keep cutting the fuel out if tried to accelerate even above 40 mph. No check engine light came on. Put in neutral, could not get above about 3500 rpm. Vehicle was in smart mode where decides which mode to be in (normal, fuel economy or sport), when would try to accelerate it would try to change to sport as it knew power was not there. Was on a 6 lane highway and could not get up to speed. Finally was able to pull to side of road, shut engine off, waited a few seconds, restarted and issue went away, still no check engine light. I have contacted my local dealer, they said they have seen on another vehicle, was not sure of outcome, having service manager call me. Lots of complaints online forums of similar issues.

NHTSA ODI 11596090

Stopped at left turn lane light. Light turns green and vehicle engine revolutions increase as I press on gas pedal but car does not move. Cars behind me lean on their horns and take evasive maneuvers to go around me. Car finally goes very slowly and transmission disengages in middle of left turn leaving vehicle in middle of intersection with oncoming traffic. Luckily everyone stopped and vehicle very slowly moved through the intersection to side of road. Vehicle is brand new and in my possession less than 48 hours. Vehicle is at dealership for troubleshooting.

NHTSA ODI 11517742