May 20, 2025Fuel system
During driving, vehicle displayed a system error indicating an issue with the hybrid system. The vehicle then immediately, and without warning, completely shut off and caused the driver to have to manually guide the vehicle to the side of the road without power assistance. The vehicle is available for inspection upon request, however we have taken it to the dealership who have inspected the vehicle but told us they could not find an issue, even though we clearly experienced on. The incident can easily be verified by our insurance company, who had to tow the vehicle. This incident put our safety at risk as it not only caused a sudden vehicle failure which could have further risked accident, but the driver also suffered heat stroke waiting for the tow truck. As stated earlier, the service center at the dealership could not reproduce or confirm the issue and have simply stated that the vehicle should just be driven as is. The vehicle has not been inspected by the manufacturer, police, or insurance representatives. I'd like to further note that this service station and dealership is called Horne Hyundai and is located in Apache Junction, Arizona. They have ignored this issue, gaslighted us, and left us with no option but to report them and this vehicle.
NHTSA ODI 11662138
Jun 21, 2024Transmission & drivetrainElectrical systemFuel system
I experienced an issue where I was driving the vehicle, and then a "hybrid system fault" message appeared on the driver information display followed by the complete loss of power. This made me have to pull over to the side of the road with no ability to accelerate out of the way of traffic to come to a stop. Once I was stopped I tuned off the vehicle and tried to turn it back on, but the vehicle would not respond so I attempted pressing the 12 volt battery reset button to the left of the steering wheel to see if this would allow me to turn the vehicle on and the car came back to life with no warning lights or messages and drove normally. This happened three more times over the course of ~1.5 hrs on my way home on the highway. I understand that things happen, I just wish there was more warning before all power was cut and the vehicle went into limp mode as this left me in a dangerous situation. The vehicle has been dropped off at the dealer and is awaiting a new hybrid battery replacement under warranty.
NHTSA ODI 11595769
Sep 5, 2023Electrical systemSpeed controlFuel system
I turned on Cruise Control at 60 mph and it immediately set itself to 20 mph, braking fast to slow down quickly. This caused the car behind me to slam on his brakes so he would not rear end me. I tried increasing cruise control speed to no avail. I had to turn it off. Once I did not have any cars behind me, I tried once again so I could take a video and of course, it worked as it should. Not five minutes later, my radio turned the volume down to zero, all by itself. 20 minutes later, when I slowed to turn into a parking lot, my car lagged and acted as if it didn't have gas enough to go up a small incline. Pressing on the gas pedal didn't do very much but I made it up the incline and was able to park. I will be calling Hyundai Dealership tomorrow where I purchased the vehicle last year. I do not have any type of pictures or recordings as it just happened and it was a pretty scary event considering I was almost rear ended.
NHTSA ODI 11542784