What 73 owners told NHTSA about the 2023 Ford Maverick Hev Hev

AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11702611

Vehicle stopped accelerating while doing an U turn with oncoming traffic. Had to pull over because the vehicle would not move.

NHTSA ODI 11692037

Started Vehicle, pulled out of a parking spot and I slowly approached an intersection, the engine accelerated at a high rpm/rate without touching the gas pedal, I immediately firmly applied brakes, the card was jerking and shaking hard working against brakes, I immediately turned car off. It could have easily ran into a car or person, being that I was on a city street with pedestrians crossing and car traffic. When I restarted, it did not want to move at all. I then restarted it a second time and it drove normal. No lights or warnings appeared. It was at Ford dealer getting all recalls repaired about 2 weeks ago and were completed to my knowledge. This just happened today [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11641224

I was driving on a divided secondary road and my truck when into reduced power mode, displaying " Powertrain malfunction/Reduced power, engine service soon, and precollision assistance not available". This ended up slowing me rapidly from 55 down to under 30 +/- MPH. When it was necessary to stop at a light and I took my foot off the accelerator, the truck did not immediately slow but actually surged forward. After 'crawling' home, I had it flat-bedded to a dealership that day, and it took them almost 2 weeks and multiple test drives to tell me that that cannot recreate this issue. I was told by the service advisor that there was an issue and that could see it in the vehicles history. I went to the dealership and asked them how long they would keep testing it if they were not able to replicate the problems. They said 'it was up to me'. I took the vehicle home. We only had it for a day and less than 100 miles of driving and the problem occurred again, after dark, on a busy road in an intersection and the truck would not move at all for a few tense moments. The gear selector dial flashed repeatedly and the parking brake came on by itself. We had the truck flat-bedded back to the dealership the next day and it will stay there until the solution is found to eliminate this dangerous and life-threatening operational fault. The second incident occurred on March 26. Service to address 2 recalls was done on the vehicle on March 6.

NHTSA ODI 11580087