What 454 owners told NHTSA about the 2022 Subaru Outback Wilderness

I opened the trunk door went to retrieve my groceries and the trunk door came down with extreme force on the top of my head without warning hitting me in the head causing a concussion. The window sensors on the driver and passenger doors also were acting off prior. Not every time but I would try to close the window and it would go up half way and then come back down.

NHTSA ODI 11699581

Driving on the highway, engine started making a rattling noise, then began to labor and eventually stopped being able to accelerate at all. Oil pressure warning light came on around the time the acceleration gave out altogether. We pulled over to the side of the highway and got out of the car, seeing steam/white smoke coming out of the front of the car. The smoke increased and after several minutes, the front of the car caught on fire.

NHTSA ODI 11695698

This is in response to your boilerplate letter of May 25, 2024. That correspondence stated that my 2022 Subaru Outback’s inspection of May 21, 2024, did not reveal any manufacturing defect that caused the unanticipated acceleration of my vehicle on April 26, 2024. That inspection was conducted by a third-party engineering firm. In amplification of this, the following is provided: • My vehicle on 26 April 2024, at approximately at 0845 AM experienced unanticipated acceleration, in my garage where it had been parked overnight. It was a cool morning. This occurred without any direct body movement from me, whatsoever. The fast forward motion I directly experienced in my vehicle was like if one put their gas pedal to the floor. The vehicle crashed about five feet into a garage shelf with me simultaneously providing braking. This directly caused about $3,000 worth of damage to the vehicle, and I will probably incur higher insurance cost because of this. •Environmental factors have been a contributing factor in unanticipated acceleration in the past. •Time to extract the data from the EDR in my vehicle took almost one month for SOA to complete the inspection (accident occurred on April 26 and the vehicle inspection took place on May 21). •Starlink, Subaru’s automatic collision notification system, did not activate on 26 April 2024, the day of the accident. •“As a rule of thumb, if the crash is sufficient to cause the air bags to deploy the EDR data are usually captured.” From the National Highway Transportation Safety Board’s website under, “EDR Q & A). My vehicle’s air bags did not deploy, and another key word is “usually”. •On May 16, 2024, five days before the inspection was completed on my vehicle I wrote the CEO a letter. Part of that letter is quoted, verbatim, for your review: “It is now my understanding, according to SOA, that what happened to me is referred to as unanticipated acceleration. Being a Subaru owner for over ten years, such in inc

NHTSA ODI 11592278

My brakes failed as I was pulling up to a curb as I attempted to break to put my car into park my breaks failed to engage. My vehicle is also equipped with emergency braking system that did not engage my vehicle crashed into and through a 7/11 while I was breaking the entire time manuall! The vehicle would not stop and did not stop until it hit the back wall of the store inside.

NHTSA ODI 11581016

The contact owned a 2022 Subaru Outback. The contact stated that while his wife was driving at 30 MPH, she heard an abnormal sound emanating from the front of the vehicle, and the vehicle suddenly lost all electrical power. She was able to coast to the shoulder of the roadway, where the vehicle failed to restart. A short time later, the contact's wife observed white smoke rising from the engine compartment, and within 15 minutes, the entire vehicle was engulfed in flames. Local emergency services were called and were able to extinguish the fire. A fire and police report were filed, and no injuries were reported. No warning lights were illuminated. The vehicle was towed to a tow yard, awaiting inspection. The manufacturer was not notified of the failure. The failure mileage was 23,000.

NHTSA ODI 11553800

The contact owns a 2022 Subaru Outback. The contact stated while pulling into a bumpy parking space, the vehicle shuddered violently, unintendedly accelerated, and crashed into a stone wall. As a result, the hood of the vehicle was bent and the bumpers were damaged. The air bags did not deploy. The contact did not sustain any injuries. The contact was able to drive to an unknown dealer, where the vehicle was inspected, but the cause of the failure could not be determined. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they would follow up in two business days. The failure mileage was 13,947.

NHTSA ODI 11553407

Pulled into a parking space at the Village Green strip mall, applied brakes and immediately, the engine accelerated and lunged my vehicle into another car that was parked in the parking space in front of my car. When the car accelerated, the brakes did not work. I reversed the car since it continued to accelerate into the parked car in front of me and the car went back as fast as it was accelerating forward. I put the car into drive since I had parked cars behind me as well. The car accelerated forward at a very high rate, I did not have brakes, I guided the car between parked cars as best I could but could not make a left turn and the car drove into a brick building in the strip mall. I opened a claim with Subaru Corp, Case #230508-190-1112.

NHTSA ODI 11522566

The contact owns a 2022 Subaru Outback. The contact stated he had taken the vehicle to the dealer for standard maintenance. When parked, the contact noticed that smoke was coming from underneath the vehicle. A loud popping noise occurred then a fire started underneath the hood of the vehicle. The fire quickly spread. The fire department extinguished the fire. There was no damage. There were no injuries and medical attention was not needed. A fire/police report was filed. The vehicle was towed and is with insurance waiting for the condition of the vehicle to be determined. The vehicle had not been officially diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 4,260.

NHTSA ODI 11517827

The contact owns a 2022 Subaru Outback. The contact stated that while reversing out of his garage, the vehicle made an abnormal sound, and while the transmission was shifted into reverse (R), the vehicle rapidly accelerated, crashing into a tree. The contact stated the vehicle made the abnormal sound again and rapidly accelerated forward, crashing into a fence. The contact sustained injuries to his head and received medical attention. A police report was filed. The vehicle was towed to a collision center. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,000. The VIN was not available. The contact stated the vehicle changed gears and right foot wasn't close to the accelerator during the crash. Medical attention was not required because the head injury was not severe.

NHTSA ODI 11510958

The contact owns a 2022 Subaru Outback. The contact stated that while driving approximately 1 to 2 mph on two occasions into a parking spot, the vehicle hesitated then accelerated and crashed into a pole. There were no warning lights illuminated. There were no reported injuries, air bag deployment, or fire. A police report was filed. The vehicle was taken to a collision shop. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was contacted and had an investigator inspect the vehicle but was unable to duplicate the failure. The failure mileage was approximately 700. The VIN was not available.

NHTSA ODI 11507870

Main Wiring harness / Main Electrical system malfunction, causing all dash lights to consistently be on. which in turn prevents all of the ADAS functions to no longer work. Vehicle has now been in 2 accidents which could have been prevented by these safety features. vehicle had had main harness replaced at dealers cost at dealership , and one at cost of insurance, problem remains unfixed/unfixable. vehicle is specifically 2022 Subaru outback Onxy XT.

NHTSA ODI 11498979

My wife was driving and was involved in traffic accident when the airbags deployed. She is a small person and has the driver's seat pulled all the way forward so she operate the vehicle. I was concern about her seating so close the steering wheel and the airbag, but told by the dealer personnel that airbags where mandatory and any tampering voids warranty, etc. She was in an accident and the airbag deployed, she suffered substantial injuries to her upper body including fractures of the clavicule, breastbone, numerous ribs and her T12. Doctors said it was almost miraculous she survived. The is significant data available on the impact of airbags. The forces expended and the bodily damages that can occur. It must be known the a body so close to the activation of the airbag could have fatal consequence but so little has been made public about this danger. We've heard about devices exploding and causing injuries and fatalities but from sitting so close to the steering wheel. And a simple fix, if the seat is fully forward, the airbag is deactivated or test to find a place where it would not be a dangerous weapon. To be injured severely or even killed by safety equipment is the height of stupidity especially when it worked as designed.

NHTSA ODI 11467723

My wife who is a small statured woman was leaving parking lot of church onto a narrow 2 lane street. As she made a left turn, the right front tire climbed the curb and dropped back onto the street. The car suddenly accelerated to top speed and crushed into a tree about 50 yards down the street. Airbags deployed causing bone breaks in left cavalcule, fractured ribs and T12. The driver is short and must sit almost against the steering wheel to drive. Without much effort to stretch her toes, she is unable to push the accelerator to the floor. she said she tried to push on the brake with no results. Eyewitnesses said they watch as she was leaving, they noted the car "jumping the curb" and said the car suddenly accelerated to a very high speed and crashed into a tree. There were no distinctive marks to show any stopping action.

NHTSA ODI 11467603

(ADAS) R WAVE RADAR SENSOR/BLIND SPOT WARNING SENSOR. NO WARNING FOR THE STATIONARY OBJECT (TREE) BEHIND MY VEHICLE CAUSING A COLLISION. A REPORT WILL BE MADE TO THE SUBARU DEALERSHIP ONCE THE VEHICLE IS REPAIRED BY THE COLLISION CENTER. INSURANCE ADJUSTERS HAVE REVIEWED. NO WARNING LIGHTS, OR ANY SIGNS OF ANY ISSUE UNTIL THE BLIND SPOT SENSOR FAILED TO PROPERLY WARN ME OF THE STATIONARY OBJECT.

NHTSA ODI 11433231

Vehicle was purhased in early June 2021. Vehicle was being operated on State Highway Route 55 at Milepost 46.7, in Elk Township, Gloucester County. Traffic was heavy, with southbound transient traffic traveling to New Jersey Shore points. Vehicle simultaneously lost power and began to display several error/warning messages on dashboard at approximately 13:52 hours. Vehicle was pulled to the right shoulder of the roadway and I began to smell something burning. As I removed personal effects from vehicle I exited and saw smoke coming from the passenger's side wheel well. I walked back approximately 100 feet and called 911, by time a dispatcher came answered, the engine compartment of the vehicle was completely engulfed in flames. No modifications of any kind were done to the vehicle since its purchase. I was the sole occupant of the vehicle and not injured. The vehicle is fully insured and payments are current. It's mileage at the time of the incident are 3,042. That information along with the error messages were provided through the Subaru Starlink App.

NHTSA ODI 11424796