What 208 owners told NHTSA about the 2022 Mitsubishi Outlander Mhev

When i drive on the interstate i noticed my hood shaking and seems like its going to fly open.

NHTSA ODI 11737728

The seat belts are much slower to retract than with other cars, including our 2019 Mitsubishi Outlander we also own. My wife has had the front passenger seat belt get stuck in the door at least 3 times (likely more) which has required us to make multiple stops at the dealership to fix it. This is certainly a safety risk since the door remains partially open this certainly is something that should be recalled and fixed. Most recent day was today 5/7/26 but has happened many times.

NHTSA ODI 11736452

Good flutter at speeds above 45 mph or high winds. NTSB issued but not notified, recall should be issued as this is a safety concern, called dealer who stated a tsb was issued but I was not notified. Due to being out of manufacture warranty I will have to pay cost of hood replacement. Mitsubishi is not responding to my outreach. I first notified dealer of concern after purchase and was not informed of tsb, I was told it was safe and a design flaw.

NHTSA ODI 11734989

The contact owns a 2022 Mitsubishi Outlander. The contact stated that while driving approximately 65-70 MPH, the hood fluttered abnormally. The vehicle was taken to the dealer twice, and the dealer test-drove the vehicle and recorded a video of the failure for the manufacturer. The contact was informed that there was no repair available at that time. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the hood was reinforced. The failure mileage was approximately 39,065.

NHTSA ODI 11729906

The hood bounces and flutters. It is especially bad driving on the interstate. It is so much that I am scared to drive it.

NHTSA ODI 11726195

This model of vehicle (2022) has a known hood flutter that cannot be repaired. It's possible the hood latch could fail and the hood will fly up/open while the vehicle is in motion. My vehicle registration acknowledges a recall but it is not for the hood flutter. I've done research and it is identified on the internet that dealerships know this hood issue exist.

NHTSA ODI 11707403

When opertaing vehicle it my parking sensor error message was given giving false reading. I was told because of this scratch i need to replace the sensor. I think its a bad design flaw n there are charging me 800 in parts and labor even though its under warranty This can cause false reading and some one can get hurt

NHTSA ODI 11638884

There is currently a service bulletin out for the hood to be replaced because it flutters on the highway, I purchased the vehicle pre owned at 61,000 miles, Mitsubishi won’t cover the repair because it’s over 60,000 miles, I feel like this is a safety concern as the hood flutters on the highway and I have 2 small children in the car most of the time one is an infant , they are trying to charge me $3,045 for the repair when it was the fault of Mitsubishi. I purchased the car preowned from Chrysler dodge jeep ram at 61,000 miles and there service department told me several times it’s normal and it’s fine, I finally brought it to a Mitsubishi service center and they told me about the issue. This should not have a warranty to be covered for repair it should be a recall , I’m worries the hood will pop open on the highway .

NHTSA ODI 11617660

I am writing to express my dissatisfaction with the 2022 Mitsubishi Outlander that I financed through your bank. Since purchasing the vehicle brand new in 2022, I have encountered numerous issues that have caused significant inconvenience and concern for my safety. In the past two years, my vehicle has experienced multiple problems, including: 1.Randomly Shutting Off: Last year, my car began randomly shutting off. The dealership attributed this to sensor issues and claimed it was due to me pumping gas while the car was on. Despite this explanation, the problem persisted, and the mechanic only reset the computer system without fixing the underlying issue. 2.Fuel Pump Issues: Recently, on August 11, 2024, my car stopped working for several hours while I was with my daughter. I replaced the battery at a cost of $300, but the problem recurred the next day in traffic. After extensive delays and towing, the dealership identified a fuel pump issue, which is covered under the powertrain warranty but not the connecting parts, costing $1500 each. 3.Safety Recalls: I discovered that the 2022 Mitsubishi Outlander has several recalls related to faulty fuel pump wiring. Although I was initially told my model was not affected, the dealership later confirmed the fuel pump issue. Additionally, the hood of my vehicle was not welded correctly, causing it to flutter and posing a safety hazard. Despite bringing my car to the dealership last year under the original warranty, no effective repairs were made. I have been without a reliable vehicle and have faced significant inconvenience and safety concerns. Given these ongoing issues and the lack of resolution, I am requesting a voluntary repossession of the vehicle. I believe this is the only viable option given the circumstances.

NHTSA ODI 11610186

On a windy day or a regular day once the car get to about 45 mph or higher the hood begins to flap, bounce, vibrant as if it is going to fly open. As if the wind is getting under and getting ready to take it away.

NHTSA ODI 11582697

The hood has fluttered since I bought the car on 7/29/21. I brought the issue to the dealership's attention, but they denied hearing any other complaints. While I was waiting at the dealership for an oil change, I was talking to other outlander owners, and they expressed the same concern. I also have an issue with the front Collison senor. Since day one, the sensor will disengage in direct sunlight, fog, and rain, making the feature useless. Once again, when brought up to the dealership, I was informed the case this was a one-off and they had not heard or seen any issues reported to Mitsubishi. And as of today, it appears my alternator has gone out.

NHTSA ODI 11562493

Since May 2023, I've been to two different dealerships with the same issue. It started with a whistling sound form air vents, buring smell, increased has consumption, loss of power going up hill, gas smell inside cabin, no air, loud noise from right side of car under hood, and engine malfunction warning. Finally, 12/12/23 the car, without warning, instantly stalled, shut-off in traffic. Several vehicles behind me had to swerve to avoid rear end collision at it was it happened in front of a school with heavy traffic! The car would not restart and had to be towed to dealership. I contacted Mitsubishi corporate office in Aug/Sept, and was assigned Bernedette, who, constantly confused and incoherent, dismissed my complaints as dealerships wouldn't fix bc Mitsubishi wouldn't reimburse. She stated if there was no code, the car could NOT be fixed! In total, both dealerships have had my car for 30 days or more. Currently, Edwards Mitsubishi, has had my car since 12/11 as back ordered part was hard to obtain. I want to go to mediation for Lemon Law in IA, as this car poses a serious threat to myself and other drivers. Mitsubishi is negligent and duplicitous by issuing erroneous and loose guidelines regarding repairs/recalls when vehicles owners present with problems known to Mitsubishi, especially 2022 Outlanders having fuel pump issues. I still can not get any assistance on the shaking hood!!!!

NHTSA ODI 11562265

While driving the 2022 Mitsubishi Outlander at highway speeds the front hood flutters very badly. Causing myself stress that the hood will fly open causing a very concerning safety problem or accident.

NHTSA ODI 11541140

The hood flutters and bounces up and down the entire time I'm driving making me too anxious to drive the car at all. I just bought the car used with 21,000 miles yesterday and noticed it after leaving the dealership to drive home. I have an appt for weatherstripping on 7/24.

NHTSA ODI 11533365

Purchase 2022 Mitsubishi Outlander fall of 2021. Took first trip of over 200 miles on Highway. Noticed that speeds of 60 MPH or over, the hood vibrates(badly). Took to local dealership was told Mitsubishi aware of issue, and in the works to correct, and most likely recall to replace hoods. Just took in this week June 2023 to local dealership. Asked again about Hood issue. This time was told Mitsubishi not aware and no fix available or in the works. My concern is I travel a lot on major highways at over 60 MPH. What happens if hood flys up when driving 60 MPH. The hood would fly back break windshield, cause Death or serious accident. And that worries my wife and me. Dealership hasn't done anytime to ease my concerns

NHTSA ODI 11528528

Hood flutters badly when passing oncoming traffic. Specifically trucks. Sometimes it blows up about an inch or more and I fear it will come loose and open eventually.

NHTSA ODI 11524753

The hood of the vehicle flutters when the car reaches 65 mph.

NHTSA ODI 11506718

The hood latch is faulty. It’s a known problem for the 22 outlander. When the car drives the hood shakes as if it will lift up while driving. It has been almost a year of ownership and Mitsubishi has yet to fix this issue.

NHTSA ODI 11497911

Traveling at speeds over 50mph or heading into a strong headwind the hood bounces and looks like it will fly open at anytime. Took it do the dealer who were unable to fix it

NHTSA ODI 11491550

Two issues: 1: since the purchase of the vehicle the hood would bounce up and down while on the highway. The service team acknowledged this was a known issue and advised they would resolve. It has been 3 month with no resolution. 2: when the gas mileage drops below 30 miles left to empty the display changes to “—“ and no longer comunicates mileage left to empty.

NHTSA ODI 11484953

Was driving through a sand storm at about 65mph. Forward collision sensor had to be turned off as when the wind and sand hit car, the car kept giving warning. Also hood shock aggressively. Was scared that it will pop open

NHTSA ODI 11482497

The contact owns a 2022 Mitsubishi Outlander. The contact stated that while driving at various speeds, the hood was fluttering. The dealer was notified about the failure but offered no assistance. The manufacturer was notified of the failure and the contact was referred back to the dealer for assistance. The vehicle was not repaired. The failure mileage was 0.

NHTSA ODI 11478349

I have had this outlander since Sept of 2021 and the hood flutter is awful. A few attempts of installing weatherstrips and no change. I had the whole hood replaced and it seems as if the whole hood is even 10x worse. Its extremly distracting and can not be safe with the amount of movement it has. This is a distraction and safety issue. No change was made with the new hood. I’m going on a year with this vehicle and it’s problem after problem. The worst one is the major hood bouncing. (Yes, the hood is latched properly) it’s just getting worse week by week. I need an answer ASAP. This is not normal and defiantly not safe at all! It’s a matter of time when that latch gives and that hood comes up!

NHTSA ODI 11478296

Hood flutters while driving. Fear of flying up while I'm driving

NHTSA ODI 11473730

When driving on highway hood bounces like it isn't latched but when I pulled over to check it was latched..scary to drive above 50mph...also, backup screen goes black/blank occasionally when reversing as well as when driving down road..dealership says they documented but no recalls on it

NHTSA ODI 11473135