What 131 owners told NHTSA about the 2022 Kia Carnival Hev

The contact owns a 2022 Kia Carnival. The contact stated that both the driver's side and passenger side electronic sliding door had malfunctioned and would erroneously open and close. The contact indicated that while the daughter was retrieving items from the vehicle the passenger electronic side sliding door erroneously closed on her daughter and causing minor injuries to the arms and ribs which did not require medical treatment. The vehicle was later the taken to the dealer and serviced under a manufacturer's campaign to reprogram the door sensors. The door sensors were reprogrammed but the failures continued to occur. The contact indicated that after the door sensors were reprogrammed the doors would randomly open and close while the vehicle was turned off. The cause of the failure has not been repaired. The manufacturer was notified of the failures. The failure mileage was 705.

NHTSA ODI 11539997

I bought this car June of 2022. The car was days old and the front end started making a popping sound when you turn the wheels. The dealership changed front right axle. There is still a popping noise but now it’s from the front and the back. The transmission went out in February of 2023. They replaced the transmission. Since then the car shakes violently when accelerating, loses power when accelerating, the self drive mode turns on by itself. I have contacted 2 different dealerships about these issues. They say “ they cannot duplicate the problem.” This car is not a safe vehicle for me or my family to ride in. They won’t do ANYTHING about it!

NHTSA ODI 11537506

Rear sliding doors DO NOT STOP when something is in the way. All my body weight could not stop the door. Yes I had the recall fixed which only slowed it down and added a beeping sound. The sensitivity of the doors NEEDS TO BE FIXED NOW BEFORE A CHILD IS SERIOUSLY HURT.

NHTSA ODI 11535402

The contact owns a 2022 Kia Carnival. The contact stated that while her daughter was inside the vehicle, the door closed on her rib cage and arm, but medical attention was not provided. Additionally, the taillights were inoperable. While driving, the vehicle stalled. While accelerating and making a turn, the vehicle hesitated and stalled. The engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the weather stripping sensor needed to be replaced. The bulb was broken, and a wiring harness replacement was needed. The system was reset. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 1,187.

NHTSA ODI 11535422

These doors need a sensor to reverse the sliding doors upon resistance. It has smashed me and my young children multiple times. The update did not solve this issue and it’s a major safety issue. My 4 year old and 1 year old both had their hand smashed in the automatic sliding doors.

NHTSA ODI 11535594

During a road trip, I stopped at a gas station to fill up. I went inside to get a drink and a large 12 inch crack appeared in the windshield about midway down on the passenger side. It was not there previously and nothing appears to have hit it either. The crack now spans to the drivers side and sits at about eye level. It also has a gap in the crack which is very noticeable on the passenger side.

NHTSA ODI 11530248

Got in car and drove less than a mile and exited car. Got back in and my windshield had a huge crack running from the lower drivers side up the window then across. Nothing hit the window though a nut or something could have fallen on it or a small rock when driving another day? Very concerning when I look online and others that own the 22 kia carnival have had this happen

NHTSA ODI 11525666

In December of 2021 my 6 month old Kia Carnival lost power while on the Ohio turnpike when the engine shut down. At that time the dealership was unable to identify the cause. Since then the vehicle has been into the shop multiple times, has an issue with Cylinder 6 and is burning coolant internally which is likely the original reason for the unexpected engine failure. Kia has been ordered through arbitration to repurchase the vehicle, however are unwilling to even offer enough to cover the loan and take back their defective vehicle. I have seen reports online of other Carnivals having similar issues. There are no recalls for this, and Kia seems to have no intention of making sure this is addressed.

NHTSA ODI 11523833

Kia issued a safety recall recognizing the power sliding doors on the Kia Carnival do not properly reverse when they encounter an object while closing. Their solution to the identified problem is to simply sound two beeps when the door closer and reduce the speed of closure. This is entirely unacceptable resolution to the problem. Adding two beeps will do nothing to protect my two year old son from having his hand mangled in the door. Now that Kia has accepted this is a safety issue, I full expect a remedy no short of fixing the problem and find the current "fix" entirely unacceptable.

NHTSA ODI 11521646

Had maintenance and recall "fix" for sliding door issue done on 5/9/2023. Technicians explained to me that the actual sensor that detects when something is in the way of the door closing and in turn force the door to stop and reverse is called the "pinch sensor". That is separate from the speed of the door closing and the sound of it beeping as it closes (what the software update changes/"fixes"). They put a note to check my pinch sensor in addition to doing the software update. Even though I explained and they tested the pinch sensor, they did not do anything to change the sensitivity of that sensor. I put my arm in the door's path, letting it close until just a few inches are left, hoping that it'll detect my arm and reverse back open. It does not. I did this multiple times, same result. The second video is me just pushing on the sensor, from an angle I tried to do from inward to outward (as if I were in the vehicle reaching towards the door and pushing on that sensor). That is how the technician explained to me that the sensor works - it works to reverse if someone is "getting out of the vehicle and pushes on that sensor", it will reverse. That's good it can/will reverse that way, but I am still frustrated because there are issues with that being the only way it reverses. 1) Little kids aren't going to understand the logistics of how/where to push on the sensor "correctly", and 2) I'm more worried about how my kids get out of the vehicle, then push the close button, then reach BACK INSIDE for something (like my arm was reaching inside from the outside). Kia should recall the pinch sensor and replace with a sensor that is actually sensitive to an object being in the path of the closing door (from the outside too). Additionally, I have seen some Carnival owners post online that there doors ARE sensitive and reverse/open at the slightest touch. Since this vehicle is capable of that, Kia should fix this on all Carnivals on which it does not operate that way.

NHTSA ODI 11521338

Vehicle’s horn intermittently stops working. The length of outage varies. Restarting the vehicle does not resolve the issue. Safety is at risk due to having no way to alerting other drivers of potential hazards.

NHTSA ODI 11518254

Horn intermittently works. Some times it works and sometimes it doesn't work. This is a safety hazard if horn does not work. I cannot warn others before collision resulting in many close calls or evasive maneuvers. Other owners experiencing similar issue in Carnival Facebook group. Irvine Kia had my car for a week and s could not fix our reproduce because it was working there. Afterwards, it will still intermittently work. Not sure if weather is affecting it or outside temperature. It doesn't matter, the horn needs to work 100% of the time.

NHTSA ODI 11516991

The contact owns a 2022 Kia Carnival. The contact stated while driving 45 MPH, the vehicle lost motive power without warning. The contact was able to stop on the side of the road. After several attempts to restart the vehicle, the contact was able to start the vehicle and noticed that the check engine warning light was illuminated. The vehicle was taken to the dealer, and the dealer stated that because the check engine warning light was not illuminated, the vehicle would not be diagnosed. On another occasion, while driving 65 MPH, the failure reoccurred. The vehicle was taken to the dealer and the dealer stated that the actuator needed to be replaced. The vehicle was repaired but the failure reoccurred. On another occasion, the contact stated while adjusting the driver’s seat to a higher position, the seat failed to remain at the higher position. The contact also stated while driving 35 MPH, the vehicle would not immediately accelerate. After several seconds, the vehicle accelerated normally. The vehicle was taken to the dealer and the dealer stated that the console, horn assembly, and an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provided no further assistance. The failure mileage was 1,872.

NHTSA ODI 11516859

Sliding door closed on 21 month old daughters arm breaking it.

NHTSA ODI 11516428

I repaired my front strut and in less than a year it is now “internally bent” is what the dealership told me. I now have 4 balled tires and 2 rear toe in tires and done 3 alignments in 1 year and I was told it’s my fault.

NHTSA ODI 11513518

The powered sliding door sensor is inadequate. My son pressed the door closed button and I had to push the door off of my body as it started to crush me.

NHTSA ODI 11512506

The sliding doors are dangerous for my children. The doors do not have sensors (or if they do they do not work) and continue to close if my children are in the doorway, have items or body parts there.

NHTSA ODI 11509037

When helping my child into the car, she pressed the door close button and the sliding door closed on my body and did not stop. The door sensors on this vehicle do not work and it will close on anything in its path, including tiny fingers. I have not personally called the dealership regarding this issue but I will have them reproduce this issue at the dealership at my next service appointment. The vehicle has not been inspected by anyone. There is no warning that the car sliding door sensors will not work and will close on anything in its path.

NHTSA ODI 11507880

Both situations have happened numerous times. The sliding doors do not stop or back off unless an adult size person pushes body force against them to open. My daughter got stuck in the door and she is 2.5. I have to push my entire body against the door to make it open back up. The second thing is the emergency braking system will automatically slam on the brakes after forcing for a long period of time, when I am on the highway. It happens on road trips after cruising for a while. And is not happening at an appropriate time.

NHTSA ODI 11507176

With very low miles on our Carnival, I had just left a stop sign and someone ran their stop sign at high speed and tboned my vehicle in the driver's side. I woke up from being unconscious while still in driver seat and my car was still limping down the road not far from the intersection. Pretty serious head, back and other injuries and was taken via ambulance to the hospital. The problem is that despite a high speed impact into the side of my vehicle, NOT ONE of the airbags deployed! I am confident that my injuries, that now seem permanent, would have been MUCH less if the airbags had deployed as designed. The car was totalled by Insurance. I do have pictures of it.

NHTSA ODI 11505365

The passenger sliding door continues to fail to lock intermittently which is obviously a safety hazard since the door is not completely closed. It is available for inspection upon request. It has not been seen by a dealer or inspected by police or insurance. My father is a mechanic and has looked at it. He is unsure how to fix the broken or why it keeps happening. The door ajar warning light is on indicating the door is not locked but even if the auto door is shut off I can’t get it to close enough manually shutting it so the warning light will turn off. It happened about three months ago then stopped and now has begun again. Nothing that I know of caused this. I use both sliding doors equally and only one is having the problem.

NHTSA ODI 11503899

The contact owns a 2022 Kia Carnival. The contact stated that the passenger’s side rear power sliding door auto-reverse failed to engage. Additionally, the contact stated that while her husband was buckling a child in the car seat located in the rear driver’s side seat, her daughter who was also inside the vehicle pressed the door switch button, and the driver’s side rear power sliding door engaged. The door closed in on her husband instead of stopping and engaging the auto-reverse function. The contact's husband was able to release himself and advised the children that were inside the vehicle to not move for their safety. There was no warning light illuminated. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact referenced NHTSA Action Number: PE22004 (Structure). The manufacturer was not notified of the failure. The failure mileage was approximately 500.

NHTSA ODI 11501337

The contact owns a 2022 Kia Carnival. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The check engine warning light illuminated. In addition, the horn and the sliding sensor for the doors on the vehicle failed to work as needed. The vehicle was taken to a dealer however, it was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 13,125.

NHTSA ODI 11499548

1. When accelerating (while driving on ECO Mode) the vehicle starts to shudder at times. When using Normal Mode, the vehicle will shudder while the brake pedal is being used at a red light. Front windshield cracks easily and paint easily chips with no sign of rocks hitting the vehicle. Called Kia Service to get the car looked at and they said they haven’t heard of such issues. 2. Doors are supposed to retract when closing if motion is occurring. A family member almost got her leg pinned by the door and our child almost got hurt on the shoulder because the door kept moving in closing mode when she was trying to get inside the car. Whatever sensor it has, it doesn’t work. 3. Roof Mold on driver’s side came off the roof while driving the speed limit on the highway never to be seen again. The passenger side almost went flying too. 4. iPhone XR does not work properly when synced to the car. It connects and disconnects out of nowhere. It becomes dangerous when using GPS. Vehicle system kept saying it needed a new software to be downloaded. Went to the site and downloaded multiple rimes, called the Customer Service about 3-4 times and last person I spoken to told me to ho straight to the Service Dept at the Kia dealership to get the software downloaded. No one at Kia knew how to download the software. After multiple attempts and Kia not “finding anything”, decided to spend extra money and get a new phone to resolve this issue. I have to have a software downloaded to the vehicle.

NHTSA ODI 11498214

Fuel gauge does not provide accurate representation of fuel amount. The car will read empty with 100 miles .

NHTSA ODI 11493488