What 457 owners told NHTSA about the 2022 Ford Maverick Hev Hev

While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.

NHTSA ODI 11743262

Just picked up vehicle after having a new battery installed. Was getting pop up on dashboard every few seconds that electrical saving mode was active. Then all of a sudden the truck shut off while driving about 45 mph on a busy road. Dash said switch to neutral to start vehicle which i tried but nothing happened. Truck coasted to a stop and would not start or even shift into neutral to push it off of the road. The dashboard was flashing pretty much every warning possible including stop safety, shift system failure, parking brake , battery saver active etc. The truck continued to not start or shift. Tow truck was called and it was towed home.

NHTSA ODI 11723267

My 2022 ford Maverick is constantly sometimes several times a day and sometimes several times a week , but since 6 weeks after purchase I have been getting powertrain fault , engine fault and hybrid battery fault alerts from my ford pass my check engine light comes on my s service wrench light comes on also and my vehicle has reduced power. As well as my battery is constantly needing to be jumped. The dealership says my Battery is fine although I’ve already replaced it twice at my exspence. I’ve had to pay for diagnostics and pcm updates supposedly to fix these problems but no resolve. My vehicle goes into reduced power while driving 75 mph up the interstate and will not excellerate causeing the vehicle to coast to a stop. After sitting a while it can be started and driven. Today I received all three faults at 10:20 am so I went to my ford.com and done a health check and it says my vehicle is healthy with no engine or power train faults. But my ford pass alerts , my dashboard warning lights , and the performance of my vehicle says otherwise. I have been put in many situations on high speed roads and my vehicle will not accelerate. Often times it is necessary to jump my battery for I can move my vehicle. These issues are a constant safety hazard to all the drivers on the road when a vehicle suddenly loses power at high speeds. After 4 years of fighting with ford for a resolve I need help. I have seen numerous recalls issued addressing these very issues but they are not issued for my vin although the data on the recall states the recall pertains to vehicles made at the hermacillo Mexico plant . Which mine was on Dec 2021. I feel like my vin somehow is being overlooked and I’m not recieving the recall for the repairs. I also believe that due to the electrical issue my truck can not retain the obd codes. I have taken my vehicle to several dealerships all telling me different resolve which I pay for and no resolve. Please help

NHTSA ODI 11723301

The engine stalled and won't start came to a slow stop warning lights came on and said "stop safely now". Turn.\nKey on engine may start for 1 second stops and we're not going to drive or any mode

NHTSA ODI 11702077

The 2022 Ford Maverick repeatedly experiences complete electrical system failures, including engine shutdown, loss of power steering, brakes, and the electronic parking brake, while driving at highway speeds, resulting in total loss of vehicle control and creating a life-threatening situation for the driver, passengers, and others on the road; prior warning signs included the 12-volt battery not staying charged and intermittent total electrical power loss, and while no warning lamps indicated imminent failure, the issue was reproduced and documented by a dealership that replaced the battery, performed a BCM relearn, and applied a software update, yet the problem persisted, leaving the vehicle undriveable and unsafe, requiring repeated jump-starts, and demonstrating a fundamental defect in the electrical and control systems; the vehicle is currently scheduled for further warranty diagnostics at a second dealership, and because prior warranty repairs failed to correct this repeat, safety-critical, and life-threatening defect, I request immediate manufacturer investigation, full warranty coverage, and evaluation for vehicle replacement under applicable Lemon Law or consumer protection remedies, as the repeated failure places lives at risk and the vehicle cannot be safely operated until fully corrected.

NHTSA ODI 11698238

1)After sitting for 2 days the battery was drained or dead. The truck would not start. I jumped the truck and it started up. Every time I park the truck i get a warning that the battery is low and I should drive it to recharge the battery. I drive the truck but it will not recharge. 2) The check engine light comes on. I went to the auto parts and scanned for diagnostics. The scan came back as a fuel tank pressure sensor failure. 3) When I drive the truck it smells as if something is burning. 4) The fuel gage is not showing accurate reading. 5)The fuel door wont open unless I have the truck turned on and then it takes several minutes. 6) After driving on the freeway I came to a stop on the off rap before entering a main street and the truck died.

NHTSA ODI 11667821

Vehicle lost all power while driving. This was due to a failure of the hybrid system. Created a dangerous situation as vehicle started coasting without power in neutral.

NHTSA ODI 11666668

Loss of forward, propulsion due to a 12 V battery system failure. Repeated and frequent deep sleep mode. Loss of fuel mileage below manufacturer specifications.

NHTSA ODI 11662797

My vehicle failed to start due to a now corrected recall issue. When it did not start I attempted to jump start the engine and found that the car is missing its positive jump terminal on the engine so it is impossible to jump the car. It was sent to a dealership for repair but they never corrected the issue. It is still missing.

NHTSA ODI 11653300

I was driving along in slow traffic on the highway and lost ALL power to my truck and it just stop. No electrical, no drive. There is a recall for this but apparently it did not include my VIN.

NHTSA ODI 11641317

Engine Service warning appeared this morning and the vehicle immediately lost power to a maximum of 20 mph. The same thing happened approximately 2.5 months ago. A Ford dealership technician checked it out could not find an issue and cancelled the check engine light. Both times this occurred on a busy road and could have led to a potential collision with another vehicle.

NHTSA ODI 11634207

Just recently I've noticed that when the engine is running and I'm stopped or parked the truck will "lurch". Almost as if I'm trying to hit the gas while parked or holding the brakes. Since this has started, I've also noticed that from 25mph to 60/65mph there is a violent vibration ONLY under acceleration (20-25% on the power meter) while the engine is running. Issue worsens depending on the mode the truck is in (worse under sport, better under ECO/Slippery). Whole truck will shake, body, steering wheel and all. Not sure if these two issues are related? I'm not sure if these are considered to be powertrain or if it's the engine. Not sure if I could have it inspected upon request because I can't pin point any mechanical abnormalities visually. I feel my safety and others may be a concern because the unknown of the issue. I'm not sure if the vehicle is breaking down, will break down, lose power or whatever the case may be. The vehicle has been reported to Ford for these issues with no resolve. No warning lamps or messages. The issue appeared to come out of no where. Wasn't doing it one day, began doing it the next.

NHTSA ODI 11631117

The engine will want to surge forward in a "pulsing" feel while stopped at a red light. No amount of braking force will keep the Ford Maverick from trying to lurch forward. It feels like someone is gently "pushing you from behind telling you to go..." This seems to happen when the engine is cold. Its done this since day one of ownership and it has now been nearly 3 years with no fix.

NHTSA ODI 11625754

Issue: Shift SYS Fault, DTC P07E6 System: Transmission Description: Emergency parking brake failed to disengage (solenoid could be heard attempting to move), as a result the transmission would not shift out of park. Check engine light and multiple codes/warnings illuminated on dash. Vehicle could not be moved or shifted into neutral. Waited 10-15 minutes before 2nd attempt, parking brake still failed to disengage. Then waited for 3 hours for third attempt, at which point emergency brake successfully disengaged. Check engine light no longer lit and no codes/warnings present on dash. Nothing changed or was done to the truck between the 2nd and 3rd attempt. Reproduction: Will drop off at dealer for confirmation in coming weeks. Warnings: Engine check light, Shift SYS fault, DTC P07E6, See dealership -> all illuminated after parking brake attempted to disengage during 1st and 2nd attempt.

NHTSA ODI 11615267

My vehicle completely shutdown while we were driving on interstate 15 doing 77 mph. When everything shut off we had no brakes and no way to put the hazards on. It’s literally died while we were driving 77 mph.

NHTSA ODI 11612165

See attached document for complaint

NHTSA ODI 11606735

Vehicle has had a Powertrain failure three times in a month. This causes the vehicle to look up and lose power. Dealers can not figure it out and Ford has not provided any solutions. Been without vehicle for 6 weeks at this point. Malfunction causes all systems to fault and vehicle seizes up making it undriveable.

NHTSA ODI 11603701

I was driving for about 10 minutes at speed 35 mph then noticed the car is in electric mode but unable to accelerate. It feels nothing happened when I depressed the gas pedal. The car came to a complete stop at traffic light but failed to accelerate when I pressed on the gas pedal. I turned off the car and started it back up and everything return to normal.

NHTSA ODI 11602817

I have a 22 hybrid maverick with ~ 27,000. I was driving back home from out of town and I had already driven for a good two and a half hours. I was passing an 18 wheeler when suddenly my whole truck turned off. The dash, infotainment screen all black. I tried to turn on the hazards but nothing came on. The steering wheel was stiff and I was pressing the brakes as hard as I could but we were barely slowing down. I coasted across the right lane and into the shoulder/grass and finally came to a stop. I turned the truck off and on and a whole bunch of warnings and lights popped up. I turned it off again and when I turned it back on it was like everything was back to normal. I drove the rest of the way home ~ 50 mph. The truck felt awkward when switching from gas to electric and shook a bit when coming to stops. I will be calling the service dept tomorrow.

NHTSA ODI 11602115

Engine lost power while driving. Could not go past 30mph after. Warning lights showed on dashboard of the engine and a wrench. Servce Engine soon warning also showed.This is the 2nd time happening. And this is the 2nd time to the dealership. They couldn't find the problem and gave it back to me.

NHTSA ODI 11597956

On June 13th 2024 my Maverick suddenly lost power and all lights on dashboard lit up. Apparently this has been documented by others, and vehicle then went into LIMP MODE and was not responding to accelator pedal properly and would not move beyond 30mph. Engine light is still on, and my Ford App shows 3 messages: 1. SERVICE ENGINE SOON 2. POWERTRAIN SYSTEM FAILURE 3. COLLISION AVOIDANCE UNAVAILABLE

NHTSA ODI 11594322

Lost engine power while driving. Only had electric power and could not accelerate to get out of the way of traffic. Able to use hazard lights and coast to safety. Turned off everything and turn on again, only to go a block and it did it again. Service engine alert came on.

NHTSA ODI 11593908

I was driving on the highway at about 65 MPH. Without warning, the vehicle dashboard displayed “Selected Gear Will Engage at Lower Speed,” the vehicle shifted itself to neutral, the accelerator pedal stopped responding, and the vehicle began coasting to a stop. I had to avoid high speed highway traffic to make it to the side of the road. When I had slowed to about 5 MPH, the vehicle forcibly shifted to park, and engaged the parking brake on its own — causing an abrupt stop. I could not shift out of park. The check engine light, wrench icon, traction icon all illuminated, the chime sounded and a series of errors displayed: “Service Advance Trac” “Collision Prevention Unavailable” “Hill Start Unavailable” “Service Engine Soon” among others. After power cycling the vehicle, the warning messages and icons remained, but I could shift into drive. However, the vehicle wouldn’t travel above 30 MPH, and seemed to accelerate on its on, as if it were on cruise control set at 30 MPH. Abruptly stopping on the highway is very dangerous, and could have caused a serious accident. Unless there is a catastrophic failure (which there wasn’t) the vehicle should never uncontrollably stop, especially on the freeway.

NHTSA ODI 11593370

Friday 6/7 I was driving my 2022 Ford Maverick at night and suddenly with no warning the dash went dark, there was a grinding noise and the truck completely shut down - engine, electrical, lights, everything. Luckily, I was on a residential street and was able to get it off the road because the flashers would not work. My safety was definitely put at risk - I was in a totally disabled truck on the side of the road after dark with no working lights of any kind, including emergency flashers. There were no warning lights in the truck prior to shut down, and no messages received via FordPass at that time - the Ford app actually showed all systems as "good". I had the truck towed to the Ford dealer that same night. Saturday morning 6/8 I received a message via the Ford App "Remote features disabled to preserve battery". Monday morning 6/10 I received a message via the Ford App "Service Engine Soon Warning". All while the truck is sitting in the dealer service lot. Background - Another ongoing issue - 3 times in the last month - May 3, May 8, and the morning of June 7th - I've been stranded and had to call AAA to come and jumpstart the truck - all 3 instances I was running errands, would shut the truck off to run in a store only to come out and the truck is totally dead. When it happened on May 8th, I received a warning via the Ford App "Service Engine Soon Warning" and took it into the Ford Service center on May 9th.

NHTSA ODI 11593564

I got recall notices in the mail in May. Unfortunately Ford of Kirkland (WA) Could not schedule me for an update until July 25th, that is their first opening because of all the recalls. On [XXX], 2024 at [XXX] I was traveling NW on [XXX] from Yakima WA to Ellensburg WA. I was traveling about 75 mph when the car shifted itself to a lower gear, then lights started flashing all over the dash for numerous things. the monitor stated something about low gear, service engine light on, diagnostic was being run, all in a matter of seconds. As I was looking to see if I could get over the truck's collision brakes activated even though there was no one in front of me. I lurched forward while my truck was slamming on the brakes out of the blue. I managed to make it to the side of the highway and shut off the truck. If anyone had been behind me they would have slammed right into me. This would have been a high speed rear end collision and I as well as others could easily have been killed! This was needless to say, terrifying! A tow truck came and towed the truck to Valley Ford in Yakima WA, I haven't yet heard what the analysis of this total system failure was. I waited in the truck for an hour for a tow along side a very busy highway with numerous large semi's passing me less that a couple feet from the driver's side where I was seated. This should NEVER happen to anyone. Ford cannot manufacture a vehicle that is this inherently dangerous! It's just a miracle no one was right behind me or there would have been major injuries, and it would not have been my fault, or their fault. It would have been Ford's fault! These trucks need to be taken off the roads. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11593311