What 330 owners told NHTSA about the 2022 Ford Bronco Sport Later Release

On 12/22/2025, my fiancé and I purchased a 2022 Ford Bronco Sport from LaFontaine Ford in Lansing, MI. During the initial purchase, we were not aware of any recalls or vehicle defects with the Bronco Sport. Roughly one month later, the check engine light came on, and after a thorough vehicle inspection, we were notified that there was a recall on the vehicle in regards to bad fuel injector(s), and that we needed to bring the vehicle back to the dealership for a computer update. After dropping the vehicle off at the dealership, we were notified that the engine was blown due to a cylinder misfire as a result of a bad fuel injector. We were also advised that the dealership had already completed the computer update prior to our purchase and cleared out the codes (critical misfire). The negligence of the dealership put my fiancé in extreme danger with selling us a vehicle with a critical fault that could cause a vehicle fire! The problem still has not been remedied as Ford is asking up to pay $3,483.00 for a new engine with them covering $4,457.00. I believe all of this should be covered under the recall and/or powertrain warranty since this issue has been well documented with Ford Bronco's prior to us purchasing the vehicle.

NHTSA ODI 11716583

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); and the vehicle was taken to the dealer, where an interim recall repair was performed. The contact expressed safety concerns because the final remedy was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11715766

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer and provided with paperwork that the recall repair was completed; however, the part for the recall repair was not yet available, and the VIN indicated that the recall was still open. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11714996

See attached document for complaint.

NHTSA ODI 11715072

The contact owns a 2022 Ford Bronco Sport. The contact stated that there were strong exhaust fumes inside the cabin of the vehicle while idling and while driving the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where the contact was informed that no exhaust fumes were detected. The vehicle was not diagnosed or repaired. Additionally, the contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 18,000.

NHTSA ODI 11710445

The contact owns a 2022 Ford Bronco Sport. The contact stated that on every occasion while entering the vehicle, there was a fuel odor coming through the vents. The check engine warning light illuminated briefly during one occasion. The vehicle was taken to the same dealer twice and was diagnosed with a cracked coolant pump. The dealer determined that the coolant pump and the purge valve needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to an independent mechanic, where it was diagnosed and determined that there was fluid leaking nearby the catalytic converter; however, the mechanic was unable to take the catalytic converter apart. The mechanic also determined that the fuel injectors, the exhaust clamps and gaskets, and Oxygen sensors needed to be replaced, and the turbo charger required coolant and oil feed lines replacements. The vehicle was not repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was 70,000.

NHTSA ODI 11700758

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11700760

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue and confirmed that the part for the recall repair was not yet available. The contact had not experienced a failure.

NHTSA ODI 11700506

There has been a recall on this issue for 4 months with no options to have it fixed. The recall clearly states that a fire may start under your hood due to the issue, which seems like an issue that should be addressed asap.

NHTSA ODI 11700429

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer and two other dealers were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11697604

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11696303

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact called the local dealer several times but was informed that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact had taken the vehicle to the same dealer for an oil change and was advised that the rear shock absorbers were leaking and needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 20,000.

NHTSA ODI 11690821

As you may know, my Ford Bronco 2022 is under NHTSA Recall 25V467 as of July 2025. October is approaching, and so far, Ford Motor Company has not found any remedy for this problem, which can not only cause a spontaneous engine fire, but can also cause the death of those inside the vehicle or a serious accident if it occurs while driving. My vehicle is for daily use, and I have to transport my son to school every day, risking his life and mine, with the uncertainty of the vehicle catching fire. I ask that you consider requiring Ford Motor Company to collect these vehicles or exchange them for others of the same value that are not at risk.

NHTSA ODI 11690217

My car has a recall since 07/16 and manufacture has not resolved the issue.

NHTSA ODI 11689606

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact stated that while turning and depressing the accelerator pedal, the vehicle was slow to respond. There was a lag before the vehicle accelerated. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was taken to another local dealer, Fairway Ford (1350 E Yorba Linda Blvd, Placentia, CA 92870); where it was diagnosed and determined that an unknown part needed to be cleaned. The vehicle was repaired, but the failure recurred. The contact called the same local dealer, who confirmed that parts were not yet available. The manufacturer was called, but the phone call was disconnected several times. The approximate failure mileage was 36,000.

NHTSA ODI 11687408

The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was an abnormally strong fuel odor inside the vehicle. The contact stated that an unknown warning light was illuminated but went off independently. The contact stated that with the weather change, the heat was needed; however, the contact was concerned with the strong fuel odor inside the vehicle and stated that the odor was dangerous. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was provided with the cost for a diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact later received notification NHTSA Campaign Number: 25V467000 (Fuel system, Gasoline); however, parts were not yet available to repair the vehicle. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,136.

NHTSA ODI 11686295

The contact owns a 2022 Ford Bronco Sport. The contact had received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The contact called local dealer and was informed that the parts to complete the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure.

NHTSA ODI 11681593

The contact owned a 2022 Ford Bronco. The contact stated that while driving approximately 20 MPH, while in a line of traffic and preparing to make a right turn onto another street, the contact noticed black smoke coming from under the hood of the vehicle and spontaneously there were flames coming from under the hood. No warning light was illuminated. The contact stated that a nearby good Samaritan dialed 9-1-1 and the local Fire Department arrived on scene to extinguish the flames. A Police report was filed; however, the report was unavailable. The contact sought medical attention for minor smoke inhalation. The vehicle was towed by a towing company at the request of the Insurance provider and remained at the tow lot. The vehicle was inspected; however, the source of the fire was not identified. The vehicle was deemed a total loss by the Insurance provider. The local dealer was not contacted. The contact stated that prior to the fire, the vehicle was inspected by the local dealer regarding a battery sensor error and the vehicle was repaired under NHTSA Campaign Number: 25V019000 (Electrical System). The contact related the fire to NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The manufacturer was not made aware of the failure. The failure mileage was approximately 46,000.

NHTSA ODI 11678547

The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000( FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11676766

Vehicle stutters when driving at slower speeds, usually between 22-27 MPH. After purchasing my vehicle used I have found that others have been reporting the same issue, to include in brand new Bronco Sports, and have been advised that is just how they are. Switching to sport mode does seem to help but the stutters occurs at different speeds. There has been no known part identified as causing the issue. There are no warnings displayed and no codes showing.

NHTSA ODI 11673068

Recall 22S73 from Ford states that fuel injectors can crack and cause an under the hood fire. We have documentation showing that the dealer applied the recommended fix on June 26th 2023. On [XXX] I was driving and felt a fuel smell, a few seconds later I started seeing smoke coming from under the hood. By the time I got to the emergency lane there was already an open flame that brushed my hair as I got off the car. In less than 5 minutes my car was completely burn down along with my personal belongings. I have pictures and video of the car on fire in the highway. The police and the fire department responded to my 911 call and they were able to confirm that the fire did not start because of any traffic accident. We have access to the car and the fuel injectors for inspection if necessary. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11627300

See attached document for complaint.

NHTSA ODI 11610177

The contact owned a 2022 Ford Bronco Sport. The contact stated while driving at 70 MPH, the vehicle experienced abnormal gear shifts. Additionally, the contact noticed a gasoline odor and a burning plastic odor coming from the A/C vents. The contact stated that upon depressing the brake pedal to come to a complete stop at the stop sign, the vehicle failed to respond. The message "ABS Failure " was displayed, and several unknown warning lights were illuminated. The contact stated that he then veered to the left while there was oncoming traffic. The contact stated that he attempted to stop the vehicle by depressing the brake pedal, shifting to park (P), and engaging the electronic parking brake, but the vehicle failed to respond and was driving at 40 MPH. The contact then noticed smoke and fire coming out from underneath the hood, and the front end of the vehicle was engulfed in fire. The contact stated that he jumped out of the vehicle. The vehicle drove into a ditch, where it burned to the ground. The fire was extinguished by the fire department. The contact was unsure whether a fire department report was filed. A police report was filed. The contact sustained a scrape on the right Elbow and received care from the ambulance. The vehicle was towed and totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11593390

On [XXX] I began my drive from Miami, FL to SF, CA for my next travel nurse assignment. Three hours into my drive, I stop for gas and return to the highway. I remember accelerating to catch up to traffic and moving into the left lane. Then I remember abruptly seeing brake lights ahead, braking hard, and the collision warning system going off. I was braking for several seconds and it became clear to me that I was going to crash into the vehicle in front of me. Immediately upon impact, my Bronco Sport caught fire. I felt the heat. I smelled the fire and fumes. I saw people running towards me, yelling for me to get out of my burning car. The airbag went off and I sustained minor injury to my right hand. At that point, my priority was to locate my cat inside my perfectly packed vehicle with all of my most important possessions. I grabbed my cat, my phone, and my purse and escaped as flames overtook my SUV. The Nissan Rouge in front of me sustained some rear bumper damage but overall relatively minor exterior damages. I am in awe that what should have been a minor collision turned into escaping a burning car with my cat and watching my everything burn away. I struggle with PTSD from the accident. The Bronco was well-maintained. I had the recall repaired, along with oil change and tire rotation in November, prior to driving from Southern California to my home in Miami in early December. The vehicle was deemed a total loss by the insurance company. The insurance company did not choose to pursue any investigation on why this happened. I’ve tried to find answers and have not been successful. The Ford dealership where I purchased the Bronco has been less than helpful and even normalized that this happens sometimes. Four months later and I’m still waiting to get refunded for all the extra extended warranties that I bought for a vehicle that I planned on having for a long time. No one seems concerned that my car caught fire instantly. This should not have happened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11582599

My car lost power on the highway. I took it to the dealership. They had the vehicle for 2 months and said it was repaired under warranty/recall. The same day that I received the car back, the same problem occurred. They kept it for a few days and said they could not determine the issue and released it back to me yesterday. This morning, it lost power again, while i was taking a left hand turn into oncoming traffic. I was almost t-boned. There is an huge safety issue here that is being brushed off and I’m afraid I will end up in a terrible accident.

NHTSA ODI 11568739