What 132 owners told NHTSA about the 2022 Acura MDX Sport Hybrid

Humming noise from drivetrain. Took vehicle to Acura dealer and was diagnosed as: Loss of all wheel drive due to interfacing spline failure between transmission and transfer case resulting in only front wheel drive. Found open investigation NHTSA with other vehicles experiencing the same failure. DP26001

NHTSA ODI 11750945

The car made a clunk sound while driving and wouldn't accelerate. After coming to a stop and trying to take off, the car still had difficulty accelerating. After turning the car off and back on everything appeared fine. The loss of acceleration was unexpected and there were no warning lights or indication of an issue. The lack of ability to accelerate along with the clunk sound caused unnecessary safety risks by not allowing the car to maneuver out of danger and disrupting the flow of traffic unexpectedly. The car then began leaking oil. The Acura dealership noted that the oil was transmission and power transfer unit oil and the car no longer has all wheel drive but only front wheel drive. The loss of all wheel drive without any indication or warning is a serious safety issue because it affects all aspects of drivability (handling, acceleration, traction). They said over time the splines of the power transfer unit input shaft rust and then sheer off which causes metal to damage the transmission seal and power transfer unit seal. The service manager said this was a known issue due to bad engineering and there is no way to prevent it. The vehicle is unchanged since the incident and can be inspected.

NHTSA ODI 11750192

The contact owns a 2022 Acura MDX. The contact stated that while driving at 30 MPH, there was an abnormal vibration coming from the front passenger’s side of the vehicle. There was no warning light illuminated. The abnormal vibration persisted, and there was a grinding sound coming from the vehicle. The vehicle was taken to an independent mechanic to be diagnosed, and it was determined that the power transfer case spline had failed and needed to be replaced. The dealer informed the contact that the VIN was not under recall, and the vehicle was not under warranty. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000.

NHTSA ODI 11750386

Transfer case splines completely sheared off. No warning lights, nothing. Car is operating in in a 2 wheel drive configuration. Now need new Transmission, new transfer case, new differential. Can provide dealer videos detailing situation if requested.

NHTSA ODI 11748788

The contact owns a 2022 Acura MDX. The contact stated while driving at various speeds exceeding 30 MPH, the vehicle failed to accelerate as intended upon depression of the accelerator pedal; however, the RPMs increased. The vehicle was taken to the local dealer, who diagnosed that the transmission had failed and needed to be replaced. The vehicle was not yet repaired. No further information was available. The failure mileage was 60,000.

NHTSA ODI 11748572

My transfer case and transmission splines stripped out as I was leaving a parking lot on a rainy day... i heard a bang... went to dealer, they confirmed drive shift to rear wheels not turning. Today July 3rd 2026, my MDX-2022 With 92k miles is at the Acura dealer... I fortunately have an Acura Precision warranty.... which will cover my repair...

NHTSA ODI 11748203

Component or system failure: AWD - All wheel drive failure, dealership stated the transcase is leaking causing the failure. Safety: this has impacted the vehicles traction, especially on wet roads Reproduced: the dealer found the issue and reproduced it Inspected: yes, by the dealer Warning lamps or messages: None 2022 MDX Advance

NHTSA ODI 11747179

Noticed fluid was leaking from bottom of car. Took to dealership and they found the transmission output shaft was twisted leading to destruction of transmission seals leading to fluid leak. They recommend full replacement of the transmission and transfer case. It appears NHTSA is already investing this known problem for the 2022 mdx where the transfer case fails and the vehicle loses its AWD function and becomes a FWD car.

NHTSA ODI 11746418

MY VEHICLE 2022 ACURA TYPE S HAS A TRANSMISSION SYSTEM PROBLEM, BLIND SPOT INFO PROBLEM, AND A ALL WHEEL DRIVE PROBLEM THAT ONLY MY FRONT WHEE;S MAY BE POWERED. IT LOOKS LIKE THE TRANSFER CASE MAYBE FAILING. MY VEHICLE ONLY HAS 25,000 MILES ON IT AND IS ABOUT TO BE OUT OF WARRANTY

NHTSA ODI 11745883

My 2022 Acura AWD MDX with 95795 miles lost the power to the rear wheels. The spline between the transmission and the transfer case stripped. The transmission and transfer case had to be replaced for $14,442.37. I had Assurant for extended warranty, and they reluctantly paid most of the repair. The shop said this was the first non-turbo (sport) model they have heard of breaking. I believe there are several complaints filed about this issue. I'm retired and travel a fair amount in the mountains.

NHTSA ODI 11746086

I accelerated from a complete stop and heard a loud bang from the transmission at 10 mph. No warning lights came on, but car now only operating in front wheel drive mode instead of AWD. Front wheels will spin under hard accelerating confirming loss of power to rear wheels. Local mechanic confirmed issue by putting vehicle on lift and showing rear drive shaft spins freely. This is a know issues for this vehicle and NHTSA has open investigation into splines connecting transmission to transfer case sheering off under load. Investigation Number 11712885.. This should result in a recall for Acura at no cost to customer.

NHTSA ODI 11745438

Driveshaft spinning freely no power transfer , vehicle is currently all-wheel-drive condition indicate severe connections between transmission and transfer case . both components are damaged vehicle need replacement of transmission and transfer case . Serviced at McGrath Acura Morton mGrove, Illinois. 06/19/26

NHTSA ODI 11745398

The component system that has failed is the Front Diff/Transmission area. Driveshaft spinning freely in park with rotations to rear wheel. I was driving home and heard a noise that sounded like something broke. Immediately pulled over and had Vehicle towed. I had my kids and husband in the vehicle with me. I'm glad we weren't driving on the highway. The vehicle was brought to Friendly Acura in Middletown, NY. They were able to diagnose the problem. I had an aftermarket warranty (Endurance Warranty Co.) awesome refused to pay for my vehicle starting it was a "pre-existing" condition. When I tried to explain to them this was not the case, they still wouldn't approve my claim after my vehicle was at Acura for 5 weeks and having 2 of their inspectors come out. Due to the amount of the repair (approximately $15,000), I am unable to pay for this repair. I had Acura out my vehicle back together and the vehicle is currently sitting in my drive way. There were no warning lights at any time prior, during or after failure of components.

NHTSA ODI 11742450

I was driving down the highway and a passerby notified me that my car was smoking. There were no indicators on the car notifying me of any issue. We pulled over and saw the car was leaking oil heavily. When taken to the dealership, they notified us that there was a leak in the transfer/transmission case and the whole transfer case would need to be replaced. The car is well maintained and had been recently serviced and no issues came up. It's very scary that there were no indicators of issues on the dashboard and my family and I could have been endangered while driving on our family vacation. Acura knows of this transfer case issue and has had to replace many of them in recent MDXs. This is a safety issue that needs to be investigated immediately.

NHTSA ODI 11742459

My wife has felt for quite some time that the traction on our 2022 Acura MDX is lacking. She first attributed it to tires, but after replacing them in November of 2024 she said that the issue was still present. She mentioned it to the Service Advisor at Bloomington Acura but we don't recall the exact timing of that and don't have a record of it. In February of 2026, while driving in snowy conditions we arrived at a vacation property. In driving up the driveway, the MDX got stuck. We got out of the car to try to push it and noticed that the rear wheels weren't rotating (I would expect them to on an AWD vehicle when the front wheels spin). We were able to put wood pieces under the front tires and get the vehicle up the driveway. We reported it to the dealer, who told us that if there were no warning lights there was no issue. We asked if they could test it because AWD wasn't working. We didn't get far but asked during a recent oil change if they could test the AWD. We had to push for that but they did test. They indicated that the rear drive rotated freely, indicating that "splines" between the transmission and transfer case had failed and it would cost $14,000 to repair (our MDX is now beyond the mileage threshold of the power train warranty. I then researched and learned that this issue is under NHTSA investigation DP26001. Customers don't have a reasonable way to know that AWD isn't working; we have brought it up previously with no way of "proving" that it isn't working (no warning lights). We believe that Acura should extend the power train warranty and repair our vehicle. The dealer let us know that they have another customer with the same issue right now. I don't believe that dealers file reports to NHTSA and imagine this issue is bigger than the number of complaints filed. AWD isn't needed by many, but it affects our safety in snowy conditions.

NHTSA ODI 11740022

My 2022 MDX purchased new in 2021 experienced an unexpected loss of AWD functionality at 5 years old with 77000 miles when the splines of the transfer case sheared with the transmission. The failure reverted the car to FWD and became very easy to lose traction in anything but ideal road conditions. There were no signs of this failure. No warning lights, no indication on the AWD power distribution monitor, and no sounds or other indications. I rigorously followed all maintenance schedules and performed all regularly scheduled maintenance at the Acura dealership. There have been numerous times when I am attempting to accelerate from a stop while turning onto a busy road where the unexpected loss in traction resulted in me nearly causing an accident. I took in my vehicle for service on 5/22/26 and they confirmed the issue is the transfer case spline failure as noted by many other Acura SH-AWD vehicles with the active NHTSA investigation. I would like to add my complaint to that filing and highlight the insidious danger that comes with the failure when the vehicle suddenly does not perform as expected. Given that my vehicle was barely behind the powertrain warranty period when the failure occured, I am now expected to cover an enormous bill that covers the replacement of the transmission and transfer case.

NHTSA ODI 11739605

I am submitting this complaint regarding my 2022 Acura MDX Advance, currently with 71,007 miles. After completing the standard transmission fluid service around the 60,000-mile maintenance interval, I began noticing abnormal drivetrain/transmission behavior that was not present before. At times, the vehicle feels as if the transmission is slipping, hesitating, or failing to transfer power smoothly. Acceleration can feel delayed, uneven, or weaker than normal, and on some occasions the vehicle seems to surge or accelerate slightly in a way that does not feel consistent with normal pedal input. This is a safety concern because the vehicle may not respond predictably when accelerating from a stop, merging, passing, or driving at highway speeds. A delay, slip, surge, or loss of expected acceleration could increase the risk of a crash, especially in traffic. The symptoms appear to involve the transmission, drivetrain, torque converter, transfer case, software calibration, or related components, but I am requesting a proper investigation to determine the actual cause. My concern is that this issue could worsen or affect other 2022 Acura MDX vehicles if it reflects a broader defect. I am requesting that NHTSA document this complaint and review whether 2022 Acura MDX models may have a safety-related issue that can cause slipping, hesitation, surging, delayed acceleration, or loss of expected power after normal maintenance. Acura should evaluate whether owners need inspection, repair, software updates, or other corrective action.

NHTSA ODI 11738928

My car was purchased from Impex Auto Greensboro, Nc one owner with 71,000. The car fax never stated any major accidents or damage. March 2026 after having my car for 1.5 years I now need a new transmission that costs $15k. I filed a Goodwill claim with Acura since all warranty’s have expired and I did not purchase an extension. The claim was denied and I’m responsible for the repair of a 4 year old car’s transmission.

NHTSA ODI 11738934

I own a 2022 Acura MDX SH-AWD with approximately 85,000 miles. The issue began suddenly while driving around 5 mph when two loud bangs were heard from the rear drivetrain/transfer case area. After the initial incident, the vehicle was driven home, and the problem became consistently noticeable during any acceleration from a stop or low speed. The drivetrain would clunk/slip during acceleration and exhibited abnormal engagement behavior. Due to concern about causing further drivetrain damage or a potential safety issue, the vehicle was subsequently towed to an Acura dealer for diagnosis. The Acura dealer confirmed that both the transfer case and transmission require replacement due to “worn teeth on splines.” The repair estimate specifically states: “REPLACE TRANSFER CASE AND TRANSMISSION DUE TO WORN TEETH ON SPLINES.” Estimated repair cost is approximately $11,400. I have photographs and repair documentation related to the failure. This failure created a potential safety concern because the drivetrain was no longer operating normally and produced loud clunking/slipping during acceleration from stops and low speeds. A drivetrain or power transfer failure could increase the risk of loss of propulsion or inability to accelerate normally into traffic. The issue was reproduced and confirmed by the Acura dealer. The vehicle has been regularly maintained, including drivetrain fluid services, through Acura/Honda service facilities. There were no warning lights, dashboard messages, or electronic indications before or after the failure event. The only indication was the loud banging noise from the drivetrain/transfer case area and the resulting abnormal drivetrain behavior during acceleration. The service manager also indicated they had seen several similar cases involving this issue.

NHTSA ODI 11737467

The contact owns a 2022 Acura MDX. The contact stated that while driving at an undisclosed speed, the all-wheel drive (AWD) system became inoperable. The contact stated that when attempting to engage the AWD function, the system failed to operate and the vehicle would transition into four-wheel drive operation. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer referred the contact to the NHTSA hotline for further assistance and advised the contact not to contact the manufacturer. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.

NHTSA ODI 11737037

Transfer case failure limiting all wheel drive system. Needs new transmission and transfer case at 83000 miles.

NHTSA ODI 11733865

Complete drivetrain failure while accelerating from a complete stop in the middle of a busy intersection. No warning lights or hazard messages were activated before or after the failure. The car made a massive clunking/banging sound and continued to clunk on acceleration. The car had to be towed to the dealership. My children were in the car with me, and we had just driven on the highway for 45 minutes before this failure. Luckily, my husband was behind me, and I activated hazards until I could pull over safely. It was jerking and clunking so badly that I was barely able to steer. It was terrifying since my two young children were in the car, and they were both screaming from the noise. I believe I would have been rear-ended if my husband had not been behind me due to the sudden jerk from the failure, as I was the first car in the left turn lane. This is not the first issue I have had with the transfer case in this vehicle. The affected transfer case and drive train were replaced only 7 months prior due to a faulty transfer case and a severe clunking sound. This vehicle has had repeated drivetrain failures without warning, resulting in loss of traction and control. The recent failure reflects a completely stripped spline connecting the transfer case and transmission. This will be the 4th transfer case this vehicle has had at only 64K miles. All recommended maintenance and care have been completed at the certified Acura dealership since the vehicle was purchased. Recently, the 60K services were completed just 3 months prior to the current failure. The vehicle is currently at the dealership for repairs under warranty, as it needs a new transmission and another transfer case. I have not yet received the documentation, as the car is not in my possession, but I will provide it once I receive it. See the attached documentation from the previous failure, dated 6/3/2025, to establish a pattern of catastrophic drivetrain failure.

NHTSA ODI 11730946

I was at a stop light, when the lights turned green, I accelerated and heard a loud bang underneath the vehicle. The sound was so loud I thought I had been rear ended. I got out to inspect the vehicle and did not see any damages. I got back into the vehicle and put it in drive to get to the closed gas station. When I started driving, I heard clunking sounds underneath vehicle. I put on my hazards and drove slow. After about 50-100 ft the clunking sounds went away. No lights on the dash or anything. I then got vehicle towed to my father’s shop to inspect what was going or what happened due to not feeling safe driving. One of his employees looked up the cause of the noise and had found that the differential splines or transfer case would strip and cause a loud bang. Which happens on a lot of these acuras. He put vehicle on lift, and put it into drive. The front wheels would spin, but not the rear wheels. He said that indicates the transfer case is bad

NHTSA ODI 11730677

The AWD system failed and now its only FWD

NHTSA ODI 11729848

Experienced loss of all wheel drive with no notification, warning lights, etc. Vehicle is only in front wheel drive. Issue caused the vehicle to perform very poorly in inclement weather and myself, wife and children became stuck in the snow. The problem has been confirmed with Acura dealership. Currently it is in the shop awaiting further info.

NHTSA ODI 11729954