What 375 owners told NHTSA about the 2021 Toyota RAV4 Phev

I have been unable to get my vehicle inspected and repaired by a dealer despite months of waiting and asking two different Toyota dealers to order the necessary part or parts. This recall has been in place for years. For several years I was told it was only being done in certain states and that New Mexico would be last on list due to climate. Probably six months ago the message changed from Toyota and it was now ok in every state. Only problem is still no parts according to dealer. Last contact was on June 2, 2026 with the second dealer to order part. No call back and no contact. First effort was in Santa Fe NM where car was purchased new in 2021at Toyota dealer. Last effort over a month ago was at Albuquerque Larry Miller Toyota. So safety recall for faulty air bag sensor on my wife's side of car has been in place about 900 days without parts to fix a potentially deadly problem. VERY DANGEROUS

NHTSA ODI 11748297

The contact owns a 2021 Toyota RAV4. The contact was traveling at approximately 50 MPH directly behind a van in the same lane of traffic. The van suddenly made an emergency avoidance maneuver to bypass a stationary vehicle completely stopped in the lane. Despite the attempt, the van rear-ended the stopped vehicle. The contact immediately initiated an evasive maneuver to avoid the sudden collision occurring ahead. However, due to proximity and immediate lane obstruction, the contact was unable to avoid an impact and struck the vehicle. The severe front-end impact resulted in catastrophic damage to the contact's vehicle before it came to a complete stop. The airbags failed to deploy, and no warning lights were illuminated. The vehicle was towed to a repair shop. A police report was filed. The driver and her pet were the only occupants of the vehicle, and the contact was the only injured passenger. The contact sustained moderate chest pain, but no medical assistance was received. A police report was filed. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 62,000.

NHTSA ODI 11742969

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number 23V865000 (Airbags) however, the part to do the recall repair was not yet available. The local dealer was/was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was/was not made aware of the issue. The contact had not experienced a failure.  The VIN was invalid./The VIN was not available.

NHTSA ODI 11741263

Srs error appeared on the dash. Now the dealership is opening steering column to fix the electrical issue. The car has less than 29,000miles on it.

NHTSA ODI 11732503

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11731394

I was in a car accident that ended up being a total loss for my vehicle. I was hit head on to the front drivers side and none of my airbags went off. I am aware there was a recall for the passenger airbags, and was actually scheduled to get the repair the following week, but the drivers side airbags are not included in the recall. After the collision I received an error message on my display that advised there was an airbag malfunction and to contact my toyota dealer. Thankfully I did not sustain any known injuries, however I am pregnant and none of my airbags went off appropriately.

NHTSA ODI 11729459

The contact owns a 2021 Toyota Rav4. The contact stated that while driving on the freeway at approximately 35 MPH, another vehicle approaching from the opposite direction attempted to make a left turn and collided with the contact's vehicle. The point of impact was the front driver's side wheel well and side bumper area, with additional damage noted on the front passenger side bumper. No warning lights illuminated. The other vehicle was driving at an undisclosed speed and sustained damage to its front-end frame. There was no property damage reported. Both vehicles came to a stop in the roadway at the intersection of [XXX] and [XXX] in San Jose, California. The contact's vehicle remained drivable and was driven to the residence; towing was not required. The airbags did not deploy. The driver sustained injuries, including a fractured vertebra and a fractured sternum, and received medical treatment. The driver believes that the injuries may have been prevented if the airbags had deployed. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The contact related the failure to NHTSA Campaign Number 23V865000 (Air Bags). The failure mileage was unavailable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11727339

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, parts were not yet available for the recall repair. The local dealer was made aware of the issue and confirmed that parts were not yet available. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ODI 11711163

Very upset that the passenger air bag is defective and Toyota refuses to fix this issue, the recall was issued December 20, 2023! I can’t let anyone ride in the front passenger seat, if there was a car accident they might be killed or injured badly… Fix this issue Toyota… This is bad bad business… My mother is [XXX] and I can’t transport her anywhere because of the defective air bag. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11710211

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but no case number was provided. The contact had not experienced a failure.

NHTSA ODI 11708781

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, parts were not yet available for the recall repair. The vehicle was taken to two dealers but was not diagnosed or repaired. The dealers confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ODI 11708421

The contact owns a 2021 Toyota RAV4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not available. The dealer referred the contact to the manufacturer for additional information. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11705359

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted several times. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the front passenger's side seat had not been used since the recall notification was received. The contact had not experienced a failure.

NHTSA ODI 11703953

The vehicle is affected by Toyota Safety Recall 23TA15 / 23TB15 (NHTSA 23V865) involving the front passenger Occupant Classification System sensor. The recall notice states that the sensor may have been improperly manufactured, which could prevent the passenger airbag from deploying in a crash. As of 2025, the manufacturer continues to list the remedy as “not available,” far past the originally estimated timeline of Quarter 3 2024. This means the safety defect cannot be repaired, and passengers may be at risk if the airbag fails to deploy. The issue has been confirmed through Toyota’s recall lookup and dealer inquiries. No warning lights are present, so there is no way for the driver to know if the sensor is malfunctioning. The manufacturer has not provided parts, an inspection, or an interim repair. I am filing this complaint because the prolonged delay leaves the vehicle with an unresolved safety defect.

NHTSA ODI 11702583

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags ) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

NHTSA ODI 11702216

I was involved in an accident on the interstate traveling at about 80 mph and I hit a guard rail. I swerved, and then the lane assistance kicked in and made me lose control of the car completely, which is how I slammed into the guard rail. In that process, none of the airbags deployed and I had a passenger in the car.

NHTSA ODI 11700985

1. The passenger side airbag has had a recall notification since 12/3/23. It is now 11/8/25. 2. The life and safety of my passengers are at risk. 3. The problem has been confirmed by NHTSA recall notification on 12/3/23, and personal experience. 4. The passenger side airbag warning came on the day I bought the vehicle on [XXX] at CarMax in Oxnard, CA, and was about to drive my Toyota Rav4 XLE off the lot. I was told by the CarMax salesperson that it was because my personal bag on the passenger seat was not heavy enough to indicate an actual person and, therefore, not to worry about this warning signal, this was normal. This obviously was not normal as there has now been a recall of the passenger side air bag system by Toyota/NHTSA as of December 2023. It is now November 2025 and there is no remedy available yet by Toyota per the NHTSA website. Your website stated if no timely remedy is completed, to file a complaint. I am now filing this complaint due to the 2-year delay by Toyota in providing this life-saving remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11698330

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11695060

The contact owns a 2021 Toyota Rav4 The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11694171

It's been a while since I bought the car, but there's still no solution to the manufacturing defect. I hope there will be a solution as soon as possible for my safety. If I drive and the airbag does not open, if I get seriously injured, who will be responsible?

NHTSA ODI 11691990

The contact owns a 2021 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags). The contact had been calling the local dealer and was informed that parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that approximately two years ago, the air bag warning illuminated and remained illuminated whenever the vehicle was started. The contact had since stopped anyone from sitting in the front passenger’s seat. The manufacturer was not informed of the failure. The failure mileage was approximately 85,000.

NHTSA ODI 11691154

On May 1, 2025, my 2021 Toyota RAV4 Hybrid displayed an SRS Airbag malfunction warning (Recall 23TA15). The passenger airbag was disabled, making the vehicle unsafe to drive. Toyota had announced this recall in December 2023, but I never received any notification. When I contacted Toyota on May 9, 2025, I was told there were no parts available and was even offered a $200 paid inspection instead of a free recall repair. My vehicle remained at the dealership from May until September 29, 2025, without any available remedy. During this period, I continued paying my auto loan and insurance for a car I could not use. Toyota also failed to disclose my right to a free rental vehicle; I only received temporary rentals (Camry, later Tacoma) after repeated demands, and they did not meet my transportation needs. While the airbag recall was still unresolved, a second safety recall (25TD01 – Rear Traction Motor Cable Corrosion) was announced in mid-September 2025. This meant my vehicle had two active safety recalls at the same time while in Toyota’s custody. Both defects were only repaired at the end of September and early October 2025. Toyota failed to notify me in time, delayed the remedy for nearly two years after the recall announcement, concealed rental rights, and allowed my vehicle to remain unsafe under multiple recalls for months. An independent arbitrator has already issued a repurchase decision, confirming Toyota’s responsibility. This demonstrates a systemic failure by Toyota to comply with recall and safety obligations.”

NHTSA ODI 11691097

My 2021 Toyota RAV4 has been under airbag recall for over a year (starting around August 2023), and I have been unable to safely use my vehicle since then. Toyota has no estimated timeline for parts availability or repair, and the recall remains unresolved, they originally estimated October 2024, but that was nearly 1 year ago. Their provided timelines are now unreliable. I was provided a rental car, but it is not comparable to my RAV4 (smaller, less safe, lacks features like AWD and collision protection). Toyota has told me that if I accept the inferior rental, I will not be allowed to drive my own vehicle until the airbag is replaced — an indefinite period. I have contacted the dealer and Toyota Corporate repeatedly, but have been told there is no fix in the foreseeable future. Toyota has effectively deprived me of my own vehicle for more than 12 months, with no compensation, no buyback, and no acceptable substitute. This indefinite delay in addressing a critical safety defect (airbags) puts me and other owners at risk. I am submitting this complaint in hopes that NHTSA can hold Toyota accountable and accelerate a fix or require them to offer alternatives such as a buyback, permanent replacement, or compensation. The prolonged unavailability and loss of use of a vehicle due to a safety defect, especially with no viable end in sight, is unacceptable. Vehicle Info: - Year: 2021 - Make: Toyota - Model: RAV4 - VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11690376

I received notice of the recall for front passenger seat airbag sensors in Dec 2023, with assurances that it would be fixed by a certain quarter, which kept getting pushed out for almost 2 years now. I haven't received any further updates in the mail or email and had to call the dealer and Toyota directly to get any updates or info. They finally had an update that the remedy fix would happen in phases. I'm in CA and the last phase 8 which is estimated for Jan 2026. I do not have confidence that the fix will happen by then as these dates have continuously been delayed for 2 years. We've been driving our cars with a potentially unsafe situation for a long time. How will we as consumers really know when our car can be fixed?

NHTSA ODI 11689957

On 9/20, I started receiving a dashboard notification alerting me of an airbag system failure (see photo) - that was unable to be dismissed for longer than 15-20 seconds obstructing my odometer, speedometer and gas meter. On 9/23, I had an appointment and was informed my car needed a “clock spring assy”. My car is not driven frequently and not even four years old yet.

NHTSA ODI 11689159