What 295 owners told NHTSA about the 2021 GMC Yukon Denali Xl 1500

Engine shut down in 2022 due to faulty lifters. Repairs were made. Same problem again in 2026.

NHTSA ODI 11726226

The contact owns a 2021 GMC Yukon. The contact stated that while driving at various speeds, the vehicle shuddered abnormally with blue smoke coming from the exhaust, with the message "Lane Departure Assist" displayed. The check engine and stabili-trak warning lights were illuminated. The vehicle was taken to a local service center, where it was diagnosed with cylinder #1 misfire. The local dealer was contacted. The vehicle was not diagnosed or repaired. Upon further investigation, the contact related the failure to the GMC Service Bulletin:15-06-01-002L. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

NHTSA ODI 11725844

I had just pulled off from street light, hit button to turn auto engine shutoff off, all of sudden I lose power as if I'm in neutral, engines reving up but won't go. Then kicks in but with less power like gears will not shift. I get to my destination but car will not go in reverse.

NHTSA ODI 11722391

Exhaust fumes and stink on cold start . vehicle only has 40,000 mi and I have exhaust smells coming in through hvac system!!

NHTSA ODI 11722482

My vehicle started making a weird noise and when I took it to the shop, they told me my crankshaft has gone bad and I was lucky I caught it before the entire engine blew

NHTSA ODI 11722330

My 2021 GMC Yukon suffered the same engine failure that is the subject of the recall. It has just over 70,000 miles. I'm now told I need a new engine. The dealer confirmed that this is the same issue that has impacted other similar vintage Yukons.

NHTSA ODI 11720183

Oil consumption is an issue. My vehicle is using a quart of oil every 1,000 miles. Manufacturer says oil changes are 5,000 mile intervals, however at 2500 miles the dipstick is dry and the low oil light comes on. There are no leaks in the driveway, nor is it smoking. The manufacturer claims this is normal. If I were to wait the 5,000 miles for an oil change I would only have three quarts of oil left in an engine that is supposed to have 8 quarts and therefore my engine would lock up. I fear that this engine will fail and I travel with our daughter all over the state of MO and OK for horse shows and do not wanted to be stranded on the interstate with my child in the car. After much research it is obvious this is a common problem with the 6.2L engines. There is an abundance of videos, forums, chats, etc stating how widespread this issue is and that GM continues to put off developing a fix or replacing the engines. We just completed an oil consumption test with the dealership and they are going to submit it to the warranty company. However, our fear is they will deny it saying it's a GM issue and kick it back to us.

NHTSA ODI 11719710

2 days after the delearship changed my oil to a heavier weight, my engine began knocking. I’m told the rod is bent but not covered by warranty

NHTSA ODI 11715102

I had the 25v-274 recall serviced at my GM Dealer and was never provide with any paperwork on the extended warranty that was part of the recall. as you can image, not having anything in writing is a big risk as these engines have been catastrophically failing. GM was supposed to provide a extended warranty and service manual update.

NHTSA ODI 11713956

The engine has started using large quantities of oil. Not dripping oil, burning oil. I have been doing oil consumption studies with GMC for months now. It burned 7 quarts in 5,000 miles. The dealership tells me it is not part of the current recall on others with the same engine, make and model. It is doing the same thing as what the recall is for and my VIN number should be added to GMC’s recall list and the motor replaced. It is a serious safety issue for me and my children,

NHTSA ODI 11713798

NHTSA Team, I am the current owner of a 2021 GMC Yukon Denali (VIN: [XXX] ) with the 6.2L L87 V8. At approximately 148,239 miles, I experienced a catastrophic lifter failure. My mechanic diagnosed a failed AFM lifter and metal contamination, requiring full engine replacement. This is documented under GM Case #XXX. CARFAX revealed that prior to my ownership, lifters were replaced twice (~10,469 miles and ~25,572 miles). The dealership I purchased from did not disclose these prior repairs, as they used an alternative vehicle history check. Only upon this third lifter failure did my mechanic identify this recurring defect. I submit this to NHTSA’s investigation into post-repair failures of the GM 6.2L engines. The pattern shows prior remedies were insufficient. Supporting documents (CARFAX, mechanic report) are available. Please advise if further details or inspection of the failed engine components are needed. Thanks, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11713397

I habe a 2021 Yukon Denali and i have had engine failure on the road. Lifter issues and rod issues. i have paid out of pocket to fix it because my truck wasnt part of the recall. But i had the first failure in November 2024. Second failure January 2026.

NHTSA ODI 11713181

Loss of power while driving, no warnings, no lights on dash, no unusual noises, and no codes. The Yukon just randomly went into neutral while driving 65 mph and "Press Start Again" popped up on the dash. I struggled to get the truck to the side of the road safely. After getting the truck into park it started back up, and I was able to make it the 3 miles home. I scheduled it to go into the dealership as it still is making no noises, and had no engine light or codes, about 2 miles from my house it shut off again while driving, only this time when it restarted it now has a ticking sound coming from the engine however no warning lights and no codes being displayed. I am reporting this as I believe it falls under the open investigation EA25007, although it clearly is the same failures others have experienced on models that were included in the recall 25V-274. I am also attempting to contact GM as my vehicle is no longer under the powertrain warranty that was not extended for the vehicles that were not included in the recall.

NHTSA ODI 11712076

Internal engine failure Car just shut off on expressway, putting the safety of my husband and child at risk. Waiting for a tow at 12:30 in the morning. Problem has been confirmed by dealer. No warning lamps or warnings signs prior to failure. Car just shut down and was not able to start again. Had to be towed!

NHTSA ODI 11711984

I have a 2021 GMC Yukon with 74,000 miles I was recently told I need a new transmission.I am am trying to understand why a car that is 5 years with all the services done by Lehman GMC in North Miami would need a new transmission they have been servicing this car and no one mention anything breaking down of need of repair until now. I spoke with the service manager Franklin and he stated to me another client had the same issue and he flush the transmission just like I am doing today and it only worked for a short time and afterwards he had to replace the transmission. I feel this is a problem with these models and GMC don't want to address it. they just want the customer to pay for the repairs. Now I spoke to the Manager and the salesman that sold me the car and nicely told me he was sorry and he could get us out of this into a 2026. Now why would I buy a new car if they cannot get the 2021 right. I have included my invoice below I feel some one should look into this I feel this is a recall matter and GMC is trying to pass the buck. Thank You [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11710688

I was driving down the highway at normal speeds under normal conditions and the engine light came on and started flashing. By the time I could find a safe place to pull over I heard the engine knocking. Left my wife, two young kids and myself stuck in the middle of the road with traffic coming. Managed to get it out of the road before going to get my truck and trailer to tow it home. I assume this is due to the L87 recall but mine was built in 01/21 and the recall is said to cover 03/21 and up. We don’t really know what to do at this point being its my wife and kids only way to work and school.

NHTSA ODI 11710038

On [XXX] driving to Denver the 52,000 mile yukon started making a clicking sound when accelerating on the interstate. Traction control light came on as well as the check engine light. Low power was noticed and we immediately pulled over as it sounded like it was going to blow up. Towed the vehicle 145 miles where we bought it and the shop confirmed the lifters and 5th cylinder are the issue and that the cams could be damaged. Recommend replacing each side. The car is basically new and under the 60K drive train warranty but about 100 days past the 5 year mark. Terrible timing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11709435

I was driving and a message popped up "Service Traction Control", then another message popped up "Forward Collision System Unavailable". Then the car started making this knocking sound and every time I would try and accelerate there would be a loud sound and almost a pulling stopping it from picking up much speed. I took the car into the dealer/repair shop and they said it was an issue with the lifters that had to be replaced and potentially an issue with the cam. They said this repair would cost upwards of $6,000 and I have never had this issue with the car before. This came out of nowhere and the car had not been showing any signs of this occurring before. This is a 2021 GMC Yukon and I drive my Wife and three sons in that car daily.

NHTSA ODI 11709048

On Christmas Day while driving on the highway, I noticed a ticking sound coming from the engine. Our 21 Yukon Denali just hit 85,000 miles. I first noticed the traction control light was became disabled and then the check engine light started flashing. The sound escalates when you step on the gas. It appears that the lifters and cams are damaged on the vehicle and had to be towed to a dealership were it currently waits to avoid further damage. I was advised by the dealership that this particular vehicle is not part of the engine, recall notice, but heard that they might be expanding vin numbers to the recall as more incidents occur. They did confirm that the lifters and Cam’s are the issue.The vehicle has had a great maintenance record and was just at the same dealership five weeks earlier for oil change.

NHTSA ODI 11708634

Driving the vehicle on the highway when I started to hear a ticking sound from the engine. After a few minutes, the check engine light came on and started flashing, traction control shut off and some system related to the rear end shut off. After inspection, it appears to have dropped a lifter.

NHTSA ODI 11707664

The vehicle shifted into Neutral while driving, locked out gear selection, triggered a transmission warning, and now will not restart.

NHTSA ODI 11707247

traction control system ESC system Suddenly and without warning, multiple warning lights started flashing including check engine. The vehicle lost power and traction. There was a loud knocking and metallic whining sound. The vehicle began to vibrate and struggled to move forward and felt like the wheels were slipping. The loss of these functions was alarming because it was dark, we were in a construction zone, and my 15-year old daughter was driving having recently earned her driver's permit. The car following us almost rear ended us. It was such an abrupt engine failure it scared me and my daughter.

NHTSA ODI 11707007

Freedom, tire and automotive Inc. advised my 6.2LV8 engine has failed due to metal debris found in the new oil, indicating a mechanical failure of an internal engine component. I called GMC and they referred me to you.

NHTSA ODI 11705091

At the time an oil change is needed, there is a warning light that says "low oil pressure and low oil." There also has been a "slipping" of the engine at around 60mph. GMC dealer states it is a torque converter. I am worried that the engine will fail or stall while driving The fuel pump control module has been replaced. Motor is not covered under the current motor recall and taking vehicle to transmission shop to have it checked as well

NHTSA ODI 11704618

Engine failure

NHTSA ODI 11703867