What 106 owners told NHTSA about the 2021 Ford Ranger (super Cab)

The contact owns a 2021 Ford Ranger. The contact stated that the back over prevention camera screen was either blank, frozen, or reversed. There were no warning lights illuminated. The vehicle was taken to the local dealer to be repaired under NHTSA Campaign Number: 25V442000 (Back Over Prevention). The vehicle was repaired, but the failure recurred. The contact was informed about a possible diagnostic test and repair cost. The manufacturer was not contacted. The failure mileage was approximately 50,000.

NHTSA ODI 11697876

The boot material surrounding the parking brake bunches up and does not allow the handle to properly seat. When using the cruise control, the parking brake handle will raise up on its own, due to the boot material, causing the cruise control to abruptly disengage. This causes the vehicle to mildly to moderately deaccelerate without warning. This could cause rear end collision.

NHTSA ODI 11698044

The Factory Driver's Side Floor Mat does not stay snapped in. This causes the Floor Mat to slide forward towards the pedals. This causes the Floor Mat to lodge underneath the accelerator pedal, which can cause an inability to accelerate. The Fllor Mat could also lodge undermeath the brake pedal, not allowing the full use of the brakes.

NHTSA ODI 11698045

Rearview Camera: Intermittent loss of rearview camera functionality when placing vehicle in Reverse. Affected roughly 50% of the time. When occurs, image is distorted for a a few seconds followed by a "camera is unavailable, please contact dealer" message on the display. Started occurring at around the 45,000 mile mark and has continued to occur with increasing frequency now at the 90,000 mile mark.

NHTSA ODI 11695982

Existing TSB related incident. While driving 45mph transmission began to disengage and free rev. Vehicle wouldn't/ couldn't select a gear. Speed dropped to 30 (in 45mph zone) Put hazards on until i could safely pull over, was almost rear ended.

NHTSA ODI 11691102

The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle suddenly stalled. The contact indicated that the failure had occurred while turning at a busy intersection. The vehicle was towed to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 86,000.

NHTSA ODI 11689503

2021 Ford Ranger with 10R80 transmission showing following codes P0733 P0734 90,000 miles on truck. jerky and slipping gear change between 3-4 and 5-6 occasionally no drive. have service records showing my truck was maintained properly.

NHTSA ODI 11673377

transmission disengaged on highway causing very dangerous driving condition. There is a Ford TSB 25-2134 issued on 4/15/2025. I am told it is a transmission pump failure and would require a very costly transmission replacement. I am within the time limit of my warranty, but just out of range on my distance warranty.

NHTSA ODI 11669924

The contact owns a 2021 Ford Ranger. The contact stated while attempting to accelerate, the transmission malfunctioned, causing the vehicle to hesitate while accelerating. The contact stated that the vehicle accelerated at reduced speeds. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 91,000.

NHTSA ODI 11668847

Several warning lights, which included: ABS failure, Parking Assist Failure, Lane Avoidance Failure, Traction Control Failure, as well as having steering difficulty. ( mileage 24500 ). The problem was found by dealer to be an eletrical connector underneath the vehicle at the mid point, with their belief that it was corrosion, which I believe to be a defective component and design. I contacted Ford but they were not interested in retrevale of the connector, so as to diagnose the failure. ( I am keeping the connector )

NHTSA ODI 11668605

I nearly hit the back another vehicle stopped for a red light when my foot caught the edge of the gas pedal. The brake pedal depresses passed the height of the gas pedal. I understand this is a commonly reported Ford ranger issue . I understand a brake bleed software procedure will fix the problem . There apparently is a Ford TSB regarding soft brake pedal issue. I bought the truck new in 2021 and have less than 6000 miles on it. I thought the braking was normal . The bumper to bumper warranty I'll not cover brake issue due to the 36000 3 year coverage.

NHTSA ODI 11667128

When I accelerate after a stop my truck starts jerking when shifting thru lower gears and the check engine light flashes. To increase my speed I have to slowly press the gas until it shifts thru gears. After it shifts thru the lower gears it appears to be okay. It doesn't do it at each stop but is now happening more frequently. I don't know if it's a transmission problem or fuel pump. Current mileage is around 62000. If I'm on the highway it will sometimes start jerking while the using cruise control and I have hit the brakes and take over acceleration. I've now parked the truck because dealer cannot get to it for 3-4 weeks.

NHTSA ODI 11665453

The contact owns a 2021 Ford Ranger. The contact stated that while driving at various speeds, the vehicle hesitated and jerked while depressing the accelerator pedal. The contact stated that the transmission unexpectedly downshifted before slamming into gear. There were no warning lights illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact was informed by the dealer to call the manufacturer for assistance. The manufacturer was notified of the failure, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 59,000.

NHTSA ODI 11664952

The contact owns a 2021 Ford Ranger. The contact stated while reversing, the back over prevention system failed to function as intended. The contact stated that the message to “See the Dealer for Repair” was displayed. The back over prevention camera system had displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with a failed rear-aide back-over camera. The contact was informed that the back over prevention camera system needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall however, the VIN was not included in the recall. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000. The VIN was unavailable.

NHTSA ODI 11664335

Transmission needed to be replaced before 50000 miles. Finally got replaced at 53000. New transmission has 11500 miles in it and is having the same problems as before. Dealership couldn’t replicate the problem and Ford is unwilling to help. Truck rough shifts, clunks, and shudders. At times won’t go into gear at lower speeds. Turned a corner at a slow speed and hit the gas but the truck wouldn’t accelerate for 1-2 seconds and I was almost rear ended by the car behind me. Truck has failed to go into gear and accelerate in traffic more than one time. 4 years old with 64xxx miles and in need of a third transmission.

NHTSA ODI 11664428

Transmission looses power when accelerating, usually between 2nd - 4th gears. This is an safe condition when I am entering traffic on highways. No warning lights have appeared.

NHTSA ODI 11656541

Right rear leaf spring was found to be broken on vehicle 2ith 70,000 miles by Ford technician during oil change. I was informed that it was not a recalled defect, repair part was on back order and was not advised as to the safety of driving the vehicle.

NHTSA ODI 11653091

It started moth my vehicle losing power and chugging , dealership diagnosed as transmission (10 speed ). After all of the Ford appointed tasks to fix said problem, valves were replaced , did not work then entire transmission was replaced . After 7 times in the shop and many missed work hours . Maybe 2 weeks later truck starts bucking as I enter the highway , was close to getting rear ended . Brought vehicle to dealership 2 weeks later diagnosed with the turbo going out in it . And then Friday 3/14 driving home from work the check engine light comes on. Says emission issues ? Also says need to service engine soon . Dealership says it is fine to drive they will call me when they can figure it out ? My vehicle ha less than 25k miles these issues started when I had 17k on it Started 8/5/24

NHTSA ODI 11648759

2021 Ford Ranger Transmission slipping during driving . causes vehicle to jerk during shifting in gear 3, 4, 7, which causes the vehicle to jerk also during down shifting it shifts very hard. i looked online and apparently ford will not issue a recall because they will lose money on all the repairs they must do. if they changed the rings in the 2022 transmission they are aware of the issue obviously but refuse to address the problem. for us 2021 owners we are fucked. 9000$ repair for us.

NHTSA ODI 11644977

Everyone that I have talked to that owns a 2021 Ford Ranger have transmission issues including me. Clunking/ jumping/ and very harsh shifting..

NHTSA ODI 11639523

Transmission failed at 65000 miles on a one owner vehicle. Conveniently just after the warranty expired. Cost to fix transmission $9000.00. Those transmissions are faulty and many people are experiencing problems.

NHTSA ODI 11637974

While driving the vehicle started to act like it could not find a its gears in the transmission and made a loud clunk then stopped moving attempted to put it in reverse and it sook a minute before it shifted and made another loud clunk then lost both forward and reverse. Currently at ford getting a new transmission. Vehicle stopped moving while driving and hard to get off the road, No warning lights came on in the vehicle.

NHTSA ODI 11637069

It wearing tires on the inside quicker the it should. The dealer aligned and said it was with in specs.

NHTSA ODI 11635975

The wrap material on the front driver side and passenger inside door handles is separating and is very sharp. I noticed it a couple of days ago when I went to get out of the vehicle and I reached to open the door, and it sliced open my finger. I told my passenger what had happened, and he checked the passenger side inside door handle, and he said that his was the same way.

NHTSA ODI 11635292

Increasingly the transmission, when cold, was experiencing difficulty shifting between 3-4-5 and not shifting into 9-10. When the weather started reaching zero degrees overnight, the vehicle was reluctant to move and, once it began moving, would not shift out of 1st. After allowing the vehicle to warm up, it would reluctantly shift from 3-4-5 and then, without any speed reduction, suddenly downshift with a shudder and bang. Vehicle is in the Ford dealer while they preform the TSB related to this universally known problem with the 10R80 transmission. Despite the TSB “approving” significant part replacements, including clutches, modules and converter, the dealer is required to proceed a few steps at a time and then test the vehicle to document the need to replace more components, before proceeding the the TSB. Ford is avoiding what should be a full recall involving providing the dealers with a rebuilt transmission and converter with the dealer’s responsibility only being the replacement of the transmission. Ford’s dealing with this very well know problematic transmission with a TSB is grossly unfair to the dealers and exceedingly unfair to the consumers who eventually bear the financial burden.

NHTSA ODI 11631609