What 28 owners told NHTSA about the 2020 Volvo XC90 T8

I was driving when a turtle popped up on my dashboard I pulled over to Google what that meant and popped the hood cause I seen a little smoke within 3 sec the car busted in flames I ran back and grab my daughter out the back seat we were almost locked in due to the car melting the wire and flames started coming inside the car

NHTSA ODI 11735004

The contact owns a 2020 Volvo XC90. The contact stated that while his wife was driving at an undisclosed speed, the vehicle experienced unintended acceleration while the brake pedal was depressed, causing the vehicle to crash into a parked vehicle. The contact's wife did not sustain any injuries, and no medical attention was received. A police report was filed. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.

NHTSA ODI 11464084

I was driving the speed limit on the highway in my Volvo 2020 XC90 which was less than one year old. The vehicle lost acceleration power and then an engine performance light came on, then a check engine light. I pulled over immediately and my car engine caught fire under the hood. The entire front of vehicle was engulfed in flames within minutes. There were approximately 11k miles on the car and it had never been maintenanced or worked on in any way that would have caused an engine fire. It was clearly a fuel line fire and Volvo did not properly investigate. My insurance company said it was a fuel line fire but could not get information from the black box because it was destroyed. This car is incredibly unsafe and should be recalled. I have multiple videos and case files concerning this "thermal event". Volvo recalled this car in Europe because of this issue and says there are none in the USA.

NHTSA ODI 11432078

ON FEBRUARY 5, 2020 I WAS INVOLVED IN A MINOR FENDER BENDER WHICH RESULTED WHEN I DROVE OFF ALIGHT AND THE CAR IN FRONT OF ME DID NOT TAKE OFF AND I HIT IT IN THE REAR AT A VERY LOW RATE OF SPEED. THE AUTO BRAKE DID NOT ENGAGE. I WAS NO MORE THAN ONE AND A HALF CAR LENGTHS BEHIND AND THE CAR WAS MOVING AT ONE TO TWO MILES PER HOUR. WHEN I HIT THE REAR OF THE CAR IN FRONT OF ME THE AIR BAGS DEPLOYED WHICH CAUSED ME TO HAVE A SLIGHT CONCUSSION AND CERTAINLY SCARED ME. THERE WAS LITTLE IF NO PHYSICAL DAMAGE TO THE VEHICLE. I CONTACTED VOLVO CUSTOMER CARE A FEW DAYS AFTER ADVISING THAT AUTO BRAKE SYSTEM DID NOT ENGAGE AND THE AIRBAG DEPLOYED. THE REPORT WAS TAKEN. I WAS ADVISED THAT THERE WERE NO PRIOR REPORTS OF THIS ISSUE. VOLVO REPAIR WAS NOT WILLING TO ACKNOWLEDGE MY CONCERN AND WOULD NOT CONFIRM THAT PRIOR TO THE REPAIR THERE-WOULD BE A REPAIR. CANDIDLY THEY WERE NOT GOING TO DO ANYTHING EXCEPT ACCEPT INSURANCE CHECK AND FIX IT. I NOW HAVE RECEIVED A RECALL NOTICE FOR THIS EXACT ISSUE WHICH I HAD REPORTED. I ADVISED THEN I WAS AFRAID OF THE CAR BECAUSE I WAS AFRAID THE AIRBAG WOULD DEPLOY UNNECESSARILY AGAIN. HOW DO I ADDRESS THE FACT THAT I WILL NOT USE THIS CAR ANY LONGER.

NHTSA ODI 11322553