What 132 owners told NHTSA about the 2020 Volkswagen Tiguan Ltd

The contact owns a 2020 Volkswagen Tiguan. The contact stated that the interior overhead console had become detached from the interior roof of the vehicle. The contact used tape to temporarily secure the console. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 40,000.

NHTSA ODI 11675112

The overhead console came loose while parked during a heat wave and over the course of a day, it ended up hanging by the wires needing to be held up while driving. It blocks the rearview mirror, has exposing wires and swings around. This occurred during a heat wave. It seems that the plastic holding the screws melted, causing it to fall off. There are no warning lights or sounds and were none prior. Warranty states they do not cover this damage. Many others online say this happened to them with the same vehicle.

NHTSA ODI 11669694

It appears that my Volkswagen Tiguan is experiencing an issue where the fuel nozzle shuts off prematurely during refueling, requiring multiple attempts to fill the tank completely. There have been no recalls on my vehicle, but it is getting to the point where I can barely fill my tank up due to prematurely shutting off. This has been an ongoing issue

NHTSA ODI 11664618

The overhead console is falling off due to weak plastic brackets in the housing. This overhead console failed over time with no contact and seems to be a big issue for many 2020 Tiguan owners. The console hanging down creating a driving hazard. There are many forum discussions laying out the issue and VW will not repair.

NHTSA ODI 11663926

Aftermarket headlights were purchased online. Manufactured by AKD Aokeding in China. The headlights were installed by a ASE certified tech. The left low beam light went out within minutes while driving. Headlights were removed and internals inspected. The construction of these lights are very unsafe and would not meet any manufacturer specs. Not sure how these headlights would pass any safety compliance. The internal components were loose, unsecure and fragile. The wiring used was very thin approximately 28/30 gauge diameter. Right side headlight displayed excessive heat. These lights and company products need further review for further sales to the U.S. Other complains are online about this manufacturer.

NHTSA ODI 11656671

After sitting in the hot sun for an hour or so, turned it on, and got a "check starter" warning, and all the dash instruments went off. No lights, turn signals, brake lights. Radio worked, windows worked for a bit, then nothing. Had power steering and brakes. Had warning lights on the mirrors. No AC/heat. Speedometer, tach, fuel, temp, display - all off. Car still ran. Found issue to be a faulty ignition switch

NHTSA ODI 11656447

Car-Net module that connects with emergency services keeps failing. This part has failed 2x on my vehicle and it is not even 5 years old yet. A simple internet search shows that this is a known issue and is experienced across models and production years for Volkswagen vehicles.

NHTSA ODI 11651801

The vehicle has had repeated failures of the oil filter adapter to block gasket. This gasket has been replaced three times in 41,000 miles. There appears to be a failure on the part of the gasket. The vehicle has been repaired for the third time, the gasket remains with the dealership where it was repaired. I do have photos of the gasket. A catastrophic failure would result in radiator fluid pouring out of the vehicle, causing the vehicle to come to a complete stop, regardless of location. This problem has occurred three times within 41,000 miles. The part has been inspected b the mechanic who replaced it. There is no warning other than to watch for leaks.

NHTSA ODI 11651601

SOS malfunction light came on after downloading & syncing the car with the MyVW app. I took the car to the dealer & they said the module needs to be replaced & it would be $1500 because it’s out of warranty but it seems like in 2021 VW replaced it for free because it’s a known issue. I did not purchase this car until 2024 so it’s not covered. There are multiple people noting the same issue on online forums.

NHTSA ODI 11645924

Car exhaust is under car and does not come outside of under the car. We were in an accident and were told that because there are now cracks and gaps under the car that the exhaust is leaking into the body of our car and could cause co2 poisoning. If the exhaust were not under the car there wouldn’t be a safety concern

NHTSA ODI 11626981

Control panel on the ceiling of the car (holds the sos button, controls for sun roof) fell off and was hanging on by wires. Dealership said it was defective clips GPS in car and through car play also does not work. Navigation shows car significantly off course. Vw said it was a Verizon issue, but it has not been resolved

NHTSA ODI 11626979

Passenger door (front) will not open with fob or door lock/unlock button. You can not open the door from the outside. Driver has to reach across to use the door latch. Won’t unlock with app either.

NHTSA ODI 11624369

Center overhead console had a catastrophic failure of the brackets holding it in place on the ceiling of the car. This resulted in the full console dangling from the ceiling of the car by wires only. This blocks driver view, the rear view mirror, and swings into driver and passenger headspace. Contacted the dealership and was told this is a common problem. There was no warning before this occurred.

NHTSA ODI 11618546

In my VW Tiguan, the sunglasses component that has the lights, the sunroof buttons, and hands-free microphone, dropped from the roof at the end of the day. It was one of the more warmer days that this happened on and I took it into the VW dealership to have them look at it the next day. The whole component blocked my ability to see and caused blind spots. The dealership gave me the car back with the light component taken out and everything else taped up. This caused a problem to not be able to see out of my rearview mirror. The dealership told me two weeks ago on 9/20 that until the part comes in, which is backordered and I still have an unknown timeframe of it coming in, I will be riding around with it taped up. I have found it difficult to drive even with it taped up because it will come down when the tape gives up. I am unsure of what the cause of it is, but know that this has been our hottest summer in the South since I've had my car.

NHTSA ODI 11618159

The GPS in this vehicle constantly gives wrong information and directions. It has consistently shown wrong directions and has tried to make me turn around on the freeway and has sent me down one way streets. This is much more serious at night when a person can’t see road signs and depends on the built in GPS.

NHTSA ODI 11614889

I have been experiencing a noticeable delay in throttle response when accelerating, particularly when attempting to slowly merge into traffic. For example, when I press the accelerator to make a left turn, my Tiguan hesitates for approximately 2-3 seconds before responding, creating a significant safety concern as I find myself stuck in oncoming traffic. I took the vehicle to the dealership for diagnostic testing, but no fault codes were detected, and no warning lights were illuminated. To demonstrate the issue, I had to conduct a test drive with the mechanic. Following this, the mechanic escalated the issue to the quality engineering team at Volkswagen. They acknowledged that they were aware of this problem but stated that there is no available fix. I was advised to use top-tier premium fuel and switch to manual mode to potentially mitigate the delay. When I escalated this issue to the VW Customer Care, they claim that it is operating as designed and no repairs would be made. I suspect that this issue stems from a defect in the vehicle's control software, which VW appears to be aware of but has not addressed with a permanent solution.

NHTSA ODI 11613027

The overhead console hangs down with wires blocking my rearview mirror and creating a blind spot on the right mirror. Volkswagon in Colorado told me that the console replacement part is on a national back order with no ETA at the time. My safety and the safety of others are put at risk because the overhead console swings while I am driving, which is a major distraction. I have to use one hand to keep the overhead console where it's supposed to be so I'm driving with one hand. Additionally, it blocks my view to my right mirror, impeding me from doing lane changes. Yes, it's been confirmed in writing from my local dealer and they are well aware of this problem because it's occurring all over the US with 2020 VW Tiguan cars. Check out this website: [XXX] Yes, my Volkswagen dealer has inspected it, however, they did not repair it because they did not have the console part. No, there were no warnings--it happened suddenly and by itself. The overhead console is made of cheap plastic and likely started dangling due to the summer heat waves which weakened the console. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11613157

I currently reside in Texas where it get HOT during the summer months. I recently got this car back in May. Recently when it’s hot outside my car had cut off one day in traffic and said please check starter system. All electrical components of the car shut off completely. The engine will start run. But the AC, lights, back up camera, windows stop working. I have an appt to drop the car off at the dealership. I been seeing this is an ongoing problem for. VW vehicles I have seen multiple stories about this happening mainly in 2019-2020 jettas. This needs to be an investigation on VW and this problem.

NHTSA ODI 11609526

The center overhead console fell down (controls dome lights, sunroof, & other convenience features). Thankfully, no one was driving but it could have caused a serious issue if we had been. Many other VW Tiguan owners have experienced this issue, sometimes multiple times.

NHTSA ODI 11607853

I came out of the Walmart and got into my car and the Overhead Console was Detached hanging by electrical cords in front of the rear view mirror. Drove to the Antwerpen delership before they closed and was informed it detached due to HEAT????? Seriously, heat! Have an appointment on 08/07/2024. It appears this is happening alot around the US. Google it

NHTSA ODI 11606411

The overhead console fell down and was hanging by the cables connected to it which control the sunroof motor, SOS system, Info button, rear interior lights and driver/passenger dome lights. It hangs between driver and passenger at roughly 4 inches from the roof and obscures peripheral vision and usage of the rear-view mirror. Finally, if it occurred while driving it could easily have caused an accident.

NHTSA ODI 11606476

The interior overhead panel fell down when the car was parked in the garage. There have already been a lot of owners complaining the same issue on VW's forum: [XXX] There was no any incident that may cause this prior to this. It looks to be the bolts attaching the console were over-torqued. If this happened during the drive, it posted hazard to the driver because there will be a hanging panel blocking the driver's vision. We went to the VW yearly maintenance and nothing was done to fix the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11604810

As you own the car for three years, my overhead panel on the roof of the car has attached itself from the car and is hanging in front of the rearview mirror by the cords. There’s also affected the GPS and electrical in the vehicle.

NHTSA ODI 11600415

My 2020 Tiguan was purchased used about 10 months ago. We moved from RI to CA and the overhead console has completely fallen down and is hanging by the wiring harnesses. I have contacted the dealer and corporate. They do not want to make the repair because it is out of warranty. Upon further investigation It appears that this is a common issue effecting many other 2020-2023 VW Tiguans. This is a safety concern as it obstructs my view from the rearview mirror as well as my line of sight out the windshield. I have a newborn child and bought this car because of the reliability and safety features. A separate issue, but there was a class action lawsuit pertaining to the EBS (Emergency breaking system) not functioning properly. This has not been the best experience and I thought VW would stand behind their product, sadly this has not been the case.

NHTSA ODI 11600620

I am writing to report a serious safety concern regarding my Volkswagen Tiguan 2020. The dome light in my vehicle has completely broken off, melting the plastic from the screws, and was hanging by the electrical wires. This issue poses multiple safety hazards: 1.Injury Risk: While driving, the dome light unlatched and fell and struck me on the side of my head, causing a distraction and injury. 2.Visibility Obstruction: When the dome light is hanging, it completely blocks the view through the windshield and rearview mirror, significantly increasing the risk of an accident. I have taken my vehicle to the dealership, and they confirmed that this is a common problem with this model. They have seen and replaced the dome light on many other vehicles of the same model. Despite this being a known issue, there were no warning lights or indicators to alert me to the impending failure. This indicates that the parts used are faulty and pose a significant safety risk. I urge the NHTSA to investigate this issue promptly and consider issuing a safety recall for Volkswagen Tiguan 2020 vehicles to prevent potential accidents and injuries. Thank you for your attention to this serious matter.

NHTSA ODI 11600088