What 298 owners told NHTSA about the 2020 Toyota Highlander

It’s been a known issue that Toyota Highlander has transmission problems under 100k miles from 2016-2021 or later (social media sites confirmed such). My vehicle require a trans axle replacement as well as the struts are leaking oil and my vehicle has less than 62k miles and is only 5 years old. This is being covered under my extended warranty but parts are on back order After doing research many owners complain about a whining noise showing acceleration of vehicle . If left unfixed this leads to transmission gears slipping and eventually needing an entire replacement Some owners also complain about leaky struts. My car has an issue with leaky struts and is being fixed under warranty Some owners say they need an entire new transmission and after that is replaced the rear transaxle goes and needs replacement Toyota is not putting a recall on this but it’s a known issue. Owners are asking to have this put out as a recall by toy. All parts are on back order and takes several months before transmission can be repaired or replaced. This tells me there are hundreds if not thousands of Highlander’s having the same issue This is a Toyota problem and is related to building transmission in the factory..recall the older vehicles and do better in the factory

NHTSA ODI 11666679

At around 61,000 miles, I noticed a whining sound in the vehicle when accelerating. I took the vehicle in to a Toyota dealer for diagnostics and their technicians indicated that my vehicle had transmission failure and it needed to be completely replaced - quoted at $8,000 to do the replacement. Diagnostic appointment also cost $174. Parts are on back order and no one could tell me when parts would come in - guess was one month. In reality, parts are now finally in (I'm about to take it in to be fixed) after 2 months. I was told by the dealership that I could drive it at my own risk of failure - if it were to fail, I would be stranded wherever that may be putting my family and those around me at risk due to the unknown nature of when that could happen. This failure is recorded for the same model and same UA80 transmission on several online forums: [XXX] The vehicle has been inspected by a Toyota dealer as I stated previously. Diagnostic report says "Internal component failure. Recommend transmission" No other warning lights or messages from the car to warn me of this problem even now. Just the whining sound from the failure itself. Keep in mind, Toyota's powertrain warranty period is 5 years or 60,000 miles - this vehicle just surpassed both of those limits as this problem came about. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11666696

Whining noise from the transmission after 66K miles - Change fluids still no improvement - Known issue with UA80 transmission . Dealers knew of the issue but still sold cars

NHTSA ODI 11666429

Final drive failing in transmisssion

NHTSA ODI 11665175

8 speed automatic transmission started whining at 45k miles (purchased new), has been inspected, dealer confirmed transmission is bad and part is on back order (date keeps moving out),

NHTSA ODI 11662250

Began hearing a high-pitched whining sound when I accelerated. Took it into the dealer and they casually told me that I needed a new transmission. My car was less than four years old, but had more than the 60,000 miles that would apply under a warranty. I am now reading online. This is a widespread problem involving Toyota Highlanders. Can’t get a new transmission for three months or more.

NHTSA ODI 11660920

2020 Toyota Highlander l developed a whining noise and after extensively researching this sound it seems like its common on highlanders with the UA80 transmission and leads to transmission failure. There is a Toyota forum where owners have gathered about this issue not only for this year highlander but early models when the specific transmission above started being used. Quotes to replaced this transmission range from $6,000-$13,000 at the dealer. Toyota has been called and they have been of no help to anyone. Even worse it seems all places are backordered on these transmissions and owners are left without a car. To quote a toyota member who called to get hemp with the issue, this is what Toyotas response was: “ Toyota refuses any support stating that "we can't predict an average life expectancy for any specific part of component", This only means life expectancy on their parts does not exist? Shouldnt they have a target life expectancy on parts? A lot of dissatisfied toyota owners as toyota is hiding from this issue.

NHTSA ODI 11660304

Around 90,000 miles, the transmission has started to whine really bad. This seems to be a common problem with this 2018 to 2021 Highlanders, but 2020 has no recall or service bulletin. My mechanic priced a transmission from a dealership and was told it would be 3 months at least to get a reman transmission. There is a good chance of catastrophic failure before we can get a new transmission installed.

NHTSA ODI 11658280

At about 85,000 miles, the transmission developed a whine noise, and two dealers and a transmission shop all state it needs replacement. However, the backlog for replacement is enormous and I risk the transmission failing catastrophically while driving.

NHTSA ODI 11656331

The contact owns a 2020 Toyota Highlander. The contact stated while driving at undisclosed speeds, there was a whining sound coming from the transmission. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the internal bearings had failed, and the transmission needed to be replaced. The vehicle was not repaired. The contact referenced Technical Service Bulletin: TSB-0008-21 as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 99,000.

NHTSA ODI 11655829

The transmission is making a whining noise at 104;368 miles. We own another 2020 Toyota Highlander and it had to have the transmission replaced for the same reason. It is available for inspection. It’s a safety hazard because it’s a bearings in the transmission that’s failing. The transmission will eventually stop working. The issue was confirmed by a Toyota dealer and one of our transmissions has already had to be replaced. Toyota has a service bulletin out for this known problem. There were no warning signs for the transmission noise.

NHTSA ODI 11654949

There is a whining noise coming from the power train/transmission. It only happens when the accelerator pedal is pressed. We had a couple of mechanics look at it. The transmission oil was changed twice, with the vehicle less than 78,000 miles. Neither mechanic can find any issue with any other item, including the engine. The noise still persists. There are no warning lights on. We have researched the web. Toyota is aware of the problem and has replaced some transmissions still under warranty. They have issues a TSB (TSB008-21) in February 2021, but did not issue a recall or notify owners of a potential problem.

NHTSA ODI 11655035

Around 92k miles my transmission started makining a whining noise while driving. Dealership diagnosed a transmission problem and it needed to be replaced. They said eventually the transmission will go bad and stop working, potentially leaving me stranded or causing an accident. Spoke with Toyota HQ who would not offer financial assistance or assist with getting a part. UA80F transmissions are on a nationwide backorder. They also would not acknowledge that there is a problem.

NHTSA ODI 11653583

The 8-speed automatic transmission was making a whirring, whining noise. Transmission could failed completely and stranded occupants including children. Vehicle has been serviced every 5,000 miles and no warning lights or indicators ever came on. Dealer inspected and diagnosed an internal component failure necessitating complete transmission replacement. Vehicle is 4 years and 2 months old with 65,000 miles on it.

NHTSA ODI 11651457

Transmission going out afraid it will come apart or lose power while driving. Toyota dealership told me that we could put new transmission in but it will be the same as the one that is in it and that problem with them has not been corrected and it probably won't hold up long either. Our vehicle only has 71000 miles and we bought it new.

NHTSA ODI 11651486

The contact owns a 2020 Toyota Highlander. The contact stated that while depressing the accelerator pedal, the vehicle was making an abnormal whining sound. The contact stated that the failure occurred at various speeds. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to Technical Service Bulletin: T-SB-0008-21 Whine Or Grind Noise from Transmission (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 98,000.

NHTSA ODI 11647946

Complete transmission and transfer assembly failure at 72,000. Just outside manufacturer warranty. Toyota Dealership and Corporate refused to acknowledge responsibility, stating that the transmission and transfer assembly met warranty requirements, and that they would not entertain assistance.

NHTSA ODI 11644935

At 76000 miles my 2020 Highlander water pump began to fail. 20 days after the water pump was replaced at Kings Toyota dealership, the transmission is now failing at 79000 miles. The warranty only covers repairs on each up to 60000 miles. This car has been maintained by the dealership and no engine light ever came on. The water pump was $1200 to repair and I’m being quoted $10K to repair the transmission. I also don’t trust that dealership didn’t accidentally cause the transmission to fail bc they surprisingly have a new transmission in stock the day I came in. If it truly failed today, then Toyota needs to recall this car for safety reasons. It went from fine to not fine in just a few days of driving.

NHTSA ODI 11644942

The transmission is starting to whine at 108,000 miles. Toyota service told me the only fix is a replacement and they have seen two failures within the same week. They also said this is a known issue with this model year. A Reddit thread shows many owners in the US and Canada with the same issue. If this is resulting in failures of the transmission in operation this is a safety issue and a reasonable recall being a known defect for this line of transmissions. The recommendation from the service department since this vehicle is paid off is to run it to failure.

NHTSA ODI 11643039

Before hitting 100,000 miles the car started making a whirring/whine noise when accelerating. We mentioned it to the service advisor when taking the car in for an oil change. Initially the advisor said the service technicians took it for a drive and didn’t notice any noise; when we picked up the vehicle asked the advisor to sit in with us to point out the noise to him, he heard and acknowledged there in fact was a whining/whirring noise and said he would inquire about it to the shop foreman. The next day the advisor called me and said the shop foreman stated that noise is a transmission issue.

NHTSA ODI 11637126

The transmission started slipping without any warning and then went into neutral while driving and I am not able to drive it anymore. The dealership said the transmission is bad. I see many complaints online about 2020 Toyota Highlander transmissions going bad for no reason. This is a new car only 4.5 years of normal driving and the transmission goes, this is not normal for such a high rated vehicle.

NHTSA ODI 11634321

Highlander transmission broke down around 80,000 miles

NHTSA ODI 11632588

The transmission in my 2020 Highlander XLE needs replacement at 64,000 miles.

NHTSA ODI 11631899

Transmission whining around 38mph when accelerator is pressed. Goes away when foot is off pedal. No warning lights are on. I test drove 3 other 2020 - 2021 Highlanders in May before I purchased this one. All 3 of those had a very noticable transmission whine over 20mph. I opted for this Highlander because there were no noticeable issues/sounds. Just this month, I am noticing a more pronounced high pitch whine during acceleration. This certainly sounds like a much wider issue, especially calling around to multiple dealerships confirming they have other 2020-2021 Highlanders in getting transmission replacements (on 3+ months wait times for parts) This is absolutely a safety issue if a transmission fails while driving. There was a technical bulletin for this same issue with certain VINs, but I was told that my VIN fell outside of that range. To answer rest of questions: No confirmation from dealer on the whine, they are all charging $180 to diagnose the issue and I am not paying that. No further inspections by the above groups listed.

NHTSA ODI 11624184

The contact owns a 2020 Toyota Highlander. The contact stated that there was an abnormal winding noise detected while accelerating. The failure increased over time. While the contact’s husband was driving approximately 60 MPH and attempting to accelerate, the vehicle lost motive power. While shifting to park, there was an abnormally loud, high-pitched winding sound detected. The vehicle was slow to shift from first to second gear. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the CV joint needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was taken to a transmission center, where the transmission was rebuilt. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 130,000.

NHTSA ODI 11623929