What 298 owners told NHTSA about the 2020 Toyota Highlander

On September 2, 2025, the vehicle’s Hybrid System shut down on cold start and the vehicle would not start. A dealer inspection reported coolant had entered cylinder #4, allegedly causing the engine block to warp, the cylinder head to crack, and the head gasket to fail. This was a sudden catastrophic engine failure on a five-year-old vehicle with no prior overheating warnings, no dashboard alerts, and no performance issues in the days leading up to the failure. It is highly unlikely for an engine block to warp without sustained overheating, yet the failure occurred on a cold start. The dealership itself described this as a “premature failure” in their service report. At approximately 26,000 miles, the vehicle’s coolant thermostat failed and was replaced under warranty. If the thermostat stuck closed even briefly, the engine could have experienced one or more silent overheat events that never registered on the dashboard. In aluminum blocks, even short bursts of high localized heat can create latent distortion that doesn’t cause immediate problems but can eventually lead to catastrophic failure years later. Safety Risk: – Vehicle became disabled suddenly without warning. – Engine failure occurred without overheating symptoms, creating risk of sudden shutdown during use. Problem Confirmation: – Engine failure confirmed by a Toyota-authorized dealer. – Dealer service report explicitly called this a “premature failure.” Warning Lamps / Symptoms: – A check engine light appeared briefly three days before failure, then cleared on its own. – No overheating warnings or drivability issues were observed prior to failure.

NHTSA ODI 11690045

The contact owns a 2020 Toyota Highlander. The contact stated that while driving at 30 MPH, there was an abnormal whining sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 78,000.

NHTSA ODI 11689414

All of the sudden around 70K miles, the transmission started to make a "whining" noise. It does not sound right and I'm afraid the transmission could fail while I'm driving. I took it to the dealer and they acknowledged that it's a known issue but that in my case the noise is not loud enough to warrant replacing the transmission. A quick research on the internet revels that this is a very common problem.

NHTSA ODI 11689199

TOYOTA HIGHLANDER 2020 less than 5 years 63,000 miles started making noise Dealer where i bought it; said my warranty expired with 60,000 miles , so i have to pay transmission replace close to $9,000 , obviously this is a Toyota fabrication problem they need to assume responsibility .

NHTSA ODI 11688890

My 2020 vehicle has 75,000 miles on it. It started making a high pitched sound when accelerating. I brought my vehicle to the dealership where I bought it, to have it inspected. I was assuming it would be a belt or an easy fix. The service agent walked over and cooly explained that I need a new transmission. He continued to say that this is a common issue with this make and model. He stated that at the beginning of the year customers were having to wait a couple of months of transmission parts, but now because of the demand due to the well known power train failure, that the current wait time for transmission parts are only two weeks. He stated several times, that this is a common problem, one that car owners are expected to pay $9,000. to fix. A quick google search brings up a plethora of customers having the same exact problem. Toyota needs to make this right and issue a recall on their faulty product.

NHTSA ODI 11688249

Transmission is defective. I do have a warranty that I purchased but I am aware that this is a faulty transmission for the 2020 and 2021 Highlander and Toyota refuses to do anything about it. Transmission is 2 - 3 months backordered and Toyota will not provide a rental.

NHTSA ODI 11687883

TRANSMISSION GAVE OUT

NHTSA ODI 11687502

2020 toyota highlander l Transmission..whining noise it gets louder when accelerating

NHTSA ODI 11687706

The vehicle’s transmission makes an audible whining noise during acceleration and intensifies as the car increases speed. The vehicle has been diagnosed and inspected at the original dealer where the car was purchased and confirmed that the transmission needs to be replaced. The vehicle’s powertrain warranty has just expired and this issue is a major problem and concern with similar model years.

NHTSA ODI 11687751

On August 3, 2025, the vehicle developed a loud humming noise. After an inspection on August 12, Heritage Toyota informed me that the transmission had failed and would require replacement at an estimated cost of $9,000. This failure occurred only days past the five-year warranty and just 8,834 miles beyond the 60,000-mile powertrain limit. I immediately contacted Toyota’s Brand Engagement Center (Case #250814000192). Despite speaking with multiple representatives over several weeks, my inquiries were repeatedly delayed, escalated, or dismissed. At one point, I was even informed that further follow-up on my case would be deleted through Toyota Website. Ultimately, I was offered 50% coverage of the transmission replacement. While I appreciate this offer, it does not fully address the seriousness of a transmission failure occurring under such circumstances. I also contacted Heritage Toyota directly to request assistance, but my calls to the service manager went unanswered, and the dealership declined to provide any additional support. I believe this situation raises concerns about both product quality and customer care. A transmission should not fail in under five years with fewer than 70,000 miles, especially on a well-maintained vehicle serviced exclusively by Toyota. I respectfully request that Toyota be held accountable for this failure and that further review be conducted to determine whether this issue represents a larger pattern of premature transmission failures in Highlanders.

NHTSA ODI 11687039

A dealership has confirmed that the transmission in my 2020 Toyota Highlander is bad. It has 101k miles on it currently. I purchased this vehicle with the mindset that I would get 200,000 or 300,000 miles of use with it. I am now having to decide if I am going to trade it in or pay $9,000 to have the transmission replaced. I have been told that there are other 2020 Toyota Highlanders having this same issue. Has there been anything to determine what is causing this issue with the transmissions and will there be a recall?

NHTSA ODI 11686388

Transmission whine Owners of 2017–2022 Toyota Highlanders, 2017–2020 Siennas, and 2018–2020 Camrys are experiencing serious transmission issues—including high-pitched whining, erratic shifting, clunks, hesitation, and premature failure. These vehicles are equipped with the UA80F (AWD) and UA80E (FWD) 8-speed automatic transmissions.

NHTSA ODI 11686420

Transmission failure at 78,000 miles

NHTSA ODI 11683790

Transmission Planetary Gears in 2020 Toyota Highlander. Makes a "whining" noise when accelerating. No warning lights or other symptoms. Many reported problems with this model but no recall. Many people are needing to pay out of pocket due to the 60k mileage powertrain warranty.

NHTSA ODI 11683248

My 2020 Toyota Highlander is equipped with Toyota’s UA80 8‑speed transmission. At around 62, 000 miles, a loud whining noise developed. The dealership confirmed the transmission is defective. Toyota has issued multiple Technical Service Bulletins acknowledging this transmission defect across all 2020 Highlanders with the UA80, but they are refusing to cover my repair because I am slightly over the 60,000‑mile powertrain warranty. Impact: This is a confirmed design flaw that affects every 2020 Highlander with the UA80 transmission. I rely on this vehicle as my only means of commuting to work—if the transmission fails, I will lose my job.

NHTSA ODI 11677882

Whining noise upon acceleration, replacement transmission recommended by Toyota dealer. Defective UA80F installed.

NHTSA ODI 11677260

My wife was driving on the highway, felt a bump and the engine RPMs spiked. The check engine light came on as well as a error message that the secondary collision braking system was disabled. The vehicle was taken to the dealership and we were told there was a internal failure in the transmission. The vehicle has approximately 80K miles.

NHTSA ODI 11676335

UA80E or UA80F Toyota transmission require a complete replacement at 65K miles. Not covered under warranty or Technical Service Bulletin T-SB-0160-18, T-SB-0008-21

NHTSA ODI 11673633

At approximately 72,000 miles, my 2020 Toyota Highlander Platinum was diagnosed by my dealership with a failing transmission that requires full replacement. I first began hearing a high-pitched whining noise during light acceleration shortly after a routine oil change, at some point between 60,000 and 70,000 miles. I did not immediately recognize it as a drivetrain issue until the symptoms worsened. This model uses Toyota’s UA80 8-speed automatic transmission, which has been the subject of Technical Service Bulletin T-SB-0008-21 and a Customer Support Program (ZJC) for earlier Highlander models due to similar internal component failures. Despite clear continuity in the symptoms and transmission design, Toyota has not extended coverage or issued a recall for 2020 models like mine. The failure occurred shortly after the end of the 5-year/60,000-mile powertrain warranty, but symptoms began while the vehicle was still within warranty range. Toyota has not responded to my formal escalation through Customer Care for nearly three weeks. I am deeply concerned Toyota is not addressing what appears to be a systemic and known defect in a critical drivetrain component that can jeopardize vehicle safety. There was no warning light or dashboard alert at the time the failure developed, making this both a mechanical and safety concern. While this issue does not involve a catastrophic failure like the Takata airbag recall, Toyota’s lack of response to a known, widespread transmission issue raises broader concerns about safety, transparency, and accountability. A sudden transmission failure—particularly at highway speeds—could result in loss of power or control. Given that several owners have filed similar complaints, I respectfully urge NHTSA to investigate this issue further and assess whether Toyota should issue a recall or expanded service campaign for 2020 Highlander models equipped with the UA80 transmission, particularly in light of prior coverage for earlier model years.

NHTSA ODI 11671630

My 2020 Toyota Highlander Platinum started having the well-known "whining" sound at just under 60,000k. This is coming from the transmission. The vehicle is now just over 60,000k and I did not know that the noise was a cause for concern, let alone something that was an issue (I am not tech savvy - I'm just a regular person). I will not drive this vehicle again, as it is my only transportation for my children. Toyota issued a service bulletin about this issue for 2021 Highlanders ONLY, but as I am now experiencing this problem, I see that this is something well known as a problem.

NHTSA ODI 11671361

76,000 miles on my 2020 Highlander. Car was made in September 2020, less than 5 years old. Started to hear whining noise from transmission. Over past few days it has gotten louder. Took to Serra Toyota dealer today in Birmingham, Alabama. They confirmed a problem with transmission and told me I needed a new one for $8600. None are even available. I refuse to pay Toyota any money for this. This is a KNOWN issue with the UA80E transmission. The transmission may completely stop working at anytime now. Dealer was unwilling to do anything to help me since car is out of 60,000 mile warranty, and no TSB's or recalls are for my particular year 2020. There is a TSB for 2021 UA80E transmissions. I am so angry about this. This is a clear manufacturing defect. When this transmission dies which will be sooner than later the car will be worthless with no transmissions available.

NHTSA ODI 11671385

I brought my 2020 Toyota Highlander to Round Rock Toyota in 09/2024 for a failed transmission, referenced in TSB T-SB-0008-21. As of today, the vehicle has been in Toyota’s possession for over 10 months and remains unrepaired. My assigned case manager (Case #241003001730) has confirmed that Toyota has no ETA for the replacement part. I’ve also confirmed through Toyota’s customer support line that their parts department cannot provide a timeline. Toyota acknowledged the issue is tied to a known defect, yet there is no resolution. I was denied a loaner vehicle until escalating the issue to the dealership’s upper management. Toyota’s delay has caused significant personal and financial hardship. This is a clear breach of their powertrain warranty and represents a systemic breakdown in their ability to support affected customers. I am seeking immediate federal review of this issue, as it affects vehicle safety, value, and reliability.

NHTSA ODI 11671287

The contact owns a 2020 Toyota Highlander. The contact stated while driving at an undisclosed speed and attempting to accelerate, there was abnormal whining sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Support Program: POL 19-04. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 129,000.

NHTSA ODI 11670858

Transmission failure- this affects the safety of others when the car decides it doesn’t want to accelerate and could potentially lead to car accidents when another vehicle runs into it. The transmission needs to be completely replaced. This issue started back in January and has been an ongoing problem since warranty and Toyota will not assist with issue of their faulty product.

NHTSA ODI 11668359

Transmission making whining noise that increases with speed. Concerned about safety if transmission fails while driving Diagnostic done at Toyota and confirmed transmission is failing and needs new replacement. There are no warning lamps. Noise has increased intensity over short period of time

NHTSA ODI 11668004