What 302 owners told NHTSA about the 2020 Toyota Corolla Cross

At 97,000 miles, the slave cylinder in my vehicle blew. My clutch pedal had stuck to the floor, and my brakes became harder and harder to press down because the clutch takes from the brake fluid reservoir. Brake fluid began to leak from the transmission, and it had to be towed in. If I hadn't come to a stop, I could have gotten in a horrible accident.

NHTSA ODI 11693217

I was driving on the freeway on my way to the house my car start to make some noises and I was loosing power I pulled up on the shoulder and turn off the car because the check engine came on turn off the car again but was struggling to go into first gear

NHTSA ODI 11692402

Windshield wipers stop mid wipe. This seems to be a common issue with this car. It poses a serious hazard when driving in inclement weather.

NHTSA ODI 11689995

I’m getting ENGINE MAINTENANCE REQUIRED VISIT YOUR DEALER, And it has to do with the A/C It only comes on when I turn on the A/C which has to work the “Coolant Bypass valve” I’ve looked online and many others have had issues it’s the 2020 and onward year Toyota, I’m not the only one Many have mentioned they reach out the dealer & state this is not a recall and need to pay out of pocket to fix, but with some many people having same issue, doesn’t seem right that it wouldn’t be a recall with its MULTIPLES of people having this same issue

NHTSA ODI 11688004

The contact’s mother owns a 2020 Toyota Corolla. The contact stated that while looking in the list of features on the infotainment center, the Forward Collision, Brakes, Accelerator, Lane Assist, On-Board Collision, and other safety features were flagged as malfunctioning. The contact stated that the list of malfunctioning systems seemed to have increased over time. The vehicle failed to turn off intermittently, causing the driver to make several attempts to turn off the vehicle. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was 80,000.

NHTSA ODI 11686565

SOS is malfunctioning. Rebooting every thirty seconds. Interferes with handfree phone calls messages pop up asking to call for operator. Google this and it very common. The sos is for emergencies to get you help and it cuts off every thirty seconds.Your phone calls. Were the person you're talking to cannot hear you until it stops.

NHTSA ODI 11685651

The contact owns a 2020 Toyota Corolla. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact became aware of an abnormal clunking sound, and that the check engine warning light was illuminated. The contact stated the failure had occurred while driving on a busy road. The contact attempted to shift the gear shifter into different driving modes; however, the vehicle failed to accelerate as intended. The contact stated that several good Samaritans pushed the vehicle into a nearby driveway. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.

NHTSA ODI 11684454

I have experienced a message saying 'Engine Maintenance Required' and after experiencing the same instances as many people have online, it seems the engine coolant bypass valve is faulty and needs to be replaced. No code can be read using a code reader either.

NHTSA ODI 11683483

The contact owns a 2020 Toyota Corolla. The contact stated that while operating the vehicle, the message "Communication Module Failure" was activated. The cause of the failure was not yet determined. The local dealer and the manufacturer were contacted regarding the failure, but no assistance was provided. The failure mileage was 37,000.

NHTSA ODI 11681365

Engine Maintenace required light came on. I was told that my coolant bypass valve needed to be replaced. This is happening on all Toyota vehicles from 2018-2024 common issue but the repair to fix something that should be covered under warranty.

NHTSA ODI 11679742

The current recall on this car (passenger front seat weigh sensor issue) has been going on for too long (since 2023). Based on the recall info, i have not been able to drive with anyone sitting on the front passenger seat.

NHTSA ODI 11675806

The contact owns a 2020 Toyota Corolla. The contact stated that while driving approximately 10 MPH and making a left turn, the Forward Collision Avoidance system activated ad the vehicle stopped independently. The contact stated there was no warning light illuminated. The contact stated that the braking function resumed, and the contact was able to continue driving. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the Forward Collision Avoidance was functioning correctly and there were no failure found with the brakes. The vehicle was not repaired. Additionally, the contact reported that the vehicle had started to shake abnormally while driving at speeds under 40 MPH. The contact stated no warning light was illuminated. The contact had not taken the vehicle back to a dealer or mechanic to be diagnosed. The manufacturer was not informed of the failure. The failure mileage was approximately 116,000.

NHTSA ODI 11675119

My airbag sensory notifications keeps coming on. When I start my car normally it isn’t on but once I start driving the notification will come on along with the ding noise it makes when you don’t have on a seat belt. I notice there was a recall on this issue for the later model Corolla and wanted to see if possibly this could be considered for the 2020 Corolla’s.

NHTSA ODI 11674399

Coolant Bypass Valve

NHTSA ODI 11673798

Fuel pump system failure causing vehicle warning lights to come on and not turn off, affecting vehicle performance for going up hill as well as vehicle completely shutting off in middle of road . Major safety hazard

NHTSA ODI 11668991

On June 19, 2025, I was driving and out of nowhere, there was a warning notification that said "A warning light was turned on. Would you like to call an operator?" On the digital cluster, there was a message that said "Engine Maintenance Required - Visit Your Dealer. Mileage noted down was 79,632. I asked around for some insight and people are telling me it's the water/coolant bypass valve that's leaking and the Op code is 24TE04R1. Will this be a covered service?

NHTSA ODI 11668609

The engine maintenance required message appeared on the dash. I was travel from work to home (about 40 miles). I pulled over immediately at a store, left my car and walked over a mile to the mechanic shop down the road (in 95° weather with a knee that has been through 3 surgeries in less than 5 years). The gentleman took me back to my car. Followed me as i took my car back to the repair shop since it was close and did not have any lights on the dash and I was not overheating. He plugged a reader in it and the error was a coolant bypass valve issue (i can't remember the exact verbage). I purchased a replacement valve 6-17-25, along with toyota coolant. I am having to wait and save up the money to have the valve replaced at the shop got the message code from. I can not afford the dealerships cost to replace the valve. The valve and coolant was expensive in itself. I have read many forums and blogs. Toyota knew there was an issue and I am requesting my reimbursement for the cost of replacing a part you knew was faulty.

NHTSA ODI 11668341

Front windshield has bubbles on all the edges and they are getting bigger i took it to the warranty ofrece and they say it not a defect, but i hace sean more tan 100 cars With the same problem ,and i don't fiel sale wathching then grow or break. I hope You can verify , just look at any corolla and You Will see what i say on the edges of the windshield, thank

NHTSA ODI 11667575

Flow Shut-off Valve Coolant Leak

NHTSA ODI 11665916

The windshield wipers stop in the middle of the windshield at times when set to intermittent. Sometimes they will not shut off when they are turned off. This can be a hazard while you are driving and you never know when it will happen.

NHTSA ODI 11664726

While driving with the windshield wipers on during a rain storm , the wipers would stop working suddenly. The Car was taken to dealer and windshield motor was replaced. Without working wipers, it was dangerous to drive.

NHTSA ODI 11663778

I have an error that appeared displaying “Engine Maintenance Required” after some investigation snd research, I have noticed that this is a common issue associated with the OEM Engine Coolant Bypass Valve. This occurred as I was driving home from work when I was driving down the freeway, I did not run into any obstacles or have an accident, it appeared out of thin air.

NHTSA ODI 11662682

unknown. i know that my car was doing fine and then randomly the coolant was low and my car was overheating on my way to work. i have yet to get it fixed, as i dont know how much it could cost me. but i read that 2020-2021 toyota makes were having issues with their coolant.

NHTSA ODI 11661991

ocs sensor recall. the potential of this recall makes me very nervous to drive the car. they haven't tested or inspected the part until the remedy is in. no lights on dash at this time.

NHTSA ODI 11661606

An engine maintenance required warning popped up. The pop up wasn't going away. My engine sounds louder than usual when turning my A/C on.

NHTSA ODI 11661513