What 434 owners told NHTSA about the 2020 Tesla Model 3 Bev

On July 11 at approximately 6:47 a.m., I was operating my Tesla Model 3 on Interstate 65 in Hart County, Kentucky, with Full Self-Driving (FSD) engaged during normal highway travel. Approximately one hour earlier, I had departed a highway rest area after sleeping from the previous day’s travel. Rain developed during the trip, but I observed adequate visibility, apparent roadway traction, and I was not impaired. I was traveling in the far-right lane of a three-lane interstate. The posted speed limit was approximately 70 mph; however, FSD limited the vehicle to approximately 65 mph and displayed warnings indicating that the higher speed was unavailable. While FSD remained engaged, the system initiated a lane change from the far-right lane into the center lane. After entering the center lane, the vehicle began displaying repeated warning messages and FSD disengaged multiple times. I attempted to locate settings related to the warnings on the touchscreen but could not identify an available adjustment. During the third disengagement, I perceived that the vehicle continued braking without releasing while steering resistance increased significantly. The steering wheel then rotated abruptly, and I was unable to regain normal directional control before the vehicle departed its intended travel path and struck a concrete median. The collision caused personal injuries and substantial vehicle damage. I have not been able to reproduce the condition. The incident was investigated by the Kentucky State Police. Based on the sequence of repeated FSD warnings, disengagements, continued braking, and abrupt steering behavior, I believe this event warrants investigation. I request that NHTSA review the vehicle’s Full Self-Driving logs, telemetry, Event Data Recorder (EDR) data, steering and braking commands, diagnostic records, and software history to determine whether a vehicle or software malfunction contributed to the collision. Almost like someone had control, into the wall -KM

NHTSA ODI 11750430

On XXX at approximately 5:00 PM, I was driving my 2020 Tesla Model 3 on [XXX] from [XXX] toward [XXX], with Tesla FSD engaged. Near the area where the center divider begins/ends, the vehicle crossed the double yellow/divider area and entered the opposing traffic lane. There was no oncoming traffic at that moment, so there was no crash, but this created a serious potential head-on collision risk. The car also did several hard jerks that aggravated my neck and back that it has been consistently doing for a long time which cause worse ongoing headaches. The system/component that malfunctioned was Tesla FSD/Advanced Driver Assistance, including lane keeping/steering behavior. The vehicle is available for inspection upon request. My safety and the safety of others were put at risk because the vehicle moved into the lane for oncoming traffic. I had to intervene and no longer feel safe using FSD. I have reported unsafe FSD behavior to Tesla multiple times before, but the issue has not been resolved. Tesla service has previously listed the concern as “FSD not working properly/test drive required” and/or general diagnosis, but I have not received a clear written resolution explaining why the vehicle crossed into the opposing lane or how Tesla will prevent this from happening again. There were no warning lamps or messages that I recall before the vehicle crossed into the opposing lane. If Tesla has vehicle logs or telemetry for the incident, I request that they be reviewed. I am reporting this because the vehicle may repeat this unsafe behavior and create a head-on collision risk. The car continues to behave unsafely and erratically. i have a log of some of the incidents. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11748025

Vehicle Information: 2020 Tesla Model 3 AWD (Leased) Full Self-Driving (FSD) enabled Summary of Safety Issue: While Full Self-Driving (FSD) was engaged, the vehicle failed to detect roadside infrastructure and collided with multiple fixed objects, including a route sign board, a walkway sign board, and an underground electrical cable. The system did not provide adequate warnings or corrective action before impact. System jerk the steering confirmed system is engaged but did not break and drive to non-drivable area and not given any disengagement warning and totaled the car. Incident Details: • Date of incident: [XXX] • Location: On [XXX] {XXX] Piscataway, NJ 08854 • Road type: [XXX] • Weather/visibility: Clear • Speed at time of incident: <40 MPH (under the speed limit) Description: As soon as i trigger the FSD it immediately tried to navigated left or right and failed and unexpectedly veered into roadside infrastructure. The system did not slow down, steer away, or alert the driver in time to prevent the collision. The impact caused significant damage to public property and the vehicle is totaled. No injuries occurred. Evidence Available: • Photos of the scene and damage • Police report (number: [XXX] • Tow documentation • Tesla collision center estimate Reason for Reporting: This incident suggests a potential safety defect in Tesla’s FSD system related to object detection, path planning, and collision avoidance. The failure occurred without driver input and raises concerns about the system’s reliability in detecting fixed roadside objects. I request that NHTSA review this incident as part of ongoing evaluations of Tesla’s driver-assistance systems. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11709397

Air bags did not deploy during crash. It is available for inspection upon request My face smashed into the steering wheel resulting in black eyes, swollen nose, cuts on my face and a concussion. Yes, the airbags clearly did not deploy during crash No No

NHTSA ODI 11705237

The complaint was filed on behalf of the contact's daughter. The contact's daughter owned a 2020 Tesla Model 3. The contact stated that while the contact's daughter was driving at 35 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The contact stated that the contact's daughter stated that the brake pedal felt spongy and unusual. The contact's daughter stated that the brake pedal was depressed to the floor; however, the vehicle still did not stop. The contact's daughter enabled the emergency braking system; however, the vehicle still did not stop. The contact's daughter beeped the horn to alert the nearby driver, and the dash cam independently activated. The contact stated that because of the failure, the contact's daughter's vehicle rear-ended the vehicle in front of the contact's daughter's vehicle. The air bags did not deploy. The contact stated that after the crash, the emergency braking system failure warning light was illuminated. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss by the insurance company. A Police report was filed. The contact's daughter was treated at the local hospital on the following day. The contact's daughter sustained headaches, whiplash, and a concussion. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.

NHTSA ODI 11693937

Experienced sudden unintended acceleration (SUA) while parking the car. Was pulling into a parking spot at a very slow speed, approx 5 mph and the car accelerated to an extremely high speed on its own without any input from me. Tried to brake to stop the car but the car did not respond or stop or slow down. Due to the SUA event, the car crashed into the side of a building, all air bags in the car were deployed, and the car is a total loss per insurance.

NHTSA ODI 11674516

Airbags did not deploy when vehicle hit 75 ft highway guardrail driving over 70 mph. The car was totaled, the driver's head hit the steering wheel, requiring stitches. EMS and police at the scene were surprised to find airbags not deployed. Vehicle has been inspected by insurance. Manufacturer has not yet been informed, to my knowledge. There were no warning lights or messages indicating a problem with airbags or anything else for that matter. Driver was wearing seatbelt.

NHTSA ODI 11667750

Car radio goes so loud it damaged my ear nerves. This results in pain especially when exposed to loud sounds

NHTSA ODI 11640726

Back and buttocks area suffered electrical burns and pain from Tesla Seat Heaters (in heated seats) twice 1. Happened in 2024 on temperature level 3 2 Although I turned it down it happened again in 2025 on temperature level 2

NHTSA ODI 11640654

In a private parking lot, within line of sight and ample time to respond to problem I used Tesla Smart Summon. Instead of taking an obvious route through the parking lot, it narrowly hit a parked car, then proceeded to drive over a parking barrier and into a wooded field towards me and a crowded food truck area. I was unable to cancel the feature in time to stop the car from the collision as it accelerated too fast and without any initial signs of an issue. Even after canceling through the app, the car tried to continue for a brief period. If anyone was in the area or we were closer we could have been hit. Tesla replaced the cameras but claimed no responsibility for damages, citing I was "in control". There were no warning lamps or indicators of any defects before the incident. I also have the original dashcam footage portraying the incident, which clearly shows numerous safety hazards to the smart summon feature.

NHTSA ODI 11634598

My car did a Phantom break while I was driving on President George bush Turnpike E at the Dallas North tollway exit . I was taking the exit with in the speed limit of 40 miles per hour and was keeping the distance from the car in front. Suddenly the car did an automatic break and car slow down significantly. I got hit from behind and had damage to the bumper and trunk. Emergency break feature went out and an alert came. It is very concerning that the car stops in the middle of road by itself and being hit from behind. I would like an answer from Tesla. I have the dash cam footage of the accident

NHTSA ODI 11624374

I was burned on back and buttocks by Tesla car seat warmer

NHTSA ODI 11585634

The door handles on the chrome version of the Tesla Model 3 begin to delaminate after several years of use. They delaminate along the door handle seam which creates an extremely sharp edge that can cut fingers. I've had the rear handle on my own model 3 rear door cut my kids finger when they tried to get into the back seat. Because the car is technically out of warranty Tesla will not cover repair without significant cost. There is no warning sign or notification other than when you reach to pull the handle and the sharp chrome edge cuts you, the one door with this issue now has the handle partially protruding since the handle can no longer sit flush. There are several threads where similar chrome version model 3 owners have had the exact same issue occur with the exact same safety risks. Tesla has only repaired the ones that fell under factory warranty. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11583196

Braking and Stopping - Braking system - Improperly functioning braking systems. I experienced a problem with the brake pedal, brake calipers, and/or any component of a Model 3 braking system. “Model 3 has an anti-lock braking system (ABS) that prevents the wheels from locking when you apply maximum brake pressure. This improves steering control during heavy braking in most road conditions…Forward Collision Warning and Automatic Emergency Braking do not operate when driving at very low speeds (see Collision Avoidance Assist on page 128). Do not rely on these features to warn you, or to prevent or reduce-the impact of a collision. (Tesla owners Manuel71-73) I stop on a downward slope with my foot on the brake to wait for a gate to open in my apartments. I let go of the brake and the vehicle remained steady until it started rolling. When it started rolling, I jam my foot on the brake but the brake is engaged (locked). The vehicle accelerates, the brakes and steering wheel is locked giving no control over the vehicle. The vehicle drives through the gate and into a wall. The airbags deploy and I get out immediately for caution of explosion and shock. I call a tow truck and made a claim with USAA. I got a concussion and multiple injuries on my body. I’ve been getting medical treatment for 6-8 months. USAA didn’t help as they deemed the accident was my fault and totaled the vehicle. I bought the vehicle for more than what’s it’s worth. I have loan payment that I can NOT pay. This was my only asset and this accident changed my work life. Tesla gave me the run around on how to make a claim and no compensation. Directed me to insurance company. This demonstrates failure of an Braking System, operating electric vehicles, company responsibility, safety and transportation regulations and policies. These vehicles are highly dangerous for my safety and others as there’ve been multiple accidents and deaths.

NHTSA ODI 11577318

Car did not react to uncoming car and accident happened. Car was totaled. RECALL NO. 23V-838 involved as the car didn’t have the right safety controls and caused collision

NHTSA ODI 11572492

The vehicle was in a frontal crash and the knee airbags exploded the glovebox and broke my leg in 3 different places.

NHTSA ODI 11568106

My Tesla Model 3 was involved in a 'fender bender' almost 9 months ago. It took 3 months just to get an appointment at a "Tesla Certified Collision Center" in my town (and I live in a fairly major city - Portland, Oregon). After the vehicle went to the shop it has now been there for OVER 5 MONTHS! This is a result of parts being incorrectly sent from Tesla, parts being unavailable from Tesla, parts being mislabeled and/or 'hidden' in their Ordering system and so many other unbelievable problems that Tesla has had. I have now been without the vehicle for over 5 months and still waiting on some other part that was now ordered over 2 weeks ago. The whole process is completely unacceptable and Tesla has really dropped the ball. I will be selling the vehicle and never owning another Tesla again, the moment it is finally done being repaired. Do I have any recourse? Can I sue Tesla to cover the 5 months of insurance I just spent my money on? Thanks!

NHTSA ODI 11563954

We had Model 3 with instance of unintended acceleration at the gate of a parking lot. This car was bought in May 2020. On December 6, 2020, she was on the way out of the parking gate and suddenly the car accelerated, hitting the side wall of the gate. The car flew over a two-way street, resulting in a compound fracture of her right hip requiring internal fixation and transfusion. The vehicle was inspected by the police. There were no warning lamps, messages, or other symptoms prior to failure.

NHTSA ODI 11560002

I was driving on the Garden State Parkway in New Jersey in the right hand lane. I was using basic auto pilot and needed to pass a pick up truck in front of me. I disabled auto pilot and went into the left lane. I re-engaged auto pilot and the vehicle took a hard right and hit the truck. I heard the audible chime once it made contact with the truck indicating that auto pilot disengaged. My car went back into the left lane and I took control. We moved to the shoulder and waited for state police to arrive. Luckily no one was injured. A police report was filed.

NHTSA ODI 11547462

Sudden acceleration while driving and at stop sign

NHTSA ODI 11539459

On August 2, 2023 at 0400, the Tesla M3 was charging in the garage using a home charger. Smoke indicative of an electrical fire likely originated from the vehicle and eventually triggered a smoke alarm in the kitchen. The driver was unaware the source of the smoke was the Tesla, disconnected the Tesla and moved it out of the house to protect the vehicleb assuming a fire was in the house, and called firefighters who searched the home without success for a source of the fire. The driver now believes the Tesla was the source as the garage access door was cracked open to feed the charging cable from the 240v outlet in the laundry room. The nearest smoke detector from the Tesla is in the kitchen, where the driver smelled smoke from an electrical fire. At roughly 0745, the driver was about to complete a one hour commute to work in this Tesla unaware that the incident at 0400 was related to the Tesla. The driver experienced a sudden vector and velocity change in the vehicle while traveling at highway speeds. This is the driver's last memory of the accident that followed. A witness driving behind the Tesla described the vehicle traveling in clear lanes when it abruptly jerked left, then right into the side of the highway into concrete barricades. The Tesla was destroyed, airbags deployed, and the driver was rescued by first responders,firefighters, and paramedics. The driver was evacuated to the nearest hospital with serious injuries. The driver suffered broken ribs, a pneumothorax, several lacerations to head and chest, several contusions across the shoulder, legs, and body, and a mild traumatic brain injury.

NHTSA ODI 11536830

my son-in-law went straight off country road and into a tree car burnt to ground was burnt to death date was [XXX] sheriff Spokane county investigating teal front suspension repaired 1 month before at local Tesla shop Spokane wa INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

NHTSA ODI 11533202

My vehicle was in a collision on the freeway and the airbags did not deploy. The car is being assessed to see if it deemed totaled. Regardless of the outcome of the status of the vehicle, given the impact of the accident, the airbags should have deployed given the impact of the collision and the impact on the car.

NHTSA ODI 11530650

The contact owned a 2020 Tesla Model 3. The contact stated while pulling into the driveway and depressing the brake pedal, the vehicle failed to respond, accelerated unintendedly, broke through the garage door, and crashed into the vehicle parked inside the garage. The other vehicle moved away and damaged the garage. There was no warning light illuminated. The air bags did not deploy. The contact shifted into reverse (R), pulled out of the driveway and shifted into drive (D). The brake pedal was depressed but the vehicle failed to respond. The contact stated that he hit the curb to stop the vehicle, and the vehicle stopped. The contact stated that all the air bags then deployed. The vehicle failed to unlock. The contact rolled down the windows and cried for help until the neighbors arrived and opened the vehicle from the outside. The contact sustained bruises on both arms, and the contact's wife sustained bruises on the right shoulder and on the left leg. Both the contact and his wife received medical assistance. There was no police report filed. The vehicle was towed to a third party it was sold to. The other damaged vehicle was totaled. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 9,600.

NHTSA ODI 11529563

on July 19,2022, when I was driving on driveway, at less than 5 miles, I tried to stop to drop my wife and applied brake. Instead of brake, due to computer mal function, it accelerated & hit the garage door, broke the garage door, door fell on the car parked in the garage, damaged that car,and tesla automatically reversed. while reversing brake wasn't working too so I tried to put in drive & brake still was not working so to stop the car for safety, I hit the curb in my front yard All airbags were deloyed, inuring both of us. All doors were locked & we couldn't open any of them. We could open windshield. We shouted HELP and my neighbor came & open the door from outside so we could get out otherwise we both could be dead inside the car

NHTSA ODI 11529230