What 434 owners told NHTSA about the 2020 Tesla Model 3 Bev

The material used to cover the steering wheel is defective and not up to safety standards. The poor quality plastic used to cover the wheel is a very thin plastic that melts from the sun and peels off causing a safety hazard. I brought this to Tesla's attention and was told they will not fix it without me paying for it. There are number of consumer complaints on the internet for the same issue showing the defective material.

NHTSA ODI 11548920

Sporadically, I've been driving and the steering stiffens so much that I can barely turn the wheel. The car flashes a warning that steering assist may be reduced. I pull over, turn the car off, restart it, and it is fine again. This happens, such as the last time I filled this out, randomly and not every day nor on every drive. I contacted Tesla and they estimated a $2,000+ cost to fix it and can't get to it until October 2nd at the earliest. Meanwhile, I need it to get to and from work. They stated that the steering concern hasn't been reported in any other vehicle, but I've seen it reported by others to NHTSA.

NHTSA ODI 11545215

While driving on the highway, the car suddenly alerted me that the steering assist was affected. The steering wheel became extremely stiff. To turn, it took two hands and quite a lot of strength. I pulled off onto an exit, turned the car off, then started it back. The steering worked properly the rest of the drive. The next day, steering worked fine on my 50-mile drive to work. On the way home, however, it froze up the same way again. Again, I pulled over, turned the car off, then back on and the issue was resolved. The steering wheel was so stiff that I could barely turn it, however, and it is incredibly unsafe. The soonest they said they could check the car is October 2nd. It seems to be a software issue since turning the car off and then back on resolves it. Tesla, however, is impossible to get in touch with other than sending a text through the app and then I'm lucky if I ever get a response.

NHTSA ODI 11544409

my son-in-law went straight off country road and into a tree car burnt to ground was burnt to death date was [XXX] sheriff Spokane county investigating teal front suspension repaired 1 month before at local Tesla shop Spokane wa INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

NHTSA ODI 11533202

This cocksucker blasts oncoming traffic with DISCO HIGHBEAMS every single fucking time there's a lonely oncoming car on the highway. Someone's gonna shoot my ass for blasting them repeatedly with highbeams. Because autosteer is connected to auto highbeams, I can't turn it off unless I turn autosteer off and drive like a 1995 peasant.

NHTSA ODI 11491852

Sporadically when driving at highway speeds, car will experience an error. Steering assist IMMEDIATELY decreases (wheel harder to turn), cruise control (if enabled) will disengage, and following Error codes appear on flatscreen : - Vehicle Hold Feature Unavailable - Tire Pressure Monitor System Fault - Automatic Emergency Braking Disabled - ABS (Anti-lock brakes) disabled - Regenerative Brakes Disabled - Steering assist reduced - Traction control disabled Unsure of which component is at fault. Tesla Service center (Norfolk VA) has pushed off appointment for more than 30 days but has acknowledged that there is an issue. SAFETY: Loss of ABS is a major safety risk to occupants. Loss of steering assist also puts driver and others at risk due to increased steering effort. Loss loss of regenerative braking also a safety risk due to the instantaneous change of vehicle braking behavior when regenerative braking switches off.

NHTSA ODI 11461057

I was trying to avoid a car parked on the side of highway on my right going between 45 to 55 miles an hour and slightly steered the car to the left, and the car swerved back and forth at the slightest steering wheel movement as if skidding in the snow. The road was dry (no rain) but the steering was not stable and the car ended up hitting a truck on the left. It caused a very serious accident and we are lucky that there was just a major car damage and no one was hurt. The steering seems to be uncontrollable and loose, and causes major swerving if one has to steer away at a high speed.

NHTSA ODI 11444088

I was driving down the Interstate and had my Tesla on Self driving. For no reason at all it did a aggressive left turn causing me to go off the road into the median. It tore up pieces of my car and Tesla wouldn’t do anything about it and have no idea why it went off the road. I have a video of the Incident

NHTSA ODI 11429386

The contact owns a 2020 Tesla Model 3. The contact stated while driving in the rain with the autopilot engaged the vehicle accelerated without warning and was incontrollable, flipped two times, and hit the curb. The contact sustained neck injuries and medical attention was provided at the hospital. All the air bags deployed. There was no reported fire. A police report was filed. The vehicle was towed to an independent body shop. The local dealer was contacted who referred the contact to the body shop. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 29,000.

NHTSA ODI 11429423

HERE IS A TESLA MODEL 3 IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39653751?TENANT=US&ROWNUMBER=19 ALL 3 BALL-JOINTS ON THE FRONT RH STEERING KNUCKLE HAVE POPPED APART. THIS IS HAPPENING SO FREQUENTLY ON TESLAS THAT IT IS OBVIOUS THEY ARE USING POOR QUALITY SUSPENSION AND STEERING COMPONENTS. THE OWNER OF THIS TESLA WAS LUCKY BECAUSE ONLY THE CAR WAS DAMAGED. THESE FAILURES ARE CERTAIN TO CAUSE DEATH AND INJURY IF NHTSA CONTINUES TO STAND BY AND DO NOTHING. THIS IS DISGRACEFUL. PLEASE TAKE IMMEDIATE ACTION. THANK YOU KEEF

NHTSA ODI 11407536

THIS IS A COMPLAINT ABOUT THE BETA RELEASE AUTOPILOT. A RANDOM MODEL 3 VIN HAS BEEN USED TO BE ABLE TO FILE A COMPLAINT. THIS COMPLAINT APPLIES TO ALL MODELS OF TESLA. HERE IS A VIDEO OF A PROUD BETA TESTER. HTTPS://WWW.YOUTUBE.COM/WATCH?V=PQ-RGY1V8UG THIS OWNER HAS A MISPLACED TRUST IN THE SAFETY OF THE AUTOPILOT. HE IS USING IT IN HIGH RAFFIC AREAS WITH PEDESTRIANS AND CYCLISTS HE IS ALSO USING IT AT EXCESSIVE SPEED ON NARROW ROADS ONLY INCHES AWAY FROM ONCOMING TRAFFIC. RATHER THAN HAVING HIS HANDS HOLDING THE WHEEL IN THE CORRECT WAY HE ONLY HAS HIS FINGERS TOUCHING THE WHEEL WITH THE PALMS FACING THE WRONG WAY. IF ANYTHING GOES WRONG HE WILL NOT BE ABLE GRAB THE WHEEL PROPERLY IN TIME TO PREVENT A COLLISION. FINGERTIP DRIVING IS UNSAFE AT THE BEST OF TIMES. IF AUTOPILOT HAS A GLITCH OR A SPASM THE DRIVER WOULD BE UNABLE TO QUICKLY REGAIN CONTROL. DESPITE THE CLAIMS OF ELON MUSK SUCH DRIVER BEHAVIOR DOES NOT LEAD TO THE BEAT RELEASE AUTOPILOT BEING REVOKED. THIS EXPERIMENT IS DEADLY. PLEASE GET IT STOPPED IMMEDIATELY. THANK YOU KEEF.

NHTSA ODI 11402970

THIS IS A COMPLAINT ABOUT THE ISSUE OF POPPED BALL-JOINTS WHICH IS AFFECTING ALL MODELS OF TESLA CARS. HERE IS JUST ONE EXAMPLE OF A BALL-JOINT THAT HAS POPPED APART FOR NO GOOD REASON. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39240789?TENANT=US&ROWNUMBER=3 IT IS EASY TO FIND OTHER EXAMPLES OF THIS SAME FAILURE IN OTHER TESLA AT THE JUNKYARD. I WILL ATTACH A FEW PHOTOGRAPHS TO SHOW YOU. THES BALL JOINTS ARE OF LOW QUALITY, UNDERSIZED, PRONE TO CREAKING AND GROANING DUE TO LACK OF GREASE WHICH CAUSES THE BALL TO WEAR DOWN AND POP OUT. THE TESLA FORUMS ARE FILLED WITH REPORTS ABOUT THIS. ELON MUSK HAS ADDRESSED THIS BY NERFING THE FORUMS. DEFINITELY A GENIUS. LINKS TO OTHER POPPED TESLAS.HERE: HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39311673?TENANT=US&ROWNUMBER=11 POPPED FRONT AND WHOMPY REAR HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39310125?TENANT=US&ROWNUMBER=15 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39308954?TENANT=US&ROWNUMBER=22 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39282369?TENANT=US&ROWNUMBER=24 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39280909?TENANT=US&ROWNUMBER=30 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39265721?TENANT=US&ROWNUMBER=33 POPPED AND THEN BURNED TO A CRISP HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39248729?TENANT=US&ROWNUMBER=39 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39245824?TENANT=US&ROWNUMBER=51 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39244011?TENANT=US&ROWNUMBER=62 POPPED HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/39258823?TENANT=US&ROWNUMBER=81 POPPED SEE ATTACHED POPS2 I CAN FIND YOU PLENTY MORE. PLEASE INVESTIGATE. THANK YOU KEEF

NHTSA ODI 11400003

HERE IS A TERDSLA IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/38998703?ROWNUMBER=0 THE FRONT WHEEL AND SUSPENSION HAVE SNAPPED OFF. BOTH LOWER BALL JOINTS AND THE UPPER STEERING KNUCKLE BALL JOINT HAVE SIMPLY POPPED APART. IT IS COMPLETELY IMPOSSIBLE FOR THIS TO BE THE RESULT OF CRASH DAMAGE.. THE WHEEL AND TIRE ARE UNDAMAGED. TESLA BALL JOINTS ARE A LOAD OF OLD BALLS. GOOD HEAVENS TO BETSY WHY WON'T YOU DO SOMETHING ABOUT THIS? YOURS IN DISGUST. KEEF

NHTSA ODI 11395456

HERE IS A TERDSLA MODEL 3 IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/38868112?ROWNUMBER=3 THE FRONT LEFT HAND SUSPENSION HAS FALLEN TO BITS. THE LOWER SUSPENSION ARM (MADE FROM CAST MONKEY METAL) HAS SNAPPED LIKE A PRETZEL. THIS IS NOT COLLISION DAMAGE. THERE IS NO DAMAGE TO THE BODYWORK AND NO AIRBAGS HAVE BEEN DEPLOYED. THIS IS SIMPLY BAD MANUFACTURING. TESLAS ARE UNSAFE AT ANY SPEED. PLEASE INVESTIGATE. THANKS. KEEF

NHTSA ODI 11390525

TESLA MODEL 3 IN THE JUNKYARD: HTTPS://WWW.AUTOAUCTIONMALL.COM/USED-CARS-FOR-SALE/2020-TESLA-MODEL-3-CO51960570 FRONT WHEELS AND SUSPENSION FALLEN TO BITS. TOP BALL JOINT POPPED APART.. LOWER BALL JOINTS BOTH SNAPPED. STEERING ARM AND LOWER FORE-LINK BUSTED. BAD DAY AT THE TENT FACTORY? PLEASE GET THESE LETHAL CONTRAPTIONS OFF THE ROADS. THANK YOU. CITIZEN KEEF

NHTSA ODI 11377242

HERE IS A 2020 TESLA MODEL 3 IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/37237764?ROWNUMBER=40 THE FRONT WHEEL HAS GONE WHOMPY. THE LOWER BALL JOINTS HAVE POPPED OUT BUT WORSE STILL THE STEERING ARM HAS SNAPPED OFF FROM THE STEERING KNUCKLE. LOOKS LIKE THE USUAL FRACTURE OF A LOW QUALITY ALLOY CASTING. THIS COULD EASILY HAVE CAUSED A FATAL CRASH. ELON MUSK BLAMES CHINESE DRIVERS FOR DRIVING IT WRONG. THIS ONE IS IN MIAMI NOT CHINA. PERHAPS ELON WILL BLAME THIS ONE ON A LATINO ALSO DRIVING IT WRONG. I STRONGLY URGE YOU TO TAKE ACTION. I URGE YOU WITH EXTREME PREJUDICE. THANK YOU KEEF

NHTSA ODI 11366213

MODEL 3 MAKES A VERY HIGH PITCH NOISE WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. IT DOES HAPPEN WHEN YOU PUT THE VEHICLE IN DRIVE AND STAND STILL ON HOLD. IT DOESN'T HAPPEN WHILE DRIVING NOR WHILE IN PARK.

NHTSA ODI 11363279

HERE IS A 2020 MODEL 3 IN THE JUNKYARD. HTTPS://WWW.IAAI.COM/VEHICLEDETAILS/37237764?ROWNUMBER=6THE FONT SUSPENSION GIBLETS HAVEALL FALLEN TO BITS. BOTH FRONT WHEELS ARE SPLAYED OUT IN OPPOSITE DIRECTIONS WHICH WOULD PROBABLY MAKE IT A LITTLE HARD TO STEER. IWOULD YOU PLEASE ISSUE AN IMMEDIATE RECALL FOR THESE TENT BUILT DEFECTIVE DEADLY CONTRAPTIONS. THANK YOU. KEEF

NHTSA ODI 11351731

FRIDAY JUNE 26TH, 6:00 P.M. PUBLIC ROADS. SUNNY, DRY. SOMETHING SNAPPED WHILE DRIVING 5 MPH AT THE MOMENT I STARTED A SLOW LEFT TURN. THE CAR LURCHED TO A HALT. THE RIGHT FRONT WHEEL WAS ANGLED LEFT AT ABOUT A 35 DEGREES, WHILE THE LEFT WHEEL POINTED STRAIGHT. TESLA SENT A FLAT BED. THE TRUCK TECHNICIAN REPORTED BY PHONE THAT THE WHEEL WAS SEPARATED FROM THE SUSPENSION AND A TESLA BOLT WAS AVAILABLE FOR HIM TO TEMPORARILY HOLD ALIGNMENT FOR SAFE LOADING. I UNDERSTAND HE LEFT A NOTE AND THE BOLT INSIDE THE CAR. I BELIEVE THE BOLT WAS PART OF THE BROKEN SUSPENSION. THE CAR HAD 3,300 MILES. DURING MY OWNERSHIP, I NOTICED A LIGHT CLICKING (OR CLUNKING) WHEN THE CAR PASSED OVER A 3 INCH CHANGE IN ROAD ELEVATION, SUCH AS OCCURS DURING REPAVING WHEN STRIKING A MAN HOLE COVER OR NEW LAYER OF ASPHALT. I TOOK THIS TO BE A PECULIARITY OF THE TESLA SUSPENSION COMBINED WITH THE 18 INCH WHEELS. THE SOUND WAS RARE, AS MOST ROADS ARE QUITE SMOOTH AND I MADE IT A POINT TO DRIVE SLOWLY OVER SUDDEN BUMPS. MORE RECENTLY, AS OUR TOWN IS REPAVING, I HEARD THE CLICK MORE FREQUENTLY. ON FATHER'S DAY, WHILE A FRIEND WAS TEST DRIVING THE CAR, HE BEING A CAR GEEK, HEARD THE CLICK, CALLED IT A "CLUNK," AND TOLD ME TO GET IT LOOKED AT. I HAD NOT YET MADE THE APPOINTMENT WHEN SOMETHING SNAPPED ON JUNE 26TH. OVER THE WEEKEND I LEFT VOICE MAILS AND SENT TO TESLA SERVICE AN EMAIL STATING TESLA SHOULD CONSIDER GIVING ME A REPLACEMENT VEHICLE, BUT I WISHED FIRST TO HEAR THEIR REPORT ON WHAT HAD OCCURRED. TESLA SERVICE IN MILFORD IS NOT OPEN ON WEEKENDS. TESLA CALLED ON MONDAY AFTERNOON SEEKING MY INPUT ON WHAT HAD OCCURRED. LATER THAT DAY THEY REPORTED IT APPEARED TO THEM THAT A CRITICAL BOLT HAD NOT BEEN WELDED ONTO THE SUB-FRAME. TESLA SERVICE IN MILFORD ORDERED A NEW SUB-FRAME, PART NUMBER 1044521-00-R, FROM CALIFORNIA. TESLA IS RESEARCHING WHAT OCCURRED.

NHTSA ODI 11337132

THE AUTO STEER IN MY TESLA MODEL 3 FAILED TODAY WHEN THE CAR WAS TURNING ON A CURVY DOWNHILL ROAD. I BELIEVE IT'S BECAUSE THE LANE MARKINGS ON THE RIGHT SIDE ENDED JUST BEFORE THE CURBING STARTED. THE CAR SUDDENLY TURNED RIGHT AND HIT THE CURB BRUSHING THE RIGHT FRONT WHEEL. IT WOULD HAVE BEEN A FATAL ACCIDENT IF I HADN'T TAKEN OVER. AUTO STEER TECHNOLOGY IS NOT YET READY FOR USE ON ALL THE ROADS AND IT SHOULD NOT BE INCLUDED BY DEFAULT IN ALL THE TESLA MODELS. MY CAR DID NOT BRAKE BECAUSE THE CRUISE CONTROL WAS STILL ON. I AM STILL IN SHOCK AND AFRAID TO USE THE AUTO STEER AGAIN.

NHTSA ODI 11297042