What 891 owners told NHTSA about the 2020 Subaru Outback Wilderness

ACC eye sight is intermittent. It normally fails within 5 minutes of operations and just turning the car on.

NHTSA ODI 11611611

The contact owns a 2020 Subaru Outback. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the thermo-control valve. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 90,000.

NHTSA ODI 11609935

The contact owns a 2020 Subaru Outback. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while operating the vehicle with a front seat passenger seated inside the vehicle, the warning message "Air Bag Off" flashed off and on. The cause of the failure was not determined. The failure mileage was 44,300. VIN tool confirms parts not available.

NHTSA ODI 11609648

See attached document for complaint

NHTSA ODI 11609339

The drivers seat is loose, rocking back and forth significantly to the point it very noticeable while driving. The dealer states that this is due to the bottom seat frame being worn out. There are only 41,000 miles on the car, about 37,000 when I first noticed the information. This should not fail so early the car’s life. The dealer is replacing the bottom seat frame at a cost of $1310.

NHTSA ODI 11608654

After an automatic software download update, the RAB off light came on. The RAB light comes on when the car is put in Reverse and provides the option to turn that function off. After the update, the RAB icon is no longer displayed. It is the only system so far that I noticed that malfunctioned after the software update

NHTSA ODI 11607657

We are on our 3rd broken windshield in 3 years. We do not drive the car very often or drive any extreme ways. This is more broken windshields than I have had in my whole life in just a few years having this car. There must be something wrong with the way it’s made.

NHTSA ODI 11606327

This recall for Subaru outbacks has been in effect since March but there is no remedy available yet. I would like to have my car repaired as soon as possible because of safety concerns. Is there a timeline for when a remedy will be available?

NHTSA ODI 11605633

The contact owns a 2020 Subaru Outback. The contact stated that while seated in the vehicle in the driveway of the residence, the front windshield cracked without impact. The vehicle was taken to the dealer; however, the contact was informed that the failure was not caused by a manufacturing defect. The windshield was replaced. The contact stated that the windshield had been replaced three times and was in the process of a fourth replacement. The contact stated that the first three windshield replacements were due to a small gravel striking the windshield. The contact stated that failures had occurred while driving, and it was very scary, she was very nervous when she heard the loud popping sound from the windshield. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 500.

NHTSA ODI 11605167

The Thermal control valve went out in May while I was traveling though Texas, I took it to a dealership right away to see what the issue was and was told once again it was the thermal control valve. When it goes out you have the check engine light come on, the eyesite, and cameras all stop working along with all The warning lights staying on. They replaced it and I was told I should most likely get a refund for when I had the part first replace in July 2021. Which at that time my car was only 7 months old. I was told I would get a reimbursement for that part. However ever since Subaru warranty sent me an approval for reimbursement of this service ( letter dated May 21, 2024 for $1071. 00 that should happen in 30 -45 days, they are now stalling and stating it will be 90 days for checks to be mailed out. This is a faulty part they knew it 3 years ago and failed to handle, now more and more vehicle owners are having the issue, so they will replace the part ONLY if you have any issues. This is fraud on the part of Subaru to their customers.

NHTSA ODI 11604582

This is a safety issue regarding the durability of windshields. I have had 2 incidents now with my 2020 subaru outback having a cracked windshield. Both times it came on suddenly with at least a foot long crack or more the first time and an 18 inch crack the second time just recently. I reported the incident to the service manager this time and he put me in touch with customer advocacy at subaru who is waiting for a report from the diagnosis on Monday, July 22. The first crack was in March 2024. Prior to the crack happening, I noticed a drip of dried substance running down the inside of my windshield from the top of the windshield. I thought it must be sealant and was going to contact subaru. However, without warning, I pulled out of my garage one morning to find a crack across the driver side of the windshield at least a foot or longer. There had been no incident of any rock hitting my windshield that I noticed and there was no damage to the paint on frame close to where the crack started which was on the outer edge of the windshield. The crack grew larger and crossed over the driver's visibility. I asked if there had been a recall since I thought this was odd and spontaneous but there was none. The service repair person said if a rock chip occurs in the defroster area in the perimeter of the windshield, the windshield will sustain a long crack. So I believed that something like that must have happened in my lack of knowledge of prior issues with subaru windshields. I had a $1000 deductible on my insurance and the repair was over that. Subaru refused to negotiate with State Farm to reduce the price so I paid the entire amount out of pocket. The second crack occurred while I was driving in the rain. I turned off my wipers to find an 18 inch long crack on the passenger side of the windshield starting at outer edge of glass. No incident of a rock chip, no damage to paint on frame.

NHTSA ODI 11603641

The contact owns a 2020 Subaru Outback. The contact stated while driving at various speeds, the vehicle stalled without warning. The contact stated that the battery was replaced several times; however, the failure persisted. The vehicle was taken to a local dealer, where it was determined that the battery was not big enough for the turbocharger installed in the vehicle. The battery was replaced; however, the failure persisted. The contact also stated that while driving at undisclosed speeds, the driver's side seat moved forward and backward unexpectedly. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000. The VIN was not available.

NHTSA ODI 11603195

On [XXX], I was driving east on [XXX] on the North side of Toledo Ohio close to the intersection with [XXX] . The "Check Engine" warning came on, all the vehicle "Eyesight" functions were automatically turned off, and Pre collision braking and Pre collision throttle control features were activated. There was no danger of a collision at this time, but all of this left me stranded in the middle of this busy four lane highway. I was able to literally crawl to the shoulder of the road. I was not hit, but it was just good fortune that prevented that. This is where my safety was at greatest risk. After about 10 minutes during which I started and stopped the car numerous times, the pre collision braking and throttle were deactivated and I was able to drive the car. I located the nearest Subaru dealer (Yark Subaru Toledo, Ohio) and drove there. The cause of the Check Engine light was diagnosed as a failure of the Thermal Control Valve. I had received a letter from Subaru dated May 1, 2024 stating that this part might fail and extending the warranty for this part. That letter specifically stated that nothing needed to be done until the part failed. There was no mention of the fact that the car would be disabled when it happened. Part was eventually replace on July 1, 2024 two days later. Since then I have spoken to 3 people at Subaru of America seeking to understand why a Check Engine situation caused the vehicle to be disabled. I also asked the Service Advisor at Yark Subaru to explain. They have all been friendly and attentive, but they cannot or will not give an explanation. My main concern is that a Check Engine situation may cause this Pre Collision shut down to happen again. Based on the danger I was in when this happed, I think that there should have been a recall and the Thermal Control Valve replaced before failure. To be clear, the repairs were completed under warranty and Subaru has sent me a $350.00 coupon for future service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11602880

I am on my 4th windshield on a 2020 Subaru Outback

NHTSA ODI 11601773

The contact owns a 2020 Subaru Outback. The contact stated that while the vehicle was parked, the front windshield unexpectedly shattered. There was no impact to the windshield that could have caused the windshield to shatter. The vehicle was taken to the dealer, who suggested that the contact file a claim with the insurance company to replace the front windshield. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 90,000.

NHTSA ODI 11600910

Hi: When I was driving yesterday, the engine warning light and brake warning light both turned on. The car was like frozen on the road cannot be moved no matter how to press the gas pedal. The police helped to call tow and move my car out of the road. The tow driver left my car at a flat parking lot. On the lot, when I tried to restart my car, the car started to shake side to side and up and down. I can feel some part is dislocated and one piece of heavy thing was swaying in the car. The engine warning light was on for two times during the last two years. First time when I sent the car to the dealership, they performed the check and fixed it by free. The customer service person told me the problem is the sensor failing and the fixing was free. So, I guess it is the system defect and the manufacture already knew it. So the repairing was free. However, with one year, the situation happened again. The second time I sent the car for fixing, the service person told me it was the same problem of sensor failing but they charged me around two hundreds dollar for the second time fixing. Yesterday, the same situation happened again with the brake warning light on at the same time. It is almost another one year after the second time I sent car for repairing. My most concern is the car completely suddenly stopped during the driving. If I was on the highway, serious collision may happen and I am already passed away.

NHTSA ODI 11599179

Rear trunk door won’t lock when closed and open up while driving. It’s unsafe as I have to constantly keep an eye in rear view mirror to see if door popped open by itself. Took to service station and they said it’s tied to battery and it is preventing door to close because trunk door takes power to open. I do not understand how trunk door locking close cannot be independent of battery. It is quite unsafe for vehicle occupants and poses danger to other vehicles driving behind.

NHTSA ODI 11598286

I have a occupancy sensor error which has turned off the airbags on the passenger seat. I looked up the issue and found an open recall with Subaru regarding this issue. I spoke with multiple case managers to resolve the issue. They said they have reported the issue to NHTSA but it is not an active recall because they have yet to find a solution. So they have no responsibility to fix the issue at this time. They are unwilling to provide me with an alternate option than driving my car with the exact issue they issued the recall for.

NHTSA ODI 11598077

The contact owns a 2020 Subaru Outback. The contact stated while turning off the vehicle, the Data Communication Module (DCM) remained running, causing the battery to become drained twice. The vehicle was taken to a local dealer but was not yet diagnosed. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 25,000. The VIN was not available.

NHTSA ODI 11596406

Spontaneous windshield cracking

NHTSA ODI 11595191

Display to control the environment freezes.

NHTSA ODI 11594771

The contact owns a 2020 Subaru Outback. The contact stated while the vehicle was parked, he became aware that the passenger’s side of the windshield was severely cracked. The dealer was contacted but the vehicle was not repaired. The contact was concerned that the vehicle was a safety hazard and could cause severe injuries to occupants in the vehicle. The manufacturer was notified of the failure and referred the contact to the Insurance Provider for assistance. The approximate failure mileage was 34,000.

NHTSA ODI 11594398

Windshield Cracked on vehicle, this is the 2nd incident and second full windshield replacement In 2 years, noth OEM.

NHTSA ODI 11594153

A small horizontal crack recently appeared on my Outback's front windshield while it was sitting in a garage overnight. The crack started from the passenger side and has now crept over to the middle of the windshield. Previous to this incident, the car had been sitting unused for over a month, so there was no opportunity for rocks or other debris from the road to cause the crack. This is the second time that the windshield has developed a crack out of thin air. I have replaced the windshield at least five times since owning the vehicle, in addition to having small chips from rocks repaired twice. These incidents are potentially dangerous and could possible interfere with the vehicle's automated systems such as collision detection and cameras.

NHTSA ODI 11592368

As my husband & I were traveling to Augusta, GA on Memorial Day weekend with our niece, we approached the [XXX] outside Chattanooga, Tennessee in heavy traffic and heavy rain on Saturday [XXX] 2024 at approximately [XXX] When we stopped for a small accident ahead of us, the “auto stop-start engine” feature stopped the car engine as normal. However, almost instantly, all of the electronics in the car appeared to fail and the car would not restart. The dashboard indicated that Eyesight and RAB were disabled and to "check the owner's manual." Normal traffic quickly resumed around us, but we were stranded in the #2 lane with several close calls of a rear-end collision--not to mention the cars at risk swerving to avoid us. My husband is a retired firefighter & our niece is a nurse in Los Angeles. Frankly, we were terrified! We were stranded on the interstate in the #2 lane for about 20 minutes before being pushed into the "gore zone" between [XXX] & [XXX] by a TDOT truck. We spent about 40 minutes in the gore zone where we were nearly hit twice by cars driving across the zone. We were finally towed to Crown Subaru in Chattanooga, TN and arrived there about 11:40 a.m. The general manager of the dealership, Keith Aviles, told us there was a sudden, massive failure of a battery cell controlling the electronics of the car, and the battery was replaced. We never had any indication or evidence prior to this incident that there were issues with the battery. Also, we have never received a notice from Subaru about battery problems. However, we are now aware that Subaru settled a class action lawsuit to avoid a recall of these batteries. I have notified six friends who own Subarus. Three have had issues with their batteries, but were also unaware of the class action lawsuit. This is absolutely shocking for a vehicle manufacturer that touts safety to sell vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11590991