What 122 owners told NHTSA about the 2020 Mercedes-benz GLE

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that the vehicle started to display failures with the air conditioning system blowing hot air. The vehicle was taken for inspection at a local dealer, and the contact was informed that the vehicle was experiencing electrical failures due to water entering the footwells, with the check engine warning light remaining illuminated. The vehicle was diagnosed, and the contact was informed that the air conditioning was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 44,000.

NHTSA ODI 11685763

Both left and right headlamp/turn signal/marker light assemblies and control modules have been replaced. One under warranty in 2023, the second in 2025. Infotainment system displays error messages Messages may increase as assembly/control module becomes increasingly dysfunctional.

NHTSA ODI 11683243

The vehicle recently experienced a cylinder head failure, confirmed by a diagnotic code P0302 (Misfire in cylinder 2), resulting in rough idling, reduced power, and potential safety risks during opreration. This issue appears to be a known defect in the M264 engine, as evidenced by similar complains from owners of GLE 350, GLC 300, and other models on forums like [XXX] and [XXX] . The failure occurred just beyond the standard 4-year/50,000-mile warranty, and Mercedes-Benz USA denied my request for a goodwill repair despite acknowledging similar issues in related models under extended warranties. Repair costs are estimated $8,000 to $13,500. I believe this defect warrants investigation due to its prevalence and potential to cause sudden power loss, which could lead to hazardous driving conditions. I urge NHTSA to investigate the M264 engine in the 2020 GLE 350 for a possible recall to protect owners and ensure safety. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11679991

Transmission Control Module / Valve Body failure occurred at 44,000 miles

NHTSA ODI 11676298

My car shook while idling the last two weeks of June 2025. It felt like it was going to shut off at light/stop sign which it did on two occasions. On July 2, 2025, it stalled abruptly during a drive after which I took it to Mercedes for service. I never received a warning signal or fault message even after it stalled. Mercedes service indicated the engine cylinder head valves were burnt and not sealing properly - estimated cost of repair $10,023.00. I am the original owner of the car, had routine maintenance and only had it performed at Mercedes. My car stopped without warning- but luckily on a local road. Others who are driving with this defective engine may not be so lucky. It appears this is a known issue to Mercedes USA but they have not done anything to fix it. The engine is M264. Even if valves are replaced, this problem may continue to occur as the Mercedes serviceman does not know what caused the burnt cylinders - just that they needed to be replaced and that it was not wear and tear. Not sure if this is related, but there was a 2022 recall on this engine (my car was not part of batch that was recalled) regarding turbo charger oil feed and return lines. The issues included engine vibration at idle and loss of power.

NHTSA ODI 11674209

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at low speeds, the vehicle entered LIMP Mode but continued to operate with reduced motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed the vehicle with engine control unit failure causing the engine to run lean, resulting in misfires in cylinders #1 and #2 and damage to the engine. The contact was informed that the engine had failed a pressure test and needed to be replaced. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was towed to the dealer, who confirmed the diagnosis and determined that the failure could be resolved with a top end engine replacement of the cylinder head, valves, valve springs, rocker arms, camshaft, spark plugs, and valve cover. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 71,000.

NHTSA ODI 11672802

The rear shock absorbers have failed on my vehicle. The vehicle makes sounds when going over bumps in the road. There is an active recall on other GLE 2020 450 models but not my specific VIN. The vehicle has less then 30,000 miles on it before the shock absorbers went out.

NHTSA ODI 11672426

I purchased my 2020 Mercedes GLE 350 new with only 12 miles on it. I also purchased an extended warranty which gave me 100,012 miles. On a Friday evening while being driven, the engine light came on. I took the truck immediately to the dealership on Monday morning. Prior to that the engine would roar loud upon starting on some occasions then calm down. When I mentioned it to the service department on previous service visits they told me it was fine and they notice that, that particular model does that when it gets hot outside. The vehicle also quit on me in the middle of the road before starting back up in about 3 minutes but on a separate visit. ALL my maintenance and service have ALL been done at the Mercedes service department so I'm confused how this happened. So, the dealership needed an extra day to diagnose so after 2 days I was hit with the news that is was a cylinder head...$9,963. I had 108,152 (out of extended warranty) miles on my truck. I notice this is a common issue with this particular year and model GLE350. I also see that Mercedes has a recall on other models just not this one. A recall is needed immediately. I pray this complaint will help others that will experience this same issue in the near future because there's no help for me now.

NHTSA ODI 11670108

Hi! I just received word that my 2020 GLE350 will need a replacement cylinder head. I went to the dealership due to having a check engine light on (light came on this morning and I promptly brought to the dealership). It is an $8,000 repair. Upon doing a quick websearch for replacement cylinder heads for 2020 GLE350s, I am finding a lot of people in web groups reporting that they are having the exact same issues for the same model (2020-2022) right after the 50,000k mileage mark (out of warranty). I have always done my maintenance directly with the dealership. Links to the chat forums with similar issues - can pull up more if needed. [XXX] Let me know if you need additional information - thank you! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11666722

Strong raw gasoline odor in cabin, making passengers “light headed”. Called dealer about a fuel system recall on this model however they said my vin number didn’t fall under the recall.. no warning lights are on

NHTSA ODI 11663764

Bought a 2020 Gle 350 used with 55000 miles on it. Within 3 weeks the check engine light comes on and the car goes into limp mode. Cannot drive it. Took it to Mercedes of Wilmington. They said it was a misfire on 4. They replaced all spark plugs and the coil to cylinder 4. Another month later the same thing happens. Took it back to Mercedes. Stated the car needs a new cylinder head at the cost of 12000$. This seems to be a common problem on these vehicles. A recall is needed immediately

NHTSA ODI 11661806

At 48,000 miles the cylinder head needed replaced. This was done under warranty. At 73,000 miles the engine started making a horrible noise and power was lost and acceleration very choppy. Had it towed to the dealer. Dealer diagnosed the issue as a Rod bearing failure and requires the engine to be fully replaced. This occured while driving, fortunately I had just gotten off the highway, otherwise the vehicle would have lost acceleration and speed and would have created and unsafe situation. The engine light never came on, neither before or after the noise and loss of acceleration.

NHTSA ODI 11660868

The rear seat belts are faulty. I had to pay out of pocket for the rear middle seat belt repair and now the rear right side is faulty and does not budge or move pass a point. I am concerned that each time these do not work, I will be out another thousand dollars for repair. Seat belts on some of my oldest cars continue to work. This should not be happening especially to a newer vehicle. I need help and by that I want Mercedes to cover the cost. It's very stressful. Thank you for hearing my concern.

NHTSA ODI 11658932

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that while driving at various speeds, the vehicle lost motive power when the check engine warning light was illuminated. Additionally, on one occasion, the vehicle failed to start and was towed to the dealer, who was unable to identify the cause of the failure. The vehicle was not repaired. The cause of the failure was not yet been determined. The manufacturer was notified of the failure. The failure mileage was 50,000.

NHTSA ODI 11659016

Turbo oil separator blocked, causing internal pressure pushing oil out of the rear main crankshaft seal. Since the oil level is monitored electrically (no dipstick), the engine can run out of oil, resulting in catastrophic failure while driving, causing a dangerous condition or accident

NHTSA ODI 11655926

Coolant pipe under intake manifold made of plastic leaking, could have caused engine overheating and failure in traffic conditions. New style pipe supplied by manufacturer is now made of steel, dealer had in stock indicating a repetitive problem.

NHTSA ODI 11654882

Cylinder misfire at low mileage with very costly repair.. Vehicle needs cylinder head.

NHTSA ODI 11653696

When operated with driver assist and stop and go assist, the car, often slams the brakes for no reason in the middle of the highway. I have reported this problem multiple times to the dealership and the dealership has kept the car in for investigation multiple times sometimes for more than two weeks. They were able to replicate the problem, but they had absolutely no solution. It’s been a few years now and it keeps happening. This is a liability issue us cars behind me are at risk to collide.

NHTSA ODI 11650987

48V battery issue cause the car not able to drive.

NHTSA ODI 11650369

My vehicle has developed problems related to the cylinder head, leading to persistent misfires, rough idling, and an illuminated check engine light. Upon diagnosis at an authorized Mercedes-Benz service center, it was determined that the cylinder head requires replacement

NHTSA ODI 11643185

The air conditioner is constantly leaking refrigerant due to a potential damaged hose which is a known issue for Mercedez-Benz SUVs. I contacted the dealership who advised this is not an issue currently being addressed by the manufacturer and would be at the cost of the vehicle owner.

NHTSA ODI 11640685

As many other GLE 350 owners reported on various forums, same thing happened to me. My car suddenly started shaking and some cylinders misfiring. My car is just 2020 and barely got 60,000 miles on it. Initial report shows that two cylinders misfires with no reason. It's failing the emission and car will not pass emission test anymore. Mercedes says it's out of warranty and asking 15k to replace cylinder head.

NHTSA ODI 11636187

There had been multiple incidents where the battery dies. We had issues where the vehicle would not start. We do not get any warning error message before this happens. We make sure all doors are closed and all lights are off. We’ve had to tow the vehicle multiple times when the battery fails. This has left us stranded on multiple occasions. In addition we have taken it for service at the Mercedes dealership and they state that there is nothing wrong with the battery or the vehicle. They have suggested to replace the battery in 2022. At the moment the vehicle does not turn on and we have to find other transportation options to get around.

NHTSA ODI 11630388

Water intrusion. It rained, water leaked into driver seat floor. The water then made it to the electrical parts underneath the driver seat. This seems identical to the recall I am seeing online with the number: 23V-177

NHTSA ODI 11628758

The contact owns a 2020 Mercedes-Benz GLE350. The contact stated that on several occasions while the ON/OFF system was activated, while making left and right turns and then stopped the vehicle stalled. The vehicle was shifted into park(P) and restarted after each failure. The vehicle was idling and the engine sputtered and ran rough. Additionally, the contact stated that while idling, the vehicle shuddered and ran rough on several occasions. The vehicle was taken to a dealer where it was diagnosed that the exhaust valve seats needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ODI 11624078