What 173 owners told NHTSA about the 2020 Hyundai Tucson Fuel Cell

High excessive oil consumption and premature piston ring failure leading to excessive oil consumption

NHTSA ODI 11752334

Tried passing someone on the thruway, as I was about to the car jerked a bit then started decelerating. The check engine light started flashing and so did the oil light. Read the code as cylinder 3 misfire and a knock sensor. Changed the spark plugs and coil packs then checked the oil and saw there was no oil in the engine. Was told by my mechanic it’s a common problem with these Hyundai engines, it seems the rings are getting fried in the engine and that’s why it consumes oil so quickly.

NHTSA ODI 11751269

While driving on the highway with adaptive cruise control on, car began decelerating without any vehicle in front. Started to get off highway, check engine light began flashing and came to a full stop. Car died. Tried restarting and car died. Check engine, oil and battery lights then on. Total engine failure and no warning lights prior.

NHTSA ODI 11750442

Vehicle is a 2020 Hyundai Tucson with a 2.4 liter engine: Theta II GDI. Vehicle was purchased new and maintained properly. Excessive oil consumption began at about 50,000 miles. Vehicle was purchased in early 2020 and therefore has an engine manufactured in 2019. Tucson vehicles with this engine from 2011 through 2019 were recalled for engine problems including excessive oil consumption and rod bearing failure possibly resulting in engine fires. If engines were not replaced an extended warranty was given for 150,000 miles or 15 years. Hyundai will not remedy our excess oil consumption problem locally or nationally. An oil consumption test was done at the Hyundai dealer. Conclusion: by dealer and national level office: it's not bad enough to remedy. There were no engine warning lights activated because we check the oil regularly and add as needed. This post-2019 2.4 liter engine continues to be a hazard as some owners from previous year's models had engine seizures in traffic which is dangerous. Some owners reported engine fires. We have not experienced those tragedies but possibly post-2019 Tucson owners should be alerted to potential dangers.

NHTSA ODI 11747239

I am reporting a serious safety issue involving diagnostic code P1326. My vehicle developed engine knocking and little to no acceleration and appeared to enter a reduced-power or limp-mode condition while driving. This made it difficult to merge, maintain speed, and travel safely in traffic, creating a risk of collision or becoming stranded in an unsafe location. Based on publicly available Hyundai materials, code P1326 is associated with the Knock Sensor Detection System (KSDS) and may indicate abnormal engine vibration, possible bearing-related engine damage, and reduced-power operation. Those materials also indicate that certain vehicles were eligible for software updates, inspection, and possible engine repair or replacement. I request that this issue be documented as a safety complaint and that the dealership perform a full diagnostic inspection, determine whether my vehicle qualifies for any applicable campaign or warranty extension, and provide appropriate repairs.

NHTSA ODI 11744527

The engine consumes oil which is a known problem at Hyundai with the Tucson for the year 2020. The car has ~51,000 miles on it. When we took the car to the dealer at which we bought the car they diagnosed that the engine was burning oil. We were told that the engine is covered by standard warranty (10 yr. 100,000 miles). there is a process Hyundai has established for engines suspected of having this issue - first we had to have them check the oil and engine and then we had to drive the car 1000 miles and bring it back to them. when we brought it back they confirmed the the engine was consuming oil. They asked us to provide our maintenance records on the car (oil changes). We were able to find evidence of 5 oil changes but we know the we changed the oil on the car every 3-5k miles as we always do. The next step in the process is a combustion chamber cleaning which costs $1400 which would normally be covered by warranty but since we did not have all records of oil changes they will not cover it so we are being told we have to pay the $1400 out of pocket and also the the cleaning is not assured to fix the issue with the engine. If it fails to fix the issue the car will need a new engine which Hyundai is telling us they will not do under the warranty and it will be our financial obligation ($10-15K additional paid by us). It is clear that Hyundai is trying to shirk their warranty obligation to us. So we are stuck - we have to pay out of pocket for a service that may not resolve the issue and if it does not the car needs a new engine. If we sell the car back to the dealership they will only pay us $6000 when the car with a good engine is worth $15K. We take our obligation of regular maintenance seriously and have been loyal buyers at this dealership for >20 years never having an issue with proper maintenance. We think it unconscionable that Hyundai is leaving us holding the bag for a problem they know exists with theses engines

NHTSA ODI 11742588

I recently purchased a 2020 Hyundai Tucson with a Nu 2.0 GDI engine. Shortly after purchase the engine completely failed and requires full replacement. When taken to a Hyundai dealership, they pulled an internal STUI report showing A95 branding, meaning Hyundai had previously denied warranty coverage blaming the prior owner for outside influence. This A95 designation does not appear on any consumer vehicle history report including Carfax or AutoCheck. I paid $13,500 for this vehicle with no knowledge of this engine history. The Nu 2.0 GDI engine in this vehicle is specifically named in Hyundai’s class action settlement. Hyundai is using internal branding to avoid responsibility for a known manufacturing defect while allowing these vehicles to re-enter the used car market with clean vehicle history reports, leaving consumers completely unprotected.

NHTSA ODI 11742153

While driving, the engine began making a loud knocking/rattling noise and the check engine light began flashing. The vehicle experienced a loss of power and was unsafe to continue operating normally. The vehicle was taken to a Hyundai dealership for diagnosis. The engine requires replacement. Hyundai denied coverage, claiming excessive oil consumption and/or maintenance concerns. However, upon inspection, the dealership removed the valve cover and advised that the engine was internally clean and showed no significant sludge buildup consistent with severe neglect. I am concerned that this engine failure may be related to known Hyundai engine issues involving the 2.4L GDI engine. The failure occurred well before the expected service life of the engine and created a potential safety hazard due to the loss of power while driving. I am requesting that NHTSA review this failure and determine whether similar failures are occurring in 2020 Hyundai Tucson vehicles equipped with the 2.4L GDI engine.

NHTSA ODI 11741423

I have had the car in twice to the mechanic within the last 6 months for check engine light. He said I keep loosing oil, but there is no leak and it's something with the Engine. Hyundai will not recall the engine, but I see so many people are having the same issue. On a 2020 vehicle, you should not have engine issues. At what point do they have a recall on this issue, as so many are reporting the same thing.

NHTSA ODI 11739459

ABOUT 18 MONTHS AGO, SOON AFTER AN OIL CHANGE AT THE DEALERSHIP, I CHECKED THE DIPSTICK. IT SHOWED LOW OIL AND I ADDED SOME. IT MADE ME THINK THAT THE DEALER HAD SHORTED THE OIL. NEXT OIL CHANGE, I HAD THEM SHOW ME THE OIL WAS FULL. IT SHOWED LOW FULL. I'VE BEEN CAREFULLY CHECKING THE OIL EVER SINCE AND HAVE CONTINUED ADDING OIL IN BETWEEN OIL CHANGES. 8 OR SO MONTHS AGO, I HAD THE OIL AND FILTER CHANGED. I MENTIONED THE PROBLEM TO THE MECHANIC AND HE SAID HE WAS AWARE HYUNDAI'S LOSE OIL. SINCE THEN, I HAVE CONTINUED TO ADD A HALF QUART AT LEAST ONCE A MONTH. I PARK ON CONCRETE AND THERE IS NO SIGN OF LEAKING OIL. I STARTED RESEARCHING THIS ISSUE AND FIND IT IS AN ONGOING PROBLEM WITH 2020 TUCSONS. I AM VERY CONCERNED WITH ENGINE DETERIORATION, SAFETY AND OIL LOSS.

NHTSA ODI 11724454

My car has been burning through about 2 quarts of oil every 1000 miles. Hyundai will NOT replace the engine. If this continues My engine could malfunction while driving. This is a serious safety concern and there's plenty of information on it. They refuse to recall it.

NHTSA ODI 11723433

Complete engine failure. Car was burning oil, wasn't aware. Since I am an on the road salesman I travel alot and get oil changes consistently. Then recently the engine oil light keeps coming on when rounding bends or stopping on a hill. I checked the dip stick and see oil is Half gone in between oil changes. The car stalled as I was approaching a dangerous intersection. Thankfully I was able to stop the car.

NHTSA ODI 11721101

burning oil at a rate of 2 qts per 1000 miles driven. Known issue in these models of tucsons. Not covered by the class action lawsuit as this VIN was not identified. It is burning oil at a catastrophic rate. The problem has burned through multiple catalytic converters that were covered under the warranty but did not solve the underlying problem. Has been burning oil since owning the car a year ago.

NHTSA ODI 11720931

I have a 2020 Tucson Sport with 82k miles. Since new, it consumes 1US qt. of oil every 6 month, although I religiously do the tune-up on its recommended intervals using only Mobil 5w-20 synthetic oil. What can I do?

NHTSA ODI 11718503

Component: Engine / Electrical System / Fuel System Incident Date: February 9th, 2026 Vehicle Speed: 45-50 MPH Description: While traveling at highway speeds on a major roadway, the vehicle experienced a catastrophic and sudden engine stall without any prior warning or dashboard indicators. The engine shut off completely while in motion, resulting in an immediate and total loss of power steering and power-assisted braking. I was forced to perform a high-effort emergency maneuver in heavy traffic to reach the shoulder and avoid a collision. This vehicle is used to transport myself, my coworker and my family whose lives was placed in immediate danger by this failure. Since the start of the financing agreement, this vehicle has a documented history of recurring sensor issues and failed repair attempts at the dealership (Route 1 Hyundai). The dealership has previously attempted to address electrical/sensor malfunctions, but the root cause remains unresolved, leading to this life-threatening stall. I believe this is a significant safety defect in the vehicle’s electrical or fuel management system that poses an unreasonable risk of accidents and injury.

NHTSA ODI 11716919

This engine has 70,000 miles on it and has burned a quart of oil every 2500 to 3000 miles, two full quarts between oil changes. In talking to others Hyundai owners, they have similar issues. I have owned multiple other brands of vehicles with well over 150K miles and they did not burn any oil. Fords, BMWs, Volvos, and Subarus.

NHTSA ODI 11715563

2020 HYUNDAI Tucson Engine blown @ 89,307 miles and 1,265 miles after oil change due to missing oil plug. Daughter drives about 5 miles per day for college and groceries. The day before Thanksgiving 2025, her 2020 HYUNDAI Tucson died about 48 miles down the Highway without warning, no prior warning lights or sounds before shutting down. I had the car towed to the local HYUNDAI dealer in the town where her college is, where they told us the engine was totaled due to a lack of oil and a missing oil plug. I discussed with the HYUNDAI service advisor about having an extended warranty; however, they would not work with me or the company I had the extended warranty with, mentioning they would not cover the engine failure due to the oil plug being missing. I asked the service advisor in a separate conversation whether an oil pan drain plug that was not properly torqued during an oil change could remain in place for some time—particularly during short, low-speed driving—and then gradually work loose over additional miles. The service advisor mentioned that in situations like my daughter’s, where only about 1,265 miles were driven after the oil change (mostly short trips), it would be within reason for an improperly installed drain plug to stay in place until a longer highway drive with higher RPMs, at which point it could back out completely and result in a sudden oil loss and engine shutdown. The service advisor also mentioned that this is something they had seen before and is not unheard of on these vehicles.

NHTSA ODI 11713262

The car has been burning oil for about two years . Noticed when my oil was changed by my mechanic , he told me oil level was about a quart low . Since that time I have had to add oil every 1000 miles . Approximately 4 quarts between oil changes , which I have done every 5 to 6 thousand miles . I have read that many other people have had same problem. This is a 2020 Tucson, Unlimited Model . Which at the time of purchase was the top model Tucson on the lot . Hopefully this is enough information to help get the consumer some Help in this situation ! Thanks

NHTSA ODI 11711727

On December 27, 2025, while driving, the engine suddenly lost power and the vehicle entered limp mode and became undriveable. A warning light appeared and diagnostic code P1326 was later confirmed, indicating engine bearing failure. The vehicle could not be driven safely and required towing to a Hyundai dealership the following day. The engine failure caused a loss of propulsion safety risk. The vehicle remains out of service pending a full engine replacement. The vehicle is available for inspection at a Hyundai dealership.

NHTSA ODI 11710997

Vehicle excessively burns oil, engine drives rough, exhaust developed smoke, burnt smell in engine, engine and oil gauge light comes on.

NHTSA ODI 11701048

The contact owns a 2020 Hyundai Tucson. The contact stated that the vehicle unintendedly shut off while driving. The vehicle was restarted. There were no warning lights illuminated. The local dealer was contacted and scheduled an appointment. The vehicle was not yet diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

NHTSA ODI 11700015

the engine failed without warning. While going up a hill the car lost power. Yes, the dealership said it was a known problem. Yes, the dealership fixed the problem by putting in a new engine which I was responsible for 5% of the cost which was 739.66. The only warning that was given was after the car failed, the engine light and the oil light went on.

NHTSA ODI 11700205

My adult son was driving and under the hood started to smoke. He pulled over and opened the hood to take a look and then a fire started under the hood! The fire department was called and they put out the fire, cut the gasoline and duct taped it up so the fuel line would not further ignite the hot engine. My insurance is looking into what would have caused a random under the hood fire. Luckily no one was injured. However the engine section of the car is melted beyond belief. My insurance has not told me if the car is repairable or not.

NHTSA ODI 11699488

My engine is burning excessive amounts of oil, which is a "known issue" of Hyundai Tucsons. After an oil change with full synthetic oil, I cannot drive my vehicle more than 4,000 miles without reaching dangerously low oil levels. Most importantly, there is no clear indicator of this low oil level—no light that comes on and STAYS on to tell me as the driver to check the oil and see if there is a problem. Instead, if I brake too hard or take a turn to sharply a red oil light will turn on for 1-2 seconds and then turn off again. It is easy to miss. The first few times this happened in May I thought perhaps there was a loose wire on the sensor. After it appeared 3 or 4 times I took it to a mechanic who told me the oil level was so low that they had to add 2 quarts of oil just to have it register on the dip stick. The excessive oil burning is a known issue that Hyundai fights tooth and nail to avoid correcting. But to not have a warning indicator that the oil is at a dangerously low level is reckless on Hyundai's part. The engine could have seized up, thrown a rod, or any number of consequences. I had my oil replaced by Hyundai in May as part 1 of their oil consumption test. My car passed their 1000-mile test and 4,000 miles later I was in dangerously low oil territory again. Thankfully, I knew what to look for this time. Cars should not consume oil at this rapid of a rate but even if they do drivers should be notified about low oil levels via car sensors to keep them and their passengers safe.

NHTSA ODI 11699155

Car was fine and I get regular oil changes. Last week all the sudden the car started making noise and just shut off. When my husband checked there was no oil on the dipstick but I park on concrete and the car is not leaking oil. Apparently the motor is blown and completely locked up.

NHTSA ODI 11697791