What 517 owners told NHTSA about the 2020 Hyundai Palisade Hybrid Hev

I was driving through town at a low rate of speed (20-30 mph) with 2-3 car lengths between me and the next vehicle. I continued through light to next light. This distance was on an upward incline. After traveling approximately 500 ft, I noticed the traffic slowing in front of me and took my foot off the accelerator to start to slow down. This is when the car suddenly accelerated (instead of slowing down as would be expected when traveling up an incline), picking up speed quickly. The car's response happened so quickly that I was unable to swerve to avoid hitting the car in front of me. I hit the car in front of me that was slowing down at the light which then subsequently hit several other vehicles that were in front of it that were also slowing/stopped for the light. The front airbag deployed as a result of the collision, knocking my glasses off. The vehicle was still continuing in forward motion after the collision….Traffic Crash Report states, “... [witness] went up to Unit 1 [Palisade], and the tires were still spinning…” As I was in shock after the collision, a bystander came up to the vehicle to turn it off and this is when the wheels/forward motion was completely stopped. This Palisade is equipped with Forward Collision Avoidance Assist (FCA) system. There was no warning given nor did the vehicle attempt to slow down during the event so I believe that this system failed to operate which contributed to the collision. I also believe that there was a failure with the engine/electrical system, ETC, and/or transmission that caused the system to suddenly accelerate while traveling uphill AFTER I removed my foot from the gas pedal. The vehicle was totaled by my insurance company. They did say that they were sending an engineer to review the Event Data Recorder. I have not seen any results from that nor do I have the vehicle in my possession as it was totaled.

NHTSA ODI 11695696

The contact owns a 2020 Hyundai Palisade. The contact stated that while his wife was attempting to close the trunk manual, there was an electrical shock where her hand came in contact with the trunk. As a result, the contact's wife sustained a minor burn to her left hand. The contact was a physician who confirmed that his wife sustained a second-degree burn and treated his wife for the injury. The contact was able to wrap his wife's hand. A dealer was contacted. The vehicle was taken to the dealer where the diagnosis was unknown. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The approximate failure mileage was 67,000.

NHTSA ODI 11637704